MV BLUEFIN QUALITY MANUAL - Australian Maritime College

Recommendations

Info

Australian Maritime College APPENDIX 2.19 ENGINE ROOM - MACHINERY SOP (OLD) ENGINE ROOM MACHINERY OPERATION REMINDER (STAFF ONLY) Pump out Poop Tank 1. Check the level by gauge rod daily. 2. Open overboard valve located port side next to fire box. 3. Switch sewerage pump to manual. It takes approx 4 mins to empty ½ tank. Do not run dry, leave about 3 – 4” in tank. Record time, position, quantity in log. 4. Do not forget to shut the overboard discharge valve. 5. With vessel alongside, may need pumping every 2 weeks. Accommodation Ventilation 1. One supply fan, two return fans, one galley fan. 2. Recommend all fans be switched off while vessel alongside. 3. All switches are located inside the air conditioning fan room. For total Alarm Panel failure (No Power) 1. Check fuses on 24V DC switchboard (next to galley) and the fuse located on top with white marking (15). 2. If fuse OK, then open the lower power box, turn the top “on/off” power pack switch to off, then back on after 10 secs. 3. Check relays in lower panel box if still no power. Start Domestic Freezer and Chiller Switch on main circuit breaker (direct onto bus bars) and distribution switch on control panel. Close freezer and chiller doors, switch on the main switch and two solenoid valves switches located port side of dry provision store. Check sea water cooling valves are open on fwd S.W. cooling pump. Switch on the S.W. cooling pump first, then switch on refrigeration compressor. To Start Ships Generators 1. Check lube oil sump level, open all S.W. cooling valves, check level fresh water header tank, check fuel supply valve is open, check exhaust drain is closed. 2. Switch to GLOW for 30 seconds, then start engine. 3. Once engine running, check lube oil pressure OK in green range. 4. Wait 5 minutes for engine to warm up. If paralleling, turn synchronising switch to the generator already on load. Append 2.19 - Machinery.docx 1 of 2 Revised: November 2010
Australian Maritime College Change Over from Shore Power 1. Switch shore power breaker to “off”, then move the interlock key (turning anticlockwise) from shore power board and insert in AG 1 & 2 switchboard and turn on (clockwise). 2. Select the main circuit breaker for the generator running, turn synchronising switch to that genset and push down first then lift up for breaker on. 3. The refrigeration circuit breaker might trip off by this change over. If so switch on cooling pump first, then the compressor. Append 2.19 - Machinery.docx 2 of 2 Revised: November 2010
Page 1 and 2:
MV BLUEFIN QUALITY MANUAL Safety Ma
Page 3 and 4:
Australian Maritime College MV BLUE
Page 5 and 6:
Australian Maritime College 18.0 MA
Page 7 and 8:
Australian Maritime College DEFINIT
Page 9 and 10:
Australian Maritime College 1.0 INT
Page 11 and 12:
Australian Maritime College AMC Sea
Page 13 and 14:
Australian Maritime College MV BLUE
Page 15 and 16:
Australian Maritime College Chapter
Page 17 and 18:
Australian Maritime College Chapter
Page 19 and 20:
Australian Maritime College 3.0 SAF
Page 21 and 22:
Australian Maritime College In addi
Page 23 and 24:
Australian Maritime College 6.0 COM
Page 25 and 26:
Australian Maritime College 8.0 AMC
Page 27 and 28:
Australian Maritime College 9.0 PER
Page 29 and 30:
Australian Maritime College 11.0 PE
Page 31 and 32:
Australian Maritime College 13.0 VE
Page 33 and 34:
Australian Maritime College 15.0 WO
Page 35 and 36:
Australian Maritime College Immedia
Page 37 and 38:
Australian Maritime College 18.0 MA
Page 39 and 40:
Australian Maritime College Cultura
Page 41 and 42:
Australian Maritime College • In
Page 43 and 44:
Australian Maritime College No whal
Page 45 and 46:
Australian Maritime College EMERGEN
Page 47 and 48:
Australian Maritime College SHIPBOA
Page 49 and 50:
CHAPTER 2 MV BLUEFIN SHIPBOARD CONT
Page 51 and 52:
Australian Maritime College AMENDME
Page 53 and 54:
Australian Maritime College 2.0 EME
Page 55 and 56:
Australian Maritime College 4.0 DRI
Page 57 and 58:
Australian Maritime College 5.0 FLO
Page 59 and 60:
Australian Maritime College The fol
Page 61 and 62:
Australian Maritime College • If
Page 63 and 64:
Australian Maritime College • Hal
