TE450 SM service manual.pdf - Hyosung

More documents

Recommendations

Info

5-9 COOLING SYSTEMTHERMOSTAT◉ REMOVAL● Remove the front fender.(Refer to page 7-3)● Drain engine coolant. (Refer to page 2-12)● Place a rag under the thermostat case.● Remove the thermostat case cap.● Remove the thermostat 1 .1◉ INSPECTIONInspect the thermostat pellet for signs of cracking.Test the thermostat at the bench for control action, inthe follwing manner.● Pass a string between flange, as shown in thephotograph.● Immerse the thermostat in the WATER containedin a beaker, as shown in the illustration.Note that the immersed thermostat is in suspension.Heat the water by placing the beaker on a stove2 and observe the rising temperature on a thermometer3 .● Read the thermometer just when opening the thermostat.This reading, which is the temperature level atwhich the thermostat valve begins to open, shouldbe within the standard value.Thermostat valveoperation temperatureValve openingValve closingStandard76℃ (169℉)71℃ (160℉)23Water
COOLING SYSTEM 5-10● Keep on heating the water to raise its temperature.● Just when the water temperature reaches specifiedvalue, the thermostat valve should have liftedby at least 8.0 mm (0.32 in).Thermostat valve liftStandardOver 8.0 mm at 90℃(Over 0.32 in at 194℉)● A thermostat failing to satisfy either of the tworequirements, start-to-open temperature and valvelift, must be replaced with a new one.◉ INSTALLATIONInstall the thermostat in the reverse order of removal.Pay attention to the following points :● Apply engine coolant to the rubber seal on thethermostat.● Install the thermostat 1 .1● Install the thermostat case cap 2 .● Tighten the thermostat case bolts to the specifiedtorque.Thermostat case bolt: 10 N∙m (1.0 kgf∙m)● Pour engine coolant. (Refer to page 2-12)● Bleed air from the cooling circuit.(Refer to page 2-12)● Install the front fender.2
Page 2:
HOW TO USE THIS MANUALTO LOCATE WHA
Page 5 and 6:
GENERAL INFORMATIONCONTENTS1INFORMA
Page 8 and 9:
1-3 GENERAL INFORMATIONSERIAL NUMBE
Page 10 and 11:
1-5 GENERAL INFORMATION◉ ENGINE C
Page 12 and 13:
1-7 GENERAL INFORMATIONEXTERIOR ILL
Page 16 and 17:
2-1 PERIODIC MAINTENANCEPERIODIC MA
Page 18 and 19:
2-3 PERIODIC MAINTENANCEMAINTENANCE
Page 20 and 21:
2-5 PERIODIC MAINTENANCEVALVE CLEAR
Page 22 and 23:
2-7 PERIODIC MAINTENANCE● If the
Page 24 and 25:
2-9 PERIODIC MAINTENANCECAUTIONTo a
Page 26 and 27:
2-11 PERIODIC MAINTENANCECAUTIONNec
Page 28 and 29:
2-13 PERIODIC MAINTENANCE5. Install
Page 30 and 31:
2-15 PERIODIC MAINTENANCE● Remove
Page 32 and 33:
2-17 PERIODIC MAINTENANCE▣ AIR BL
Page 34 and 35:
2-19 PERIODIC MAINTENANCESTEERINGIn
Page 36 and 37:
2-21 PERIODIC MAINTENANCE● Count
Page 38 and 39:
2-23 PERIODIC MAINTENANCESUSPENSION
Page 40 and 41:
