SERVICE SPECIFICATIONS

More documents

Recommendations

Info

AT-86 Plunger Sleeve Primary Regulator Valve Intermediate Modulator Valve No. 1 and No. 2 Solenoid ♦ Non-reusable part A46DE AUTOMATIC TRANSMISSION - LOWER VALVE BODY (A46DE) Retainer Pin Cooler Return Check Ball ♦ Gasket Sleeve LOWER VALVE BODY COMPONENTS Lock-Up Relay Valve Ball Low Coast Modulator Valve Valve Body Cover ♦ Gasket Valve Body Cover ♦ Gasket Pressure Relief Valve No. 3 Solenoid AT6264
Mark Name (Color) A46DE AUTOMATIC TRANSMISSION - LOWER VALVE BODY (A46DE) VALVE BODY SPRINGS <strong>SPECIFICATIONS</strong> HINT: During reassembly, please refer to the spring specifications below to help you to differentiate the different springs. Free length / Outer diameter mm (in.) Total No. of coils Primary regulator valve (Blue) 50.28 (1.9795) / 17.02 (0.6701) 12.5 Low coast modulator valve (None) 42.35 (1.6673) / 9.2 (0.362) 17.0 Intermediate modulator valve (Red) 35.43 (1.3949) / 8.8 (0.348) 16.4 Lock-up relay valve (Green) 32.60 (1.2835) / 11.4 (0.449) 10.25 Oil cooler by-pass valve (Blue) 28.00 (1.1024) / 13.6 (0.535) 8.0 Pressure relief valve (None) 32.14 (1.2654) / 13.14 (0.5173) 11.0 Damping check valve (None) 20.00 (0.7874) / 4.97 (0.196) 18.0 Cooler return check ball (None) 13.7 (0.539) / 10.5 (0.413) 10.0 AT-87 Q00833
Page 1 and 2:
SERVICE SPECIFICATIONS SERVICE DATE
Page 3 and 4:
Output Shaft End play 0.3 - 0.9 mm
Page 5 and 6:
EQUIPMENT Feeler gauge Vernier cali
Page 7 and 8:
Rear Planetary Gear Planetary pinio
Page 9 and 10:
AT-10 PREPARATION SST (SPECIAL SERV
Page 11 and 12:
IN-10 INTRODUCTION - ABBREVIATIONS
Page 13 and 14:
GENERAL SPECIFICATIONS Type of Tran
Page 15 and 16:
GENERAL SPECIFICATIONS Type of Tran
Page 17 and 18:
2. FUNCTION OF COMPONENTS COMPONENT
Page 19 and 20:
2 or L Position 2nd Gear L Position
Page 21 and 22:
4. ELECTRONIC CONTROL SYSTEM The el
Page 23 and 24:
2. FUNCTION OF COMPONENTS COMPONENT
Page 25 and 26:
2 or L Position 2nd Gear L Position
Page 27 and 28:
ECTS Throttle Position Sensor Idli
Page 29 and 30:
Manual Valve Lever Shaft ♦ Oil Se
Page 31 and 32:
A46DE AUTOMATIC TRANSMISSION - COMP
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
SST A46DE AUTOMATIC TRANSMISSION -
Page 39 and 40:
Page 41 and 42:
Manual Valve Lever Shaft ♦ Oil Se
Page 43 and 44:
A46DF AUTOMATIC TRANSMISSION - COMP
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
SST A46DF AUTOMATIC TRANSMISSION -
Page 51 and 52:
Page 53 and 54:
AT-24 COMPONENT PARTS GENERAL NOTES
Page 55 and 56:
AT-26 Front Side Bushing A46DE AUTO
Page 57 and 58:
AT-28 A46DE AUTOMATIC TRANSMISSION
Page 59 and 60:
AT-26 Front Side Bushing A46DF AUTO
Page 61 and 62:
AT-28 A46DF AUTOMATIC TRANSMISSION
Page 63 and 64:
AT-30 AT4751 AT4752 A46DE AUTOMATIC
Page 65 and 66:
Page 67 and 68:
AT-34 AT4578 AT4765 Retainer Retain
Page 69 and 70:
AT-36 Hold Lock A46DE AUTOMATIC TRA
Page 71 and 72:
AT-30 AT4751 AT4752 A46DF AUTOMATIC
Page 73 and 74:
Page 75 and 76:
AT-34 AT4881 AT4765 AT4578 AT4765 R
Page 77 and 78:
AT-36 Hold Lock A46DF AUTOMATIC TRA
Page 79 and 80:
Page 81 and 82:
AT-40 Front Rear A46DE AUTOMATIC TR
Page 83 and 84:
O/D Planetary Ring Gear Race ♦ No
Page 85 and 86:
