V92TC V92TC DELUXE - Polaris

More documents

Recommendations

Info

Maintenance 2. Move the sidestand to its stored (up) position and remove the sidestand return spring. WARNING Wear face protection. The sidestand return spring is under tension and can injure your eyes and face when released. 3. Remove the sidestand pivot bolt. 4. Remove any old grease and dirt from the sidestand, frame, and pivot bolt. 5. Lubricate the sidestand and pivot bolt with Victory All Purpose Grease or equivalent. 6. Reinstall the sidestand pivot bolt. Torque: 35 ft -lbs (47 Nm) 7. Move the sidestand to its stored (up) position and reinstall the sidestand return spring. Inspect Sidestand Pad 1. Check the condition of the sidestand rubber pad, and make sure it is firmly attached to the sidestand. 2. Inspect the sidestand rubber pad for wear. Replace the rubber pad if it is worn above the wear limit (see the Victory Service Manual or an authorized Victory dealer). 1 1. Sidestand 2. Rubber Pad 2 112
Check Fasteners Maintenance Visually inspect the entire motorcycle chassis and engine for loose, damaged, or missing fasteners. Tighten loose fasteners to the proper torque (see the Specifications section of the Owner’s Manual, ortheVictory Service Manual). Replace stripped, damaged, or broken fasteners with genuine Victory fasteners of equal size and strength immediately. Road Test Before returning the motorcycle to regular use, road test it in a safe environment. Pay special attention to the proper fit and operation of all serviced components. Make any corrections or additional adjustments as necessary to ensure safe and enjoyable vehicle performance. WARNING Improperly installed or adjusted components can make the motorcycle unstable or hard to handle. Improperly installed electrical components can cause engine or electrical system failure. In either case, damage or serious injury could result. 113
Page 1 and 2:
2002 V92TC V92TC DELUXE
Page 3:
We’ve created a web site, just fo
Page 7 and 8:
Foreword Thank you for choosing a V
Page 9 and 10:
Table of Contents Introduction ....
Page 11 and 12:
Table of Contents Check Evaporative
Page 13 and 14:
Table of Contents Check Wheel Spoke
Page 15 and 16:
Introduction Read the Owner’s Man
Page 17 and 18:
Safety Precautions WARNING Improper
Page 19 and 20:
Safe Riding Practices Follow these
Page 21 and 22:
Safety Precautions Safe Riding Prac
Page 23 and 24:
Safety Precautions Carrying a Passe
Page 25 and 26:
Safety Precautions Example 1: V92TC
Page 27 and 28:
Saddlebags Safety Precautions Saddl
Page 29 and 30:
Product Modifications Safety Precau
Page 31 and 32:
Gasoline and Exhaust Gases (continu
Page 33 and 34:
Safety Precautions Location of Safe
Page 35 and 36:
Safety Precautions Location of Safe
Page 37 and 38:
Motorcycle Description Use the foll
Page 39 and 40:
Motorcycle Description 2 3 1 4 (Del
Page 41 and 42:
Vehicle Identification Number Motor
Page 43 and 44:
Instruments and Controls Ignition K
Page 45 and 46:
Instruments and Controls P (Park) P
Page 47 and 48:
Instruments and Controls If a turn
Page 49 and 50:
Instruments and Controls Instrument
Page 51 and 52:
Instruments and Controls DEFAULT OD
Page 53 and 54:
Instruments and Controls Clutch Lev
Page 55 and 56:
Instruments and Controls Gear Shift
Page 57 and 58:
Side Covers Instruments and Control
Page 59 and 60:
Pre-Operation Check To keep your Vi
Page 61 and 62:
Pre -Operation Check Engine Stop/Ru
Page 63 and 64:
Pre -Operation Check Tires Check Ti
Page 65 and 66:
Pre -Operation Check Check Front Br
Page 67 and 68:
Pre -Operation Check Check Throttle
Page 69 and 70:
Check Steering Pre -Operation Check
Page 71 and 72:
Operation This section describes ho
Page 73 and 74:
Fueling and Fill Height Operation F
Page 75 and 76: Operation Starting the Engine (cont
Page 77 and 78: Operation Shifting Gears (continued
Page 79 and 80: Accelerating Operation To accelerat
Page 81 and 82: Stopping the Engine Operation Befor
Page 83 and 84: Maintenance This section includes i
Page 85 and 86: Maintenance Periodic Maintenance In
Page 87 and 88: Maintenance Periodic Maintenance In
Page 89 and 90: 10. Reinstall the oil fill cap and
Page 91 and 92: Inspect Drive Sprocket and Sprocket
Page 93 and 94: Maintenance 5. Push the plunger upw
Page 95 and 96: Maintenance 6. To adjust the rear w
Page 97 and 98: Maintenance 3. Record the measureme
Page 99 and 100: Front Suspension and Steering Check
Page 101 and 102: Maintenance Fuel System Check Fuel
Page 103 and 104: 3. Loosen the fast idle cable adjus
Page 105 and 106: 10. Reconnect the clutch cable and
Page 107 and 108: Lubricate Front Brake Lever Mainten
Page 109 and 110: Check Rear Brake Pedal Freeplay and
Page 111 and 112: WARNING Maintenance • Do not oper
Page 113 and 114: Maintenance Tires Check Tire Pressu
Page 115 and 116: Check or Replace Spark Plugs The sp
Page 117 and 118: Check Engine Compression An accurat
Page 119 and 120: Battery Maintenance The motorcycle
Page 121 and 122: Maintenance 1. To clean oxidation f
Page 123 and 124: Maintenance Adjust Headlamp The hea
Page 125: Remove and Install Saddlebags Maint
Page 129 and 130: Cleaning and Storage This section e
Page 131 and 132: Caution Cleaning and Storage Use as
Page 133 and 134: Windshield Care Cleaning and Storag
Page 135 and 136: Cleaning and Storage Stabilize Fuel
Page 137 and 138: Cleaning and Storage Maintaining Du
Page 139 and 140: Warranties Motorcycle Noise Regulat
Page 141 and 142: Warranties Manufacturer’s Warrant
Page 143 and 144: Warranties failure occurs prior to
Page 145 and 146: IV. Legal Rights Warranties THIS WA
Page 147 and 148: Warranties Warranty Coverage And Ex
Page 149 and 150: Specifications Model Year 2002 V92T
Page 151 and 152: Specifications Model Year 2002 V92T
Page 153 and 154: Fuel Specifications Specifications
Page 155 and 156: Index A Accelerating, 65 Accessorie
Page 157 and 158: Index D Design characteristics, 4 D
Page 159 and 160: Index Fuel system Checking crankcas
Page 161 and 162: M Maintenance, 69-114 Maintenance i
Page 163 and 164: Index Service intervals, 70 Shift p
Page 165 and 166: Index V Vehicle identification numb
show all

V92TC V92TC DELUXE - Polaris

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?