SERVICE SPECIFICATIONS

More documents

Recommendations

Info

SST A46DE AUTOMATIC TRANSMISSION - OVERDRIVE DIRECT CLUTCH (A46DE) AT4753 AT4880 AT4754 AT5879 AT4756 5. REMOVE DISC 8. REMOVE FLANGE AND CUSHION PLATE (a) Using a screwdriver, remove the snap ring. (b) Remove the flange and cushion plate. 7. REMOVE PISTON RETURN SPRINGS (a) Place SST on the spring seat and compress the return springs with a shop press. SST 09350-20015 (09369-20040) (b) Using a snap ring expander, remove the snap ring. (c) Remove the spring seat and eighteen springs. AT-31 8. REMOVE OVERDRIVE DIRECT CLUTCH PISTON (a) Place the O/D direct clutch onto the oil pump. (b) Hold the O/D direct clutch piston and apply compressed air to the oil pump to remove the O/D direct clutch piston. HINT: Make sure the direct clutch piston square in the drum before applying compressed air. (c) Remove the two O-rings from the piston.
AT-32 A46DE AUTOMATIC TRANSMISSION - OVERDRIVE DIRECT CLUTCH (A46DE) AT4757 AT4758 AT4881 AT4759 9. REMOVE THRUST WASHER (a) Using a screwdriver, remove the snap ring. (b) Remove the thrust washer. 10. REMOVE ONE-WAY CLUTCH ASSEMBLY 11. DISASSEMBLE ONE-WAY CLUTCH (a) Remove the two retainers from both sides. (b) Remove the one-way clutch from the outer race. 12. REMOVE THRUST WASHER
Page 1 and 2:
SERVICE SPECIFICATIONS SERVICE DATE
Page 3 and 4:
Output Shaft End play 0.3 - 0.9 mm
Page 5 and 6:
EQUIPMENT Feeler gauge Vernier cali
Page 7 and 8:
Rear Planetary Gear Planetary pinio
Page 9 and 10:
AT-10 PREPARATION SST (SPECIAL SERV
Page 11 and 12:
IN-10 INTRODUCTION - ABBREVIATIONS
Page 13 and 14: GENERAL SPECIFICATIONS Type of Tran
Page 15 and 16: GENERAL SPECIFICATIONS Type of Tran
Page 17 and 18: 2. FUNCTION OF COMPONENTS COMPONENT
Page 19 and 20: 2 or L Position 2nd Gear L Position
Page 21 and 22: 4. ELECTRONIC CONTROL SYSTEM The el
Page 23 and 24: 2. FUNCTION OF COMPONENTS COMPONENT
Page 25 and 26: 2 or L Position 2nd Gear L Position
Page 27 and 28: ECTS Throttle Position Sensor Idli
Page 29 and 30: Manual Valve Lever Shaft ♦ Oil Se
Page 31 and 32: A46DE AUTOMATIC TRANSMISSION - COMP
Page 37 and 38: SST A46DE AUTOMATIC TRANSMISSION -
Page 41 and 42: Manual Valve Lever Shaft ♦ Oil Se
Page 43 and 44: A46DF AUTOMATIC TRANSMISSION - COMP
Page 49 and 50: SST A46DF AUTOMATIC TRANSMISSION -
Page 53 and 54: AT-24 COMPONENT PARTS GENERAL NOTES
Page 55 and 56: AT-26 Front Side Bushing A46DE AUTO
Page 57 and 58: AT-28 A46DE AUTOMATIC TRANSMISSION
Page 59 and 60: AT-26 Front Side Bushing A46DF AUTO
Page 61 and 62: AT-28 A46DF AUTOMATIC TRANSMISSION
Page 63: AT-30 AT4751 AT4752 A46DE AUTOMATIC
Page 67 and 68: AT-34 AT4578 AT4765 Retainer Retain
Page 69 and 70: AT-36 Hold Lock A46DE AUTOMATIC TRA
Page 71 and 72: AT-30 AT4751 AT4752 A46DF AUTOMATIC
Page 75 and 76: AT-34 AT4881 AT4765 AT4578 AT4765 R
Page 77 and 78: AT-36 Hold Lock A46DF AUTOMATIC TRA
Page 79 and 80: AT-38 A46DE AUTOMATIC TRANSMISSION
Page 81 and 82: AT-40 Front Rear A46DE AUTOMATIC TR
Page 83 and 84: O/D Planetary Ring Gear Race ♦ No
Page 85 and 86: A46DF AUTOMATIC TRANSMISSION - OVER
Page 87 and 88: A46DF AUTOMATIC TRANSMISSION - OVER
Page 91 and 92: SST SST AT4650 AT6246 AT4838 A46DE
