hybrid operation, maintenance and warranty manual - Steyr Motors

More documents

Recommendations

Info

CLEAN EFFICIENT POWERCheck following parameters on screen „HCU” before continuing with start- procedure:- E-Mode ready = red illustrated,- D-Mode ready = green illustrated,- HCU o.k.= green illustrated- GENER.= green illustrated,- BATTERY = between min.45V/max.57V .NOTE:If parameters are not displayed as described above, follow chapter 4.TROUBLE SHOOTING or contact yourauthorized STEYR MOTORS marine DEALER.5. Push button „E-Mode“ on Hybrid panel as below shown to disengage Diesel engine from Hybrid Generator.E-ModeManualDrive12 VStartE-ModeManualDrive12 VStartE-ModeManualDrive12 VStartE-ModeManualDrive12 VStartCLEAN EFFICIENT POWER11-026CLEAN EFFICIENT POWERIf disengagement-process was successful, below illustrated screen appears on SCC under menu „HCU”Check following parameters on screen „HCU” before continuing with start- procedure:- E-Mode ready = green illustrated- D-Mode ready = red illustrated- HCU o.k.= green illustrated- GENER. = green illustrated,- BATTERY = between min.45V/max.57V11-019STEYR-CONTROL-CENTER49.16.45N 48.08.56N 102.41.11W 014.27.47W 57,4 117 14:05 22:57GENER.SPEED/KN10.0 340,51rpm1,52 310rpm x 1000A455 3 4 43 85 4 85E-Mode ready26 °C bar 525D-Mode ready °C °C20 1090 86 HCU ok15050 120 6HCUOIL/BARRPM2650 15002502500100209870 131548,00E-Speed HCU/CURBATTERYHybrid statustus2,8 6.377.8 E-MOTOR 7350VTEMP/°C120MAINSWITCHHybrid statusE-Mode readyD-Mode readyHCU ok11-016NOTE: When button „E-Mode“ is activated on Hybrid panel it can be noticed audible that Hybrid couplingactuator is disengaging/engaging between Diesel engine and Hybrid Generator- 24 -Z001045-0_1_March 2012
CLEAN EFFICIENT POWER6. To start E-MODE operation, move throttle- lever in forward position.On SCC, menu “HCU”, fi eld “GENERATOR” will change to “E-DRIVE” as soon Hybrid- Generator isturning (see below illustration)STEYR-CONTROL-CENTERR49.16.45N 48.08.56N 102.41.11W 014.27.47W 57,4 117 14:05 22:57GENER.SPEED/KN10.0 340,51rpm1,52 310rpm x 1000A455 3 4 43 85 4 85E-Mode ready26 °C bar 525D-Mode ready °C °C20 1090 68 HCU ok15050 120 6HCUOIL/BARRPM2650 15002502500100209870 131548,00E-Speed HCU/CURBATTERYHybrid statustus2,8 6.377.8 E-MOTOR 7350VTEMP/°C120MAINSWITCHE-DRIVEHybrid statusE-Mode readyD-Mode readyHCU ok11-015NOTE: During E-MODE operation (forward- and neutral- position) and ignition „ON“ warning-light batterychargewill illuminate.Warning- light battery-charge will extinguish as soon as D-MODE operation is started (=Diesel engine rotatesalternator; alternator charges engine’s starter battery)OFFONSTARTHybrid statusE-Mode readyD-Mode readyHCU ok11-003Z001045-0_1_March 2012 - 25 -
Page 1 and 2: HYBRIDOPERATION, MAINTENANCEAND WAR
Page 3 and 4: WELCOME ABOARDCongratulations on yo
Page 5 and 6: TABLE OF CONTENTS1. GENERAL PART ..
Page 7 and 8: 1.2. Product References, Illustrati
Page 11 and 12: 1.15. SymbolsCertain symbols or com
Page 13 and 14: CLEAN EFFICIENT POWERCLEAN EFFICIEN
Page 15 and 16: 2.3 Starting/Stopping a Hybrid Engi
Page 17 and 18: Check following parameters on scree
Page 19 and 20: *) Starting/Stopping the Hybrid- En
Page 21 and 22: Check following parameters on scree
Page 23: 3 442651023 854512060200,51551,5290
Page 27 and 28: CLEAN EFFICIENT POWER1. Move thrott
Page 29 and 30: *) Starting/Stopping the Hybrid- En
Page 31 and 32: CLEAN EFFICIENT POWERCheck followin
Page 33 and 34: CLEAN EFFICIENT POWERSTOPPING HYBRI
Page 35 and 36: CLEAN EFFICIENT POWERVARIANT B:1. P
Page 37 and 38: CLEAN EFFICIENT POWER1.To start the
Page 39 and 40: 3 4 43 85 4265251068 150120 6SWITCH
Page 41 and 42: E-ModeManualDrive12 VStartE-ModeMan
Page 43 and 44: CLEAN EFFICIENT POWERNOTE:In case o
Page 45 and 46: 2.10 Gear Box - InformationNOTE: Yo
Page 47 and 48: CLEAN EFFICIENT POWER2. Ignition ON
Page 49 and 50: CLEAN EFFICIENT POWER• in E-Mode
Page 51 and 52: Instrument PanelHybrid Engines are
Page 53 and 54: • HCU is limiting or stopping cha
Page 55 and 56: CLEAN EFFICIENT POWERMain Switch to
Page 57 and 58: If temperature-values exceed from S
Page 59 and 60: 2.17 Diagnostic systemThe electroni
Page 61 and 62: 2.19 Economy in Electrical-MODE (E-
Page 63 and 64: THIS PAGE IS INTENTIONALLY BLANKZ00
Page 65 and 66: Z001045-0_1_March 2012 - 65 -4.2 Tr
Page 67 and 68: Z001045-0_1_March 2012 - 67 -
Page 69 and 70: 4.3. Reading Service Codes/Alarms f
Page 71 and 72: CODE ABBREV. 150 PINWIREChart -Serv
Page 73 and 74: 5.2. Preparation for Off Season Sto
Page 75 and 76:
THIS PAGE IS INTENTIONALLY BLANKZ00
Page 77:
SERVICENETWORKAUSTRIASTEYR MOTORS G
show all

hybrid operation, maintenance and warranty manual - Steyr Motors

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?