Manual - Unvented Gas Log Heater or Vented Decorative Appliance

More documents

Recommendations

Info

CDVSC7 & CDV7 Series Gas FireplaceCONTENTSPLEASE READ THE INSTALLATION & OPERATING INSTRUCTIONS BEFORE USING APPLIANCE.Thank you and congratulations on your purchase of a MHSC fireplace.IMPORTANT: Read all instructions and warnings carefully before starting installation.Failure to follow these instructions fully may result in a possible fire hazard and will void the warranty.Important Safety Information..................................... 3Code Approval............................................................. 4Product Specifications............................................... 5High Elevations....................................................... 6Gas Pressures........................................................ 6Gas Specifications, Orifice Sizes............................ 6Fireplace & Framing Dimensions........................... 7Pre-Installation InformationBefore You Start..................................................... 9Fireplace Framing .................................................. 9Fireplace Location................................................ 10Clearances..................................................................11Securing Fireplace to Floor or Framing.................. 12Finishing Material................................................. 12Venting Installation................................................... 13General VentingTermination Location...................................... 13Termination Clearances................................. 15Assembling Vent Pipes.................................. 15Rear Vent Installation Only............................. 16How to Use the Vent Graph........................... 17Vent Pipe Clearances..................................... 18Rear Vent Applications & Installation.................... 19Top Vent Sidewall Applications & Installation....... 20Vertical Sidewall Applications & Installation.......... 22Below Grade Installation....................................... 24Vertical Through-the-RoofApplications & Installation.............................. 25Fireplace Installation................................................ 27Check Gas Type................................................... 27Gas Pipe Installation............................................. 28Check Gas Pressure - Millivolt................................ 29Electrical Installation................................................ 29Electrical Wiring................................................. 29Remote Wall Mounted Switch............................... 30Remote Wall Switch.............................................. 30Optional DC Remote Systems.............................. 30Electronic Pilot Ignition Wiring.............................. 31Optional Fan/Blower Systems.............................. 31Operating Instructions - Millivolt............................. 32What To Do If You Smell Gas............................... 32Lighting Pilot for the First Time............................. 32Lighting Pilot......................................................... 33Lighting Burner..................................................... 34To Turn Off Gas.................................................... 34Operating Instructions Electronic Ignition............. 35What To Do If You Smell Gas............................... 35Lighting Electronic Ignition.................................... 35To Turn Off Gas.................................................... 35Check Gas Pressure - Signature Command System 36Electrical Installation - SCS..................................... 36Electrical Wiring.................................................... 36Junction Box Wiring.............................................. 37Command Center Wall Installation....................... 37Wall Switch Installation......................................... 37Signature Command System Wiring Diagram...... 38Optional Fan/Blower System - SCS......................... 39BLOTSC Wiring Diagram..................................... 39BLOT Automotic Thermostat Blower.................... 40FK-12 Manual Blower........................................... 40Operating Instructions - SCS................................... 41What To Do If You Smell Gas............................... 41Operating Instructions.......................................... 42To Turn Off Gas.................................................... 42Signature Command System................................... 43Operation Instructions.......................................... 43Glass Removal.......................................................... 46Log Placement.......................................................... 46Rockwool Placement............................................ 46Log Placement...................................................... 47Lava Rock and Ember Placement........................ 47Cleaning and Maintenance....................................... 48Burner, Pilot and Control Compartment................ 48Pilot Flame............................................................ 48Burner Flame........................................................ 48Vent System......................................................... 49Glass Door............................................................ 49Logs...................................................................... 49Rock Wool ........................................................... 49Troubleshooting........................................................ 50Replacement Parts.................................................... 54Firebox Components............................................ 54Standing Pilot - Millivolt Control............................ 56Electronic Ignition................................................. 58Signature Command System................................ 59Logs...................................................................... 61Venting Components............................................ 62Massachusetts Requirements................................. 66Warranty..................................................................... 67Energuide Efficiencies............................................. 6869D3011