Page 93 and 94: AT-42 Front Clutch Front Clutch Pis
Page 97 and 98: AT-46 AT4687 AT4688 Rear Front SST
Page 99 and 100: AT-48 SST A46DE AUTOMATIC TRANSMISS
Page 101 and 102: AT-50 SST AT4696 AT4838 AT4695 A46D
Page 103 and 104: Snap Ring ♦ Non-reusable part A46
Page 105 and 106: A46DF AUTOMATIC TRANSMISSION - REAR
Page 107 and 108: A46DF AUTOMATIC TRANSMISSION - REAR
Page 111 and 112: SST AT4704 AT4839 SST A46DE AUTOMAT
Page 113 and 114: AT-52 Oil Seal Ring Snap Ring ♦ N
Page 115 and 116:
AT-54 A46DF AUTOMATIC TRANSMISSION
Page 117 and 118:
Page 119 and 120:
AT-58 SST A46DE AUTOMATIC TRANSMISS
Page 121 and 122:
AT-60 SST AT4778 AT4783 AT4777 A46D
Page 123 and 124:
Center Support Non reusable part A
Page 125 and 126:
SST A46DF AUTOMATIC TRANSMISSION -
Page 127 and 128:
A46DF AUTOMATIC TRANSMISSION - NO.
Page 129 and 130:
A46DE AUTOMATIC TRANSMISSION - PLAN
Page 131 and 132:
AT-62 Free Hold Front Side Retainer
Page 133 and 134:
AT-64 Open End AT4773 AT4769 Free H
Page 135 and 136:
AT-66 A46DE AUTOMATIC TRANSMISSION
Page 137 and 138:
AT-68 Hold Free 5. CHECK OPERATION
Page 139 and 140:
Page 141 and 142:
AT-68 Hold Free 5. CHECK OPERATION
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Disc ♦ Non-reusable part A46DF AU
Page 157 and 158:
Pin Pin Retainer A46DE AUTOMATIC TR
Page 159 and 160:
Q00434 A46DE AUTOMATIC TRANSMISSION
Page 161 and 162:
Pin Pin Retainer A46DF AUTOMATIC TR
Page 163 and 164:
Q00434 A46DF AUTOMATIC TRANSMISSION
Page 165 and 166:
Mark Name (Color) A46DE AUTOMATIC T
Page 167 and 168:
AT-80 Retainer Plug Cut-back Valve
Page 169 and 170:
AT-82 RETAINERS AND PIN LOCATION Cu
Page 171 and 172:
AT-84 Mark Name (Color) A46DE AUTOM
Page 173 and 174:
Plug Pin ♦ Non-reusable part A46D
Page 175 and 176:
RETAINERS, PIN AND CHECK BALLS LOCA
Page 177 and 178:
Mark Name (Color) A46DE AUTOMATIC T
Page 179 and 180:
AT-86 Plunger Sleeve Intermediate M
Page 181 and 182:
AT-88 RETAINERS, CHECK BALLS AND SP
Page 183 and 184:
A46DE AUTOMATIC TRANSMISSION - TRAN
Page 185 and 186:
AT6267 Mark A46DF AUTOMATIC TRANSMI
Page 187 and 188:
SST AT6424 AT4803 A46DF AUTOMATIC T
Page 189 and 190:
A46DF AUTOMATIC TRANSMISSION - COMP
Page 191 and 192:
SST SST Front A46DF AUTOMATIC TRANS
Page 193 and 194:
Page 195 and 196:
Page 197 and 198:
C4500 A46DF AUTOMATIC TRANSMISSION
Page 199 and 200:
Page 201 and 202:
COMPONENT PARTS INSTALLATION Disass
Page 203 and 204:
Manual Valve Lever Manual Valve Lev
Page 205 and 206:
A46DE AUTOMATIC TRANSMISSION - COMP
Page 207 and 208:
Front A46DE AUTOMATIC TRANSMISSION
Page 209 and 210:
Race SST A46DE AUTOMATIC TRANSMISSI
Page 211 and 212:
Q00420 A46DE AUTOMATIC TRANSMISSION
Page 213 and 214:
AT6231 AT6229 A46DE AUTOMATIC TRANS
Page 215 and 216:
A46DE AUTOMATIC TRANSMISSION - COMP
Page 217 and 218:
1992 TOYOTA MOTOR CORPORATION All r
Page 219 and 220:
IN-6 Fuse Equal Amperage Rating WRO
Page 221 and 222:
IN-8 INTRODUCTION - GLOSSARY OF SAE
Page 223 and 224:
IN-2 HOW TO USE THIS MANUAL To assi
Page 225 and 226:
IN-4 CAUTIONS, NOTICES, HINTS: Sl U
Page 227:
Class Diameter mm Pitch mm Specifie
show all

SERVICE SPECIFICATIONS

Create successful ePaper yourself

Delete template?

Save as template?