SERVICE SPECIFICATIONS

More documents

Recommendations

Info

A46DE AUTOMATIC TRANSMISSION - REAR CLUTCH (A46DE) AT4693 AT4883 AT-51 (b) Using a screwdriver, install the snap ring. Be sure the end gap of the snap ring is not aligned with the cutout portion of the rear clutch drum. 6. CHECK PISTON STROKE OF REAR CLUTCH (a) Plate the rear clutch assembly onto the center support. (b) Using a dial indicator, measure the rear clutch piston stroke applying and releasing the compressed air 392-785 kPa (4 - 8 kgf/cm2 , 57 - 114 psi), as shown. Piston stroke: 0.90 - 1.75 mm (0.0354 - 0.0689 in.) If the piston stroke is less than the limit, parts may have been assembled incorrectly, check and reassemble again.
Snap Ring ♦ Non-reusable part A46DF AUTOMATIC TRANSMISSION - REAR CLUTCH (A46DF) Flange Disc Piston Return Spring Snap Ring AT4692 AT4883 REAR CLUTCH COMPONENTS No. 2 Rear Clutch Piston ♦ O-Ring Plate ♦ O-Ring Rear Clutch Piston Subassembly Rear Clutch Drum REAR CLUTCH DISASSEMBLY AT6247 1. CHECK PISTON STROKE OF REAR CLUTCH (a) Place the rear clutch assembly onto the center support. (b) Using a dial indicator, measure the rear clutch piston stroke applying and releasing the compressed air 392-785 kPa (4 - 8 kgf/cm 2 , 57 - 114 psi), as shown. Piston stroke: 0.90 - 1.75 mm (0.0354 - 0.0689 in.) If the values are nonstandard, inspect the discs. AT-47
Page 1 and 2:
SERVICE SPECIFICATIONS SERVICE DATE
Page 3 and 4:
Output Shaft End play 0.3 - 0.9 mm
Page 5 and 6:
EQUIPMENT Feeler gauge Vernier cali
Page 7 and 8:
Rear Planetary Gear Planetary pinio
Page 9 and 10:
AT-10 PREPARATION SST (SPECIAL SERV
Page 11 and 12:
IN-10 INTRODUCTION - ABBREVIATIONS
Page 13 and 14:
GENERAL SPECIFICATIONS Type of Tran
Page 15 and 16:
GENERAL SPECIFICATIONS Type of Tran
Page 17 and 18:
2. FUNCTION OF COMPONENTS COMPONENT
Page 19 and 20:
2 or L Position 2nd Gear L Position
Page 21 and 22:
4. ELECTRONIC CONTROL SYSTEM The el
Page 23 and 24:
2. FUNCTION OF COMPONENTS COMPONENT
Page 25 and 26:
2 or L Position 2nd Gear L Position
Page 27 and 28:
ECTS Throttle Position Sensor Idli
Page 29 and 30:
Manual Valve Lever Shaft ♦ Oil Se
Page 31 and 32:
A46DE AUTOMATIC TRANSMISSION - COMP
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
SST A46DE AUTOMATIC TRANSMISSION -
Page 39 and 40:
Page 41 and 42:
Manual Valve Lever Shaft ♦ Oil Se
Page 43 and 44:
A46DF AUTOMATIC TRANSMISSION - COMP
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
SST A46DF AUTOMATIC TRANSMISSION -
Page 51 and 52: A46DF AUTOMATIC TRANSMISSION - COMP
Page 53 and 54: AT-24 COMPONENT PARTS GENERAL NOTES
Page 55 and 56: AT-26 Front Side Bushing A46DE AUTO
Page 57 and 58: AT-28 A46DE AUTOMATIC TRANSMISSION
Page 59 and 60: AT-26 Front Side Bushing A46DF AUTO
Page 61 and 62: AT-28 A46DF AUTOMATIC TRANSMISSION
Page 63 and 64: AT-30 AT4751 AT4752 A46DE AUTOMATIC
Page 67 and 68: AT-34 AT4578 AT4765 Retainer Retain
Page 69 and 70: AT-36 Hold Lock A46DE AUTOMATIC TRA
Page 71 and 72: AT-30 AT4751 AT4752 A46DF AUTOMATIC
Page 75 and 76: AT-34 AT4881 AT4765 AT4578 AT4765 R
Page 77 and 78: AT-36 Hold Lock A46DF AUTOMATIC TRA
Page 81 and 82: AT-40 Front Rear A46DE AUTOMATIC TR
