SERVICE SPECIFICATIONS

More documents

Recommendations

Info

AT-12 Park/Neutral Position Switch 10 mm 34 (345, 25) 12 mm 57 (580, 42) 21 (215, 16) Oil Pump N-m (kgf-cm, ft-lbf) ♦ Non-reusable part A46DF AUTOMATIC TRANSMISSION - COMPONENT PARTS REMOVAL (A46DF) 3.9 (40, 35 in.-lbf) ♦ O-Ring Thrust Bearing : Specified torque Lock Washer Grommet Transmission Housing COMPONENT PARTS REMOVAL COMPONENTS ♦ O-Ring Shift Cable Bracket No. 1 Vehicle Speed Sensor Key Ball Sensor Rotor 5.4 (55, 48 in.-lbf) A/T Fluid Temp. Sensor Elbow ♦ O-Ring ♦ O-Ring 34 (350, 24) No. 2 Vehicle Speed Sensor Snap Ring Speedometer Drive Gear Elbow 34 (350, 24) 6.9 (70, 61 in.-lbf) Control Shaft Lever Transfer Adaptor Q03428 Z07120
Manual Valve Lever Shaft ♦ Oil Seal N-m (kgf-cm, ft-lbf) ♦ Non-reusable part A46DF AUTOMATIC TRANSMISSION - COMPONENT PARTS REMOVAL (A46DF) Throttle Cable Breather Hose Spacer Parking Lock Pawl Bracket Pin Wave Washer Manual Valve Lever 7.4 (75, 65 in.-lbf) ♦ Oil Seal Parking Lock Rod Valve Body 10 (100, 7) ♦ Gasket Oil Strainer Oil Pan : Specified torque ♦ O-Ring Accumulator Spring ♦ Gasket Oil Tube Magnet Drain Plug Cover ♦ Gasket E-Ring Spring Shaft Accumulator Piston 44 (45, 39 in.-lbf) 20 (205, 15) AT-13 AT6313
Page 1 and 2: SERVICE SPECIFICATIONS SERVICE DATE
Page 3 and 4: Output Shaft End play 0.3 - 0.9 mm
Page 5 and 6: EQUIPMENT Feeler gauge Vernier cali
Page 7 and 8: Rear Planetary Gear Planetary pinio
Page 9 and 10: AT-10 PREPARATION SST (SPECIAL SERV
Page 11 and 12: IN-10 INTRODUCTION - ABBREVIATIONS
Page 13 and 14: GENERAL SPECIFICATIONS Type of Tran
Page 15 and 16: GENERAL SPECIFICATIONS Type of Tran
Page 17 and 18: 2. FUNCTION OF COMPONENTS COMPONENT
Page 19 and 20: 2 or L Position 2nd Gear L Position
Page 21 and 22: 4. ELECTRONIC CONTROL SYSTEM The el
Page 23 and 24: 2. FUNCTION OF COMPONENTS COMPONENT
Page 25 and 26: 2 or L Position 2nd Gear L Position
Page 27 and 28: ECTS Throttle Position Sensor Idli
Page 29 and 30: Manual Valve Lever Shaft ♦ Oil Se
Page 31 and 32: A46DE AUTOMATIC TRANSMISSION - COMP
Page 37 and 38: SST A46DE AUTOMATIC TRANSMISSION -
Page 39: A46DE AUTOMATIC TRANSMISSION - COMP
Page 43 and 44: A46DF AUTOMATIC TRANSMISSION - COMP
Page 49 and 50: SST A46DF AUTOMATIC TRANSMISSION -
Page 53 and 54: AT-24 COMPONENT PARTS GENERAL NOTES
Page 55 and 56: AT-26 Front Side Bushing A46DE AUTO
Page 57 and 58: AT-28 A46DE AUTOMATIC TRANSMISSION
Page 59 and 60: AT-26 Front Side Bushing A46DF AUTO
Page 61 and 62: AT-28 A46DF AUTOMATIC TRANSMISSION
Page 63 and 64: AT-30 AT4751 AT4752 A46DE AUTOMATIC
Page 67 and 68: AT-34 AT4578 AT4765 Retainer Retain
Page 69 and 70: AT-36 Hold Lock A46DE AUTOMATIC TRA
Page 71 and 72: AT-30 AT4751 AT4752 A46DF AUTOMATIC
Page 73 and 74: AT-32 A46DF AUTOMATIC TRANSMISSION
Page 75 and 76: AT-34 AT4881 AT4765 AT4578 AT4765 R
Page 77 and 78: AT-36 Hold Lock A46DF AUTOMATIC TRA
Page 81 and 82: AT-40 Front Rear A46DE AUTOMATIC TR
Page 83 and 84: O/D Planetary Ring Gear Race ♦ No
Page 85 and 86: A46DF AUTOMATIC TRANSMISSION - OVER
Page 87 and 88: A46DF AUTOMATIC TRANSMISSION - OVER
Page 89 and 90: SST A46DE AUTOMATIC TRANSMISSION -
Page 91 and 92:
SST SST AT4650 AT6246 AT4838 A46DE
Page 93 and 94:
