GEA CAIRfricostar - CS Klimateknik

More documents

Recommendations

Info

Safety and User InformationGEA CAIRfricostar2.4 Labelling of safety informationThe following designations and symbols have been used in this manual to designatesafety information:ELECTRICAL HAZARD!This symbol indicates that there is a risk of electrical shock when carrying out certaintask(s).PERSONAL INJURY!Here you will find special information as well as requirements and restrictions for theprevention of personal injury.DANGER FROM ROTATING UNIT PARTS!Here you will find special information as well as rules and restrictions for theprevention of personal injury due to rotating parts of the unit.DANGER DUE TO OVERHEAD LOADS!Here you can find special information as well as rules and restrictions for theprevention of personal injury and damage to units due to falling parts.DANGER DUE TO HOT SURFACES!Here you can find special information as well as rules and restrictions for theprevention of personal injury due to hot surfaces.DANGER OF SCALDING!Here you can find special information as well as rules and restrictions for theprevention of personal injury due to scalding, e.g. by steam.DANGER DUE TO COMBUSTIBLE SUBSTANCES!Here you will find special information as well as requirements and regulations for theprevention of personal injury due to fire.DANGER FROM SHARP EDGES!Here you can find special information as well as rules and restrictions for theprevention of personal injury due to cutting by thin sheet metal.ENVIRONMENTAL DAMAGE!Here you will find special information, rules and restrictions for the prevention ofdamage to the environment including information on any national environmentalprotection regulations in force.DAMAGE TO THE UNIT!Here you will find special information, rules and restrictions regarding the preventionof damage to the unit.8 PR-2006-0019-GB • Subject to modifications • Status 05/2009
GEA CAIRfricostarSafety and User Information2.5 Safety-conscious workingPlease observe the following notes during installation, maintenance and repair work:When working on or around the mains power supplyELECTRICAL HAZARD!All power supply connections must be switched off and checked to see if theyare voltage-free and then secured against unintentional switching on.Earth and short-circuit them and cover any neighbouring electrical conductingparts or isolate them. Failure to do so may lead to serious injury or death.When carrying out any kind of work in general:PERSONAL INJURY!There is a danger of injury when the units are in operation:– Danger of impacts – doors on the discharge side may be flung open– Danger of crushing due to underpressure at doors on suction side– Danger due to rotating parts such as fans etc.DAMAGE TO THE UNIT!If dampers are closed when the system is in operation, the unit componentsmay be critically damaged by under- or overpressure, particularly if thedampers are closed abruptly.DANGER FROM SHARP EDGES!When working on the unit in general there is a danger of cuts being inflicted bythin sheet metal and fins. This applies in particular when carrying out maintenanceand cleaning work on the surfaces of heating and cooling coil fins.Work may only be carried out on the unit if– all poles of the power supply have been disconnected,– the unit is secured to prevent it from being switched back on (also see “Electricalhazard”),– all moving parts – particularly the fan impeller, motor, rotary heat exchanger, controland shut-off dampers – have come to a standstill: wait at least 5 minutes afterswitching off the unit,– the heat exchangers have cooled down to ambient temperature.Once the work on the unit has been carried out, it must be ensured that– all protective devices are functioning effectively – for example, fan protectivedevices (door protection grille, contact protection) must be locked– no persons are present in danger areas.2.6 Proper useThe GEA CAIRfricostar units are exclusively intended for dehumidification, ventilation,air heating and filtering and are primarily applied in private and public swimmingpools.Improper useProper use also includes the observance of the operation manual as well as theinspection and maintenance intervals specified by GEA.Any use other than that described above is considered improper. The manufacturer/supplier is not liable for any damages arising from improper use. The user alone bearsthe risk.PR-2006-0019-GB • Subject to modifications • Status 05/2009 9
Page 1 and 2: Air conditioning of swimming pools
Page 3: GEA CAIRfricostarTable of ContentsC
Page 6 and 7: Safety and User InformationGEA CAIR
Page 10 and 11: Safety and User InformationGEA CAIR
Page 12 and 13: Technical DescriptionGEA CAIRfricos
Page 18 and 19: Transportation and StorageGEA CAIRf
Page 20 and 21: Transportation and StorageGEA CAIRf
Page 22 and 23: AssemblyGEA CAIRfricostar5 Assembly
Page 24 and 25: AssemblyGEA CAIRfricostarFig. 5-4:F
Page 26 and 27: AssemblyGEA CAIRfricostar• Remove
Page 28 and 29: AssemblyGEA CAIRfricostarAdditional
Page 30 and 31: AssemblyGEA CAIRfricostar5.2.4 Asse
Page 32 and 33: InstallationGEA CAIRfricostarNoteTh
Page 34 and 35: InstallationGEA CAIRfricostar6.3.3
Page 36 and 37: InstallationGEA CAIRfricostar6.3.4
Page 38 and 39: Electrical ConnectionGEA CAIRfricos
Page 44 and 45: CommissioningGEA CAIRfricostar8 Com
Page 46 and 47: CommissioningGEA CAIRfricostar8.4 D
Page 48 and 49: CommissioningGEA CAIRfricostarELECT
Page 50 and 51: MaintenanceGEA CAIRfricostar9 Maint
Page 52 and 53: MaintenanceGEA CAIRfricostar9.1.1 B
Page 54 and 55: MaintenanceGEA CAIRfricostarUnit co
Page 56 and 57: MaintenanceGEA CAIRfricostarInitial
Page 58 and 59:
MaintenanceGEA CAIRfricostar• Obs
Page 60 and 61:
MaintenanceGEA CAIRfricostar9.6 Hea
Page 62 and 63:
MaintenanceGEA CAIRfricostarOil and
Page 64 and 65:
TroubleshootingGEA CAIRfricostar11
Page 66 and 67:
GEA CAIRfricostarMaintenance interv
Page 68:
Customer proximity, sales structure
show all

GEA CAIRfricostar - CS Klimateknik

Create successful ePaper yourself

Delete template?

Save as template?