A46DF AUTOMATIC TRANSMISSION - OVER
Page 87 and 88:
A46DF AUTOMATIC TRANSMISSION - OVER
Page 89 and 90:
Page 91 and 92:
SST SST AT4650 AT6246 AT4838 A46DE
Page 93 and 94:
AT-42 Front Clutch Front Clutch Pis
Page 95 and 96:
Page 97 and 98:
AT-46 AT4687 AT4688 Rear Front SST
Page 99 and 100:
AT-48 SST A46DE AUTOMATIC TRANSMISS
Page 101 and 102:
AT-50 SST AT4696 AT4838 AT4695 A46D
Page 103 and 104:
Snap Ring ♦ Non-reusable part A46
Page 105 and 106:
A46DF AUTOMATIC TRANSMISSION - REAR
Page 107 and 108:
A46DF AUTOMATIC TRANSMISSION - REAR
Page 109 and 110:
Page 111 and 112:
SST AT4704 AT4839 SST A46DE AUTOMAT
Page 113 and 114:
AT-52 Oil Seal Ring Snap Ring ♦ N
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
AT-58 SST A46DE AUTOMATIC TRANSMISS
Page 121 and 122:
AT-60 SST AT4778 AT4783 AT4777 A46D
Page 123 and 124:
Center Support Non reusable part A
Page 125 and 126: SST A46DF AUTOMATIC TRANSMISSION -
Page 127 and 128: A46DF AUTOMATIC TRANSMISSION - NO.
Page 129 and 130: A46DE AUTOMATIC TRANSMISSION - PLAN
Page 131 and 132: AT-62 Free Hold Front Side Retainer
Page 133 and 134: AT-64 Open End AT4773 AT4769 Free H
Page 135 and 136: AT-66 A46DE AUTOMATIC TRANSMISSION
Page 137 and 138: AT-68 Hold Free 5. CHECK OPERATION
Page 139 and 140: AT-66 A46DF AUTOMATIC TRANSMISSION
Page 141 and 142: AT-68 Hold Free 5. CHECK OPERATION
Page 155 and 156: Disc ♦ Non-reusable part A46DF AU
Page 157 and 158: Pin Pin Retainer A46DE AUTOMATIC TR
Page 159 and 160: Q00434 A46DE AUTOMATIC TRANSMISSION
Page 161 and 162: Pin Pin Retainer A46DF AUTOMATIC TR
Page 163 and 164: Q00434 A46DF AUTOMATIC TRANSMISSION
Page 165 and 166: Mark Name (Color) A46DE AUTOMATIC T
Page 167 and 168: AT-80 Retainer Plug Cut-back Valve
Page 169 and 170: AT-82 RETAINERS AND PIN LOCATION Cu
Page 171 and 172: AT-84 Mark Name (Color) A46DE AUTOM
Page 173 and 174: Plug Pin ♦ Non-reusable part A46D
Page 175: RETAINERS, PIN AND CHECK BALLS LOCA
Page 179 and 180: AT-86 Plunger Sleeve Intermediate M
Page 181 and 182: AT-88 RETAINERS, CHECK BALLS AND SP
Page 183 and 184: A46DE AUTOMATIC TRANSMISSION - TRAN
Page 185 and 186: AT6267 Mark A46DF AUTOMATIC TRANSMI
Page 187 and 188: SST AT6424 AT4803 A46DF AUTOMATIC T
Page 189 and 190: A46DF AUTOMATIC TRANSMISSION - COMP
Page 191 and 192: SST SST Front A46DF AUTOMATIC TRANS
Page 197 and 198: C4500 A46DF AUTOMATIC TRANSMISSION
Page 201 and 202: COMPONENT PARTS INSTALLATION Disass
Page 203 and 204: Manual Valve Lever Manual Valve Lev
Page 205 and 206: A46DE AUTOMATIC TRANSMISSION - COMP
Page 207 and 208: Front A46DE AUTOMATIC TRANSMISSION
Page 209 and 210: Race SST A46DE AUTOMATIC TRANSMISSI
Page 211 and 212: Q00420 A46DE AUTOMATIC TRANSMISSION
Page 213 and 214: AT6231 AT6229 A46DE AUTOMATIC TRANS
Page 215 and 216: A46DE AUTOMATIC TRANSMISSION - COMP
Page 217 and 218: 1992 TOYOTA MOTOR CORPORATION All r
Page 219 and 220: IN-6 Fuse Equal Amperage Rating WRO
Page 221 and 222: IN-8 INTRODUCTION - GLOSSARY OF SAE
Page 223 and 224: IN-2 HOW TO USE THIS MANUAL To assi
Page 225 and 226: IN-4 CAUTIONS, NOTICES, HINTS: Sl U
Page 227:
Class Diameter mm Pitch mm Specifie
show all

SERVICE SPECIFICATIONS

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?