AT-42 Front Clutch Front Clutch Pis
Page 95 and 96:
AT-44 A46DF AUTOMATIC TRANSMISSION
Page 97 and 98:
AT-46 AT4687 AT4688 Rear Front SST
Page 99 and 100:
AT-48 SST A46DE AUTOMATIC TRANSMISS
Page 101 and 102:
AT-50 SST AT4696 AT4838 AT4695 A46D
Page 103 and 104:
Snap Ring ♦ Non-reusable part A46
Page 105 and 106:
A46DF AUTOMATIC TRANSMISSION - REAR
Page 107 and 108:
A46DF AUTOMATIC TRANSMISSION - REAR
Page 109 and 110:
SST A46DE AUTOMATIC TRANSMISSION -
Page 111 and 112:
SST AT4704 AT4839 SST A46DE AUTOMAT
Page 113 and 114:
AT-52 Oil Seal Ring Snap Ring ♦ N
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
AT-58 SST A46DE AUTOMATIC TRANSMISS
Page 121 and 122:
AT-60 SST AT4778 AT4783 AT4777 A46D
Page 123 and 124:
Center Support Non reusable part A
Page 125 and 126:
SST A46DF AUTOMATIC TRANSMISSION -
Page 127 and 128:
A46DF AUTOMATIC TRANSMISSION - NO.
Page 129 and 130:
A46DE AUTOMATIC TRANSMISSION - PLAN
Page 131 and 132:
AT-62 Free Hold Front Side Retainer
Page 133 and 134:
AT-64 Open End AT4773 AT4769 Free H
Page 135 and 136:
AT-66 A46DE AUTOMATIC TRANSMISSION
Page 137 and 138:
AT-68 Hold Free 5. CHECK OPERATION
Page 139 and 140:
Page 141 and 142:
AT-68 Hold Free 5. CHECK OPERATION
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Disc ♦ Non-reusable part A46DF AU
Page 157 and 158:
Pin Pin Retainer A46DE AUTOMATIC TR
Page 159 and 160:
Q00434 A46DE AUTOMATIC TRANSMISSION
Page 161 and 162:
Pin Pin Retainer A46DF AUTOMATIC TR
Page 163 and 164:
Q00434 A46DF AUTOMATIC TRANSMISSION
Page 165 and 166:
Mark Name (Color) A46DE AUTOMATIC T
Page 167 and 168:
AT-80 Retainer Plug Cut-back Valve
Page 169 and 170:
AT-82 RETAINERS AND PIN LOCATION Cu
Page 171 and 172:
AT-84 Mark Name (Color) A46DE AUTOM
Page 173 and 174:
Plug Pin ♦ Non-reusable part A46D
Page 175 and 176:
RETAINERS, PIN AND CHECK BALLS LOCA
Page 177 and 178:
Mark Name (Color) A46DE AUTOMATIC T
Page 179 and 180:
AT-86 Plunger Sleeve Intermediate M
Page 181 and 182:
AT-88 RETAINERS, CHECK BALLS AND SP
Page 183 and 184:
A46DE AUTOMATIC TRANSMISSION - TRAN
Page 185 and 186:
AT6267 Mark A46DF AUTOMATIC TRANSMI
Page 187 and 188:
SST AT6424 AT4803 A46DF AUTOMATIC T
Page 189 and 190:
A46DF AUTOMATIC TRANSMISSION - COMP
Page 191 and 192:
SST SST Front A46DF AUTOMATIC TRANS
Page 193 and 194:
Page 195 and 196:
Page 197 and 198:
C4500 A46DF AUTOMATIC TRANSMISSION
Page 199 and 200:
Page 201 and 202:
COMPONENT PARTS INSTALLATION Disass
Page 203 and 204:
Manual Valve Lever Manual Valve Lev
Page 205 and 206:
A46DE AUTOMATIC TRANSMISSION - COMP
Page 207 and 208:
Front A46DE AUTOMATIC TRANSMISSION
Page 209 and 210:
Race SST A46DE AUTOMATIC TRANSMISSI
Page 211 and 212:
Q00420 A46DE AUTOMATIC TRANSMISSION
Page 213 and 214:
AT6231 AT6229 A46DE AUTOMATIC TRANS
Page 215 and 216:
A46DE AUTOMATIC TRANSMISSION - COMP
Page 217 and 218:
1992 TOYOTA MOTOR CORPORATION All r
Page 219 and 220:
IN-6 Fuse Equal Amperage Rating WRO
Page 221 and 222:
IN-8 INTRODUCTION - GLOSSARY OF SAE
Page 223 and 224:
IN-2 HOW TO USE THIS MANUAL To assi
Page 225 and 226:
IN-4 CAUTIONS, NOTICES, HINTS: Sl U
Page 227:
Class Diameter mm Pitch mm Specifie
show all

SERVICE SPECIFICATIONS

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?