2-25 PERIODIC MAINTENANCEOIL PRESSU
Page 42 and 43:
3-1 ENGINEENGINE REMOVAL ANDREMOUNT
Page 44 and 45:
3-3 ENGINE● Remove the carburetor
Page 46 and 47:
3-5 ENGINE● Loosen the muffler co
Page 48 and 49:
3-7 ENGINE● Tighten the exhaust p
Page 50 and 51:
3-9 ENGINEENGINE DISASSEMBLY● Rem
Page 52 and 53:
3-11 ENGINE● Turn the magneto rot
Page 54 and 55:
3-13 ENGINE● Place a clean rag ov
Page 56 and 57:
3-15 ENGINE● Remove the clutch pu
Page 58 and 59:
3-17 ENGINE● Remove the gearshift
Page 60 and 61:
3-19 ENGINE● Remove the cam chain
Page 62 and 63:
3-21 ENGINE● Remove the crankshaf
Page 64 and 65:
3-23 ENGINE● Install the valve sp
Page 66 and 67:
3-25 ENGINE▣ VALVE HEAD RADIAL RU
Page 68 and 69:
3-27 ENGINE▣ CAMSHAFT JOURNAL WEA
Page 70 and 71: 3-29 ENGINE▣ CAM CHAIN AND CAM CH
Page 72 and 73: 3-31 ENGINE▣ PISTON RING-TO-GROOV
Page 74 and 75: 3-33 ENGINECRANK BALANCER AND BALAN
Page 76 and 77: 3-35 ENGINECLUTCH▣ CLUTCH DRIVE P
Page 78 and 79: 3-37 ENGINETRANSMISSION▣ DISASSEM
Page 80 and 81: 3-39 ENGINE▣ REASSEMBLYReassemble
Page 82 and 83: 3-41 ENGINE● Remove the oil strai
Page 84 and 85: 3-43 ENGINE▣ CLUTCH RELEASE CAMSH
Page 86 and 87: 3-45 ENGINE◉ GEARSHIFT CAM, FORK
Page 88 and 89: 13-47 ENGINE◉ GEAR POSITION SWITC
Page 90 and 91: 3-49 ENGINE● Install the gearshif
Page 92 and 93: 23-51 ENGINE● Bend the tongue of
Page 94 and 95: 3-53 ENGINE◉ PISTON RING● Insta
Page 96 and 97: 3-55 ENGINE● Install the cam chai
Page 98 and 99: 3-57 ENGINE21st pin15th pin31
Page 100 and 101: 3-59 ENGINE◉ CAM CHAIN TENSION AD
Page 102 and 103: FUEL SYSTEMCONTENTSFUEL TANK……
Page 104 and 105: FUEL SYSTEM 4-2◉ REMOUNTINGRemoun
Page 106 and 107: FUEL SYSTEM 4-4◉ LOCATION OF CARB
Page 108 and 109: 7FUEL SYSTEM 4-6● Remove the spri
Page 110 and 111: FUEL SYSTEM 4-8● Remove the main
Page 112 and 113: FUEL SYSTEM 4-10● Align the hole
Page 114 and 115: 5-1 COOLING SYSTEMENGINE COOLANTAt
Page 116 and 117: 5-3 COOLING SYSTEM● Disconnect re
Page 118 and 119: 5-5 COOLING SYSTEMCOOLING FAN◉ IN
Page 120: 5-7 COOLING SYSTEM◉ INSTALLATIONI
Page 125 and 126: COOLING SYSTEM 5-12● Remove the c
Page 127 and 128: COOLING SYSTEM 5-14▣ BEARING CASE
Page 129: COOLING SYSTEM 5-16OIL TANK AND HOS
Page 132 and 133: 5-19 COOLING SYSTEM● Install the
Page 135 and 136: ELECTRICAL SYSTEM 6-21314121512 Bat
Page 138 and 139: 6-5 ELECTRICAL SYSTEM▣ IGNITION C
Page 140 and 141: 6-7 ELECTRICAL SYSTEMCHARGING SYSTE
Page 142 and 143: 6-9 ELECTRICAL SYSTEMSTARTER SYSTEM
Page 144 and 145: 6-11 ELECTRICAL SYSTEM◉ STARTER M
Page 146 and 147: 6-13 ELECTRICAL SYSTEMLAMPS◉ HEAD
Page 148 and 149: 6-15 ELECTRICAL SYSTEM◉ COMBINATI
Page 150 and 151: 6-17 ELECTRICAL SYSTEMCapSeal3 Pour
Page 152 and 153: CHASSISCONTENTSEXTERIOR PARTS …
Page 154 and 155: CHASSIS 7-2
