- Page 1:
FORWARD HOW TO USE THIS MANUAL CONT
- Page 5:
MECHANISM ILLUSTRATIONS LH12W / LH1
- Page 9 and 10:
1. GENERAL INFORMATION The length
- Page 11 and 12:
1. GENERAL INFORMATION When separa
- Page 13:
1. GENERAL INFORMATION Do not let
- Page 18:
Troubles Diagnosis A. Engine hard t
- Page 22 and 23:
Parts to Be Greased Steering shaft
- Page 24:
Precautions in Operation ·····
- Page 30 and 31:
Ignition System Caution C.D.I igni
- Page 32 and 33:
Filling Out Brake Fluid Tighten the
- Page 34:
Side Stand Check side stand spring
- Page 38 and 39:
To this chapter contents 2. MAINTEN
- Page 40: Precautions in Operation ·····
- Page 46 and 47: Gear Oil Oil level inspection Park
- Page 48 and 49: Precautions in Operation...........
- Page 50 and 51: Trouble Diagnosis Poor engine start
- Page 52 and 53: Check if the vacuum piston for wear
- Page 55: 4. FUEL SYSTEM Float Chamber Disass
- Page 59 and 60: 4. FUEL SYSTEM Notes: 4-12 To this
- Page 61 and 62: 5. ENGINE REMOVAL Removal of Engine
- Page 63: 5. ENGINE REMOVAL Remove the mounti
- Page 68: Mechanism Diagram ········
- Page 72: Remove the 2 cylinder head mounting
- Page 78: After the valve seat ground, coat v
- Page 82: Mechanism Diagram ········
- Page 85: 7. CYLINDER/PISTON Piston Removal P
- Page 89: 7. CYLINDER/PISTON Notes: 7-8 To th
- Page 93 and 94: 8. V-BELT DRIVING SYSTEM/KICK START
- Page 95 and 96: 8. V-BELT DRIVING SYSTEM/KICK START
- Page 97 and 98: 8. V-BELT DRIVING SYSTEM/KICK START
- Page 99 and 100: 8. V-BELT DRIVING SYSTEM/KICK START
- Page 101 and 102: 8. V-BELT DRIVING SYSTEM/KICK START
- Page 103 and 104: 8. V-BELT DRIVING SYSTEM/KICK START
- Page 105 and 106: 9. FINAL DRIVING MECHANISM Precauti
- Page 107 and 108: 9. FINAL DRIVING MECHANISM Inspecti
- Page 109 and 110: 9. FINAL DRIVING MECHANISM Install
- Page 111 and 112: 9. FINAL DRIVING MECHANISM Re-assem
- Page 113 and 114: 9. FINAL DRIVING MECHANISM Notes: 9
- Page 115 and 116: 10. ALTERNATOR/STARTING CLUTCH Prec
- Page 117 and 118: 10. ALTERNATOR/STARTING CLUTCH Remo
- Page 119 and 120: 10. ALTERNATOR/STARTING CLUTCH Remo
- Page 121 and 122: 10. ALTERNATOR/STARTING CLUTCH Inst
- Page 124 and 125: Disassembly of crankcase Remove the
- Page 126 and 127: Crankshaft Inspection Use a thickne
- Page 128 and 129: Install R/L. crank case disassemble
- Page 130: Mechanism Diagram ········
- Page 135 and 136: 12. COOLING SYSTEM Check reserve ta
- Page 137 and 138: 12. COOLING SYSTEM Water Pump Check
- Page 139 and 140: 12. COOLING SYSTEM Install the new
- Page 141:
12. COOLING SYSTEM Thermostat Pleas
- Page 144 and 145:
Mechanism Diagram ········
- Page 146 and 147:
Front cover Remove Loosen 8 screw f
- Page 148 and 149:
Handle rear cover Remover Remove fr
- Page 150:
Front under spoiler Remove Remove f
- Page 153 and 154:
13. BODY COVER Body cover Remove Re
- Page 155 and 156:
13. BODY COVER Floor panel Remove L
- Page 157 and 158:
13. BODY COVER Use T flex socket wr
- Page 159 and 160:
13. BODY COVER Note: 13-16 To this
- Page 161 and 162:
14. BRAKE Mechanism Diagram-Rear Dr
- Page 163 and 164:
14. BRAKE Trouble Diagnosis Disk Br
- Page 165 and 166:
14. BRAKE Adding Brake Fluid Before
- Page 167 and 168:
14. BRAKE Disk Brake - Caliper Remo
- Page 170 and 171:
Master Cylinder Install Install the
- Page 172 and 173:
Install brake lining Apply with a t
- Page 174 and 175:
Mechanism Diagram ········
- Page 176 and 177:
Steering Handle Removal Remove the
- Page 178 and 179:
Front Wheel Remove First by the bra
- Page 180 and 181:
Installation Open out brake lining
- Page 182 and 183:
Steering Stem Remove Remove handle,
- Page 184 and 185:
Mechanism Diagram ········
- Page 186 and 187:
Muffler Removal Loosen the 2 nuts f
- Page 188 and 189:
Installation Install the rear wheel
- Page 190 and 191:
Mechanism Diagram ········
- Page 192:
Trouble Diagnosis No voltage Batte
- Page 195 and 196:
17. ELECTRICAL SYSTEM Inspection on
- Page 197:
17. ELECTRICAL SYSTEM Ignition Syst
- Page 200 and 201:
Removal of Starter motor Remove the
- Page 202:
Replacing the Front winker light Bu
- Page 206:
Fuel Unit Open the seat. Remove the
- Page 210 and 211:
Home page Contents 18. ELECTRICAL D