- Page 1:
FORWARD HOW TO USE THIS MANUAL CONT
- Page 5:
MECHANISM ILLUSTRATIONS LH12W / LH1
- Page 9 and 10:
1. GENERAL INFORMATION The length
- Page 11 and 12:
1. GENERAL INFORMATION When separa
- Page 13:
1. GENERAL INFORMATION Do not let
- Page 18:
Troubles Diagnosis A. Engine hard t
- Page 22 and 23:
Parts to Be Greased Steering shaft
- Page 24:
Precautions in Operation ·····
- Page 30 and 31:
Ignition System Caution C.D.I igni
- Page 32 and 33:
Filling Out Brake Fluid Tighten the
- Page 34:
Side Stand Check side stand spring
- Page 38 and 39:
To this chapter contents 2. MAINTEN
- Page 40:
Precautions in Operation ·····
- Page 46 and 47:
Gear Oil Oil level inspection Park
- Page 48 and 49:
Precautions in Operation...........
- Page 50 and 51:
Trouble Diagnosis Poor engine start
- Page 52 and 53:
Check if the vacuum piston for wear
- Page 55:
4. FUEL SYSTEM Float Chamber Disass
- Page 59 and 60:
4. FUEL SYSTEM Notes: 4-12 To this
- Page 61 and 62:
5. ENGINE REMOVAL Removal of Engine
- Page 63:
5. ENGINE REMOVAL Remove the mounti
- Page 68:
Mechanism Diagram ········
- Page 72:
Remove the 2 cylinder head mounting
- Page 78:
After the valve seat ground, coat v
- Page 82:
Mechanism Diagram ········
- Page 85:
7. CYLINDER/PISTON Piston Removal P
- Page 89 and 90:
7. CYLINDER/PISTON Notes: 7-8 To th
- Page 92 and 93:
Left Crankcase Cover Left crankcase
- Page 94 and 95:
Installation Caution Pull out drive
- Page 96 and 97:
Inspection The weight rollers are t
- Page 98 and 99:
Clutch Outer/Driven Pulley Disassem
- Page 100 and 101: Clutch weight Replacement Remove sn
- Page 102 and 103: Installation of Clutch OUTER/Driven
- Page 104 and 105: Mechanism Diagram ········
- Page 106 and 107: Disassembly of Final Driving Mechan
- Page 108 and 109: Bearing Replacement Caution Never
- Page 110 and 111: Install a new drive shaft bearing o
- Page 112 and 113: Apply with grease onto new oil seal
- Page 114 and 115: Mechanism Diagram ········
- Page 116 and 117: Right Crankcase Cover Removal Remov
- Page 118 and 119: Starting Clutch Inspection Check th
- Page 120 and 121: Flywheel Installation Align the key
- Page 122: Mechanism Diagram ········
- Page 125 and 126: 11. CRANKCASE / CRANK Remove crank
- Page 127 and 128: 11. CRANKCASE / CRANK Assembly of c
- Page 129 and 130: 11. CRANKCASE / CRANK Tighten 4 bol
- Page 134 and 135: System Test Test on the filler cap
- Page 136 and 137: Remove coolant outlet pipe and rese
- Page 138 and 139: Check any wear and damage of the me
- Page 140 and 141: Install the seal washer into the ro
- Page 143 and 144: 12. COOLING SYSTEM Notes: To this c
- Page 145 and 146: 13. BODY COVER Maintenance Body cov
- Page 147 and 148: 13. BODY COVER Handle front cover D
- Page 149: 13. BODY COVER Side cover Remove Lo
- Page 153 and 154: 13. BODY COVER Body cover Remove Re
- Page 155 and 156: 13. BODY COVER Floor panel Remove L
- Page 157 and 158: 13. BODY COVER Use T flex socket wr
- Page 159 and 160: 13. BODY COVER Note: 13-16 To this
- Page 161 and 162: 14. BRAKE Mechanism Diagram-Rear Dr
- Page 163 and 164: 14. BRAKE Trouble Diagnosis Disk Br
- Page 165 and 166: 14. BRAKE Adding Brake Fluid Before
- Page 167 and 168: 14. BRAKE Disk Brake - Caliper Remo
- Page 170 and 171: Master Cylinder Install Install the
- Page 172 and 173: Install brake lining Apply with a t
- Page 174 and 175: Mechanism Diagram ········
- Page 176 and 177: Steering Handle Removal Remove the
- Page 178 and 179: Front Wheel Remove First by the bra
- Page 180 and 181: Installation Open out brake lining
- Page 182 and 183: Steering Stem Remove Remove handle,
- Page 184 and 185: Mechanism Diagram ········
- Page 186 and 187: Muffler Removal Loosen the 2 nuts f
- Page 188 and 189: Installation Install the rear wheel
- Page 190 and 191: Mechanism Diagram ········
- Page 192: Trouble Diagnosis No voltage Batte
- Page 195 and 196: 17. ELECTRICAL SYSTEM Inspection on
- Page 197: 17. ELECTRICAL SYSTEM Ignition Syst
- Page 200 and 201:
Removal of Starter motor Remove the
- Page 202:
Replacing the Front winker light Bu
- Page 206:
Fuel Unit Open the seat. Remove the
- Page 210 and 211:
Home page Contents 18. ELECTRICAL D