Page 83 and 84: O/D Planetary Ring Gear Race ♦ No
Page 85 and 86: A46DF AUTOMATIC TRANSMISSION - OVER
Page 87 and 88: A46DF AUTOMATIC TRANSMISSION - OVER
Page 89 and 90: SST A46DE AUTOMATIC TRANSMISSION -
Page 91 and 92: SST SST AT4650 AT6246 AT4838 A46DE
Page 93 and 94: AT-42 Front Clutch Front Clutch Pis
Page 97 and 98: AT-46 AT4687 AT4688 Rear Front SST
Page 99 and 100: AT-48 SST A46DE AUTOMATIC TRANSMISS
Page 101: AT-50 SST AT4696 AT4838 AT4695 A46D
Page 105 and 106: A46DF AUTOMATIC TRANSMISSION - REAR
Page 107 and 108: A46DF AUTOMATIC TRANSMISSION - REAR
Page 109 and 110: SST A46DE AUTOMATIC TRANSMISSION -
Page 111 and 112: SST AT4704 AT4839 SST A46DE AUTOMAT
Page 113 and 114: AT-52 Oil Seal Ring Snap Ring ♦ N
Page 119 and 120: AT-58 SST A46DE AUTOMATIC TRANSMISS
Page 121 and 122: AT-60 SST AT4778 AT4783 AT4777 A46D
Page 123 and 124: Center Support Non reusable part A
Page 125 and 126: SST A46DF AUTOMATIC TRANSMISSION -
Page 127 and 128: A46DF AUTOMATIC TRANSMISSION - NO.
Page 129 and 130: A46DE AUTOMATIC TRANSMISSION - PLAN
Page 131 and 132: AT-62 Free Hold Front Side Retainer
Page 133 and 134: AT-64 Open End AT4773 AT4769 Free H
Page 137 and 138: AT-68 Hold Free 5. CHECK OPERATION
Page 141 and 142: AT-68 Hold Free 5. CHECK OPERATION
Page 153 and 154:
AT-74 A46DF AUTOMATIC TRANSMISSION
Page 155 and 156:
Disc ♦ Non-reusable part A46DF AU
Page 157 and 158:
Pin Pin Retainer A46DE AUTOMATIC TR
Page 159 and 160:
Q00434 A46DE AUTOMATIC TRANSMISSION
Page 161 and 162:
Pin Pin Retainer A46DF AUTOMATIC TR
Page 163 and 164:
Q00434 A46DF AUTOMATIC TRANSMISSION
Page 165 and 166:
Mark Name (Color) A46DE AUTOMATIC T
Page 167 and 168:
AT-80 Retainer Plug Cut-back Valve
Page 169 and 170:
AT-82 RETAINERS AND PIN LOCATION Cu
Page 171 and 172:
AT-84 Mark Name (Color) A46DE AUTOM
Page 173 and 174:
Plug Pin ♦ Non-reusable part A46D
Page 175 and 176:
RETAINERS, PIN AND CHECK BALLS LOCA
Page 177 and 178:
Mark Name (Color) A46DE AUTOMATIC T
Page 179 and 180:
AT-86 Plunger Sleeve Intermediate M
Page 181 and 182:
AT-88 RETAINERS, CHECK BALLS AND SP
Page 183 and 184:
A46DE AUTOMATIC TRANSMISSION - TRAN
Page 185 and 186:
AT6267 Mark A46DF AUTOMATIC TRANSMI
Page 187 and 188:
SST AT6424 AT4803 A46DF AUTOMATIC T
Page 189 and 190:
Page 191 and 192:
SST SST Front A46DF AUTOMATIC TRANS
Page 193 and 194:
Page 195 and 196:
Page 197 and 198:
C4500 A46DF AUTOMATIC TRANSMISSION
Page 199 and 200:
Page 201 and 202:
COMPONENT PARTS INSTALLATION Disass
Page 203 and 204:
Manual Valve Lever Manual Valve Lev
Page 205 and 206:
Page 207 and 208:
Front A46DE AUTOMATIC TRANSMISSION
Page 209 and 210:
Race SST A46DE AUTOMATIC TRANSMISSI
Page 211 and 212:
Q00420 A46DE AUTOMATIC TRANSMISSION
Page 213 and 214:
AT6231 AT6229 A46DE AUTOMATIC TRANS
Page 215 and 216:
Page 217 and 218:
1992 TOYOTA MOTOR CORPORATION All r
Page 219 and 220:
IN-6 Fuse Equal Amperage Rating WRO
Page 221 and 222:
IN-8 INTRODUCTION - GLOSSARY OF SAE
Page 223 and 224:
IN-2 HOW TO USE THIS MANUAL To assi
Page 225 and 226:
IN-4 CAUTIONS, NOTICES, HINTS: Sl U
Page 227:
Class Diameter mm Pitch mm Specifie
show all

SERVICE SPECIFICATIONS

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?