IMPORTANT SAFETY INFORMATIONINSTALLERPlease leave these instructions with the appliance.OWNERCDVSC7 & CDV7 Series Gas FireplacePlease retain these instructions for future reference.WARNING• Read this owner’s manual carefully and completely before trying to assemble, operate,or service this fireplace.• Any change to this fireplace or its controls can be dangerous.• Improper installation or use of this fireplace can cause serious injury or death fromfire, burns, explosions, electrical shock and carbon monoxide poisoning.This fireplace is a vented product. This fireplace mustbe properly installed by a qualified service person. Theglass door must be properly seated and sealed. If thisunit is not properly installed by a qualified service personwith glass door properly seated and sealed, combustionleakage can occur.CARBON MONOXIDE POISONING: Early signs ofcarbon monoxide poisoning are similar to the flu withheadaches, dizziness and/or nausea. If you have thesesigns, the fireplace may not have been installed properly.Get fresh air at once! Have the fireplace inspected andserviced by a qualified service person. Some people aremore affected by carbon monoxide than others. Theseinclude pregnant women, people with heart or lung diseaseor anemia, those under the influence of alcohol, andthose at high altitudes.Propane/LP gas and natural gas are both odorless. Anodor-making agent is added to each of these gases. Theodor helps you detect a gas leak. However, the odoradded to these gases can fade. Gas may be present eventhough no odor exists.Make certain you read and understand all warnings. Keepthis manual for reference. It is your guide to safe andproper operation of this fireplace.1. This appliance is only for use with the type of gasindicated on the rating plate. This appliance is notconvertible for use with other gases unless a certifiedkit is used.2. For propane/LP fireplace, do not place propane/LPsupply tank(s) inside any structure. Locate propane/LP supply tank(s) outdoors. To prevent performanceproblems, do not use propane/LP fuel tank of lessthan 100 lbs. capacity.3. If you smell gas• shut off gas supply.• do not try to light any appliance.• do not touch any electrical switch; do not use anyphone in your building .• immediately call your gas supplier from a neighbor’sphone. Follow the gas supplier’s instructions.69D30114. Never install the fireplace• in a recreational vehicle• where curtains, furniture, clothing, or other flammableobjects are less than 42" from the front, top,or sides of the fireplace• in high traffic areas• in windy or drafty areas5. This fireplace reaches high temperatures. Keep childrenand adults away from hot surfaces to avoid burns orclothing ignition. Fireplace will remain hot for a time aftershutdown. Allow surfaces to cool before touching.6. Young children should be carefully supervised whenthey are in the same room as the appliance. Toddlers,young children and others may be susceptible to accidentalcontact burns. A physical barrier is recommendedif there are at risk individuals in the house. To restrictaccess to a fireplace or stove, install an adjustablesafety gate to keep toddlers, young children and otherat risk individuals out of the room and away from hotsurfaces.7. Do not modify fireplace under any circumstances. Anyparts removed for servicing must be replaced prior tooperating fireplace.8. Turn fireplace off and let cool before servicing, installing,or repairing. Only a qualified service person shouldinstall, service, or repair the fireplace. Have burnersystem inspected annually by a qualified serviceperson.9. You must keep control compartments, burners, andcirculating air passages clean. More frequent cleaningmay be needed due to excessive lint and dust. Turn offthe gas valve and pilot light before cleaning fireplace.10. Have venting system inspected annually by a qualifiedservice person. If needed, have venting systemcleaned or repaired. See Cleaning and Maintenance,Page 48.11. Keep the area around your fireplace clear of combustiblematerials, gasoline, and other flammable vapor andliquids. Do not run fireplace where these are used orstored. Do not place items such as clothing or decorationson or around fireplace.Continued on page 4
Page 1: Installation and OperatingInstructi
Page 5 and 6: product featuresCDVSC7 & CDV7 Serie
Page 7 and 8: fireplace dimensions & FRAMINGCDVSC
Page 9 and 10: pRE-INSTALLATION INFORMATIONBefore
Page 11 and 12: CLEARANCESCDVSC7 & CDV7 Series Gas
Page 13 and 14: Venting INSTALLATION INFORMATIONCDV
Page 15 and 16: Venting INSTALLATION INFORMATIONCDV
Page 17 and 18: Venting INSTALLATION INFORMATIONHow
Page 19 and 20: Venting installationCDVSC7 & CDV7 S
Page 27 and 28: fireplace installationCDVSC7 & CDV7
Page 29 and 30: CHECK GAS PRESSURE & Electrical ins
Page 31 and 32: Electrical installationCDVSC7 & CDV
Page 33 and 34: millivolt OPERATING INSTRUCTIONSCDV
Page 35 and 36: electronic ignition OPERATING INSTR
Page 37 and 38: ELECTRICAL INSTALLATIONCDVSC7 & CDV
Page 39 and 40: OPTIONAL FAN BLOWER SYSTEMSCDVSC7 &
Page 41 and 42: OPERATING INSTRUCTIONS - SIGNATURE
Page 43 and 44: SIGNATURE COMMAND SYSTEM OPERATION
Page 45 and 46: SIGNATURE COMMAND SYSTEM OPERATION
Page 47 and 48: Log placementCDVSC7 & CDV7 Series G
Page 49 and 50: cleaning and maintenanceCDVSC7 & CD
Page 51 and 52: troubleshootingCDVSC7 & CDV7 Series
Page 53 and 54:
troubleshootingCDVSC7 & CDV7 Series
Page 55 and 56:
eplacement partsCDVSC7 & CDV7 Serie
Page 57 and 58:
REPLACEMENT PARTSCDVSC7 & CDV7 Seri
Page 59 and 60:
Page 61 and 62:
Page 63 and 64:
VENTING COMPONENTSHORIZONTAL VENTIN
Page 65 and 66:
CDVSC7 & CDV7 Series Gas Fireplace6
Page 67 and 68:
Limited lifetime warranty policyLif
show all

Manual - Unvented Gas Log Heater or Vented Decorative Appliance

Create successful ePaper yourself

Delete template?

Save as template?