Page 156 and 157: CHASSIS 7-4● Remove the four stee
Page 158 and 159: CHASSIS 7-6◉ REMOUNTINGRemount th
Page 161: 7-9 CHASSIS▣ REAR WHEEL HUB● Re
Page 164 and 165: CHASSIS 7-12▣ FRONT WHEEL● Inst
Page 166 and 167: CHASSIS 7-14◉ BRAKE PAD REPLACEME
Page 168 and 169: 32CHASSIS 7-16● Remove the brake
Page 170 and 171: CHASSIS 7-18◉ BRAKE DISK REMOVAL
Page 172 and 173:
CHASSIS 7-20◉ MASTER CYLINDER INS
Page 174 and 175:
CHASSIS 7-22◉ REMOVAL● Remove t
Page 176 and 177:
CHASSIS 7-24◉ INSPECTION AND DISA
Page 178 and 179:
CHASSIS 7-26◉ REASSEMBLY AND REMO
Page 180 and 181:
CHASSIS 7-28NOTEWhen installing the
Page 182 and 183:
CHASSIS 7-30STEERING◉ CONSTRUCTIO
Page 184 and 185:
CHASSIS 7-32▣ STEERING SHAFT AND
Page 186 and 187:
CHASSIS 7-34● Remove the steering
Page 188 and 189:
CHASSIS 7-36◉ REASSEMBLY AND REMO
Page 190 and 191:
CHASSIS 7-38with a narrow width hav
Page 192 and 193:
CHASSIS 7-40◉ TOE-IN ADJUSTMENTAd
Page 194 and 195:
CHASSIS 7-42◉ BRAKE PAD REPLACEME
Page 196 and 197:
CHASSIS 7-44◉ BRAKE CALIPER REMOV
Page 198 and 199:
21CHASSIS 7-46◉ BRAKE CALIPER REA
Page 200 and 201:
CHASSIS 7-48● Connect the parking
Page 202 and 203:
CHASSIS 7-50◉ MASTER CYLINDER REA
Page 204 and 205:
CHASSIS 7-52● Remove the reverse
Page 206 and 207:
CHASSIS 7-54REAR SHOCK ABSORBER◉
Page 208 and 209:
CHASSIS 7-56◉ REAR SHOCK ABSORBER
Page 210 and 211:
CHASSIS 7-58▣ DAMPING FORCE ADJUS
Page 212 and 213:
CHASSIS 7-60◉ REMOVAL▣ CUSHION
Page 214 and 215:
CHASSIS 7-62◉ INSPECTION AND DISA
Page 216 and 217:
CHASSIS 7-64▣ CUSHION LEVER AND R
Page 218 and 219:
CHASSIS 7-66REAR AXLE◉ CONSTRUCTI
Page 220 and 221:
CHASSIS 7-68● Remove the brake di
Page 222 and 223:
CHASSIS 7-70▣ REASSEMBLY AND REMO
Page 224 and 225:
CHASSIS 7-72● Apply SUPER GREASE
Page 226 and 227:
SERVICING INFORMATIONCONTENTSTROUBL
Page 228 and 229:
SERVICING INFORMATION 8-2ComplaintN
Page 230 and 231:
SERVICING INFORMATION 8-4◉ CARBUR
Page 232 and 233:
SERVICING INFORMATION 8-6◉ BATTER
Page 234 and 235:
SERVICING INFORMATION 8-8◉ BRAKES
Page 236 and 237:
SERVICING INFORMATION 8-10Special t
Page 238 and 239:
SERVICING INFORMATION 8-12TIGHTENIN
Page 240 and 241:
SERVICING INFORMATION 8-14SERVICE D
Page 242 and 243:
SERVICING INFORMATION 8-16◉ OIL P
Page 244 and 245:
SERVICING INFORMATION 8-18◉ TRANS
Page 246 and 247:
SERVICING INFORMATION 8-20◉ THERM
Page 248 and 249:
SERVICING INFORMATION 8-22◉ WATTA
Page 250 and 251:
SERVICING INFORMATION 8-24◉ BRAKE
Page 252 and 253:
WIRE AND CABLE ROUTINGSERVICING INF
Page 254 and 255:
SERVICING INFORMATION 8-28
Page 256 and 257:
SERVICING INFORMATION 8-30
Page 258 and 259:
SERVICING INFORMATION 8-32WIRING DI
Page 260 and 261:
MEASURINGTAPPETCLEARANCE (mm)0.10 ~
show all

TE450 SM service manual.pdf - Hyosung

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?