Page 65 and 66:
Australian Maritime College c In th
Page 67 and 68:
Australian Maritime College Immedia
Page 69 and 70: Australian Maritime College 6.13.5
Page 71 and 72: Australian Maritime College APPENDI
Page 73 and 74: Australian Maritime College Alongsi
Page 79 and 80: Australian Maritime College START U
Page 81 and 82: Australian Maritime College JRC JLN
Page 85 and 86: Australian Maritime College MF/HF D
Page 87 and 88: Australian Maritime College MAIN ST
Page 99 and 100: Australian Maritime College 1. CHEC
Page 107 and 108: Australian Maritime College INSTALL
Page 109 and 110: Australian Maritime College ENGINE
Page 111 and 112: Australian Maritime College 3. Pump
Page 115 and 116: Australian Maritime College 1. Pres
Page 119: Australian Maritime College APPENDI
Page 127 and 128: Australian Maritime College PRE-OPE
Page 129 and 130: Australian Maritime College Anchora
Page 131 and 132: Australian Maritime College • Det
Page 135 and 136: Australian Maritime College PRE-EXE
Page 137 and 138: Australian Maritime College Blocks
Page 139 and 140: Australian Maritime College HAULING
Page 141 and 142: Australian Maritime College Warps s
Page 143 and 144: Australian Maritime College While s
Page 145 and 146: Australian Maritime College It is r
Page 149 and 150: Australian Maritime College Once th
Page 153 and 154: Australian Maritime College Once th
Page 157 and 158: Australian Maritime College Port: A
Page 159 and 160: Australian Maritime College Current
Page 161 and 162: Australian Maritime College Cabin 5
Page 163 and 164: Australian Maritime College Fire de
Page 167 and 168: Australian Maritime College PORT RA
Page 169 and 170: Australian Maritime College January
Page 171 and 172:
Australian Maritime College APPENDI
Page 173 and 174:
Australian Maritime College Further
Page 175 and 176:
Page 177 and 178:
Australian Maritime College • Lon
Page 179 and 180:
Australian Maritime College WORK IN
Page 181 and 182:
Australian Maritime College b. Stud
Page 183 and 184:
Australian Maritime College OUTSIDE
Page 185 and 186:
Australian Maritime College FIELD W
Page 187 and 188:
Australian Maritime College MEDICAL
Page 189 and 190:
Australian Maritime College Dear St
Page 191 and 192:
Australian Maritime College WORK IN
Page 193 and 194:
Australian Maritime College Respons
Page 195 and 196:
Australian Maritime College Flowcha
Page 197 and 198:
Australian Maritime College Activit
Page 199 and 200:
Australian Maritime College 2. The
Page 201 and 202:
Page 203 and 204:
Australian Maritime College Job/Tas
Page 205 and 206:
Australian Maritime College Require
Page 207 and 208:
Page 209 and 210:
Australian Maritime College Append
Page 211 and 212:
Page 213 and 214:
Append 7.1 - MV Bluefin Specs & Sur
Page 215 and 216:
Australian Maritime College Vessel
Page 217 and 218:
Australian Maritime College Main En
Page 219 and 220:
Australian Maritime College PUMPS A
Page 221 and 222:
Australian Maritime College CAPACIT
Page 223 and 224:
Australian Maritime College Winch:
Page 225 and 226:
Australian Maritime College SURVEY
Page 227 and 228:
Page 229 and 230:
Australian Maritime College AUSTRAL
Page 231 and 232:
Page 233 and 234:
Page 235 and 236:
Page 237 and 238:
Page 239 and 240:
Australian Maritime College Please
Page 241 and 242:
Australian Maritime College CONTENT
Page 243 and 244:
Australian Maritime College SECTION
Page 245 and 246:
Page 247 and 248:
Australian Maritime College When tr
Page 249 and 250:
Australian Maritime College A sampl
Page 251 and 252:
Page 253 and 254:
Australian Maritime College 3.1.5 S
Page 255 and 256:
Australian Maritime College In case
Page 257 and 258:
Australian Maritime College Further
Page 259 and 260:
Australian Maritime College Plans/t
Page 261 and 262:
Australian Maritime College 3.7 Gen
Page 263 and 264:
Page 265 and 266:
Page 267 and 268:
Australian Maritime College A (SHIP
Page 269 and 270:
Page 271 and 272:
Page 273 and 274:
Page 275 and 276:
Page 277 and 278:
Page 279 and 280:
Page 281 and 282:
Page 283 and 284:
Page 285 and 286:
Page 287 and 288:
Page 289 and 290:
Page 291 and 292:
Australian Maritime College Certifi
Page 293:
show all

MV BLUEFIN QUALITY MANUAL - Australian Maritime College

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?