Leonardo 250-300 Repair Manual 2004 - Wheels Academy

More documents

Recommendations

Info

LEONARDO 250 - 300 CYCLE PARTS 7.8. REAR BRAKE 7.8.1. REAR BRAKE DIAGRAM l Key 1. Brake control lever 2. Brake fluid pump/tank 3. Brake fluid pipe 4. Bleed valve 5. Pipe fitting screw 6. Brake calliper 7. Pad pin 8. Stop ring 9. Brake pads 10. Antivibration plates 11. Pad spring 12. Brake disc 7 - 57
CYCLE PARTS LEONARDO 250 - 300 7.8.2. REPLACING THE REAR BRAKE PADS • Remove the rear brake caliper, (REMOVING THE REAR WHEEL). • Remove the circlip (1). • Remove the spindle (2). • Remove the spring (3). CAUTION The spring (3) is stamped with an arrow which must always be oriented in the direction of travel of the motorcycle.. • Extract the pads (4) complete with vibration dampers (5). CAUTION Do not operate the brake lever with the brake pads removed, or the brake caliper pistons might fall out leading to loss of brake fluid. • Replace both pads (4). • If they are worn, also replace the vibration dampers (5). CAUTION The brake pads must always be replaced in pairs. Ensure they become properly seated in the brake caliper. CAUTION Make sure that the arrows on the vibration dampers are oriented in the direction of travel when replaced. • Fit the spring (3). • Fit the pin (2). • Fit the circlip (1) • Check brake fluid level, (BRAKE). 7 - 58
Page 1 and 2:
1194 4 00/2004-04 LEONARDO 250 - 30
Page 3 and 4:
INTRODUCTION LEONARDO 250 - 300 CON
Page 5 and 6:
INTRODUCTION LEONARDO 250 - 300 0.1
Page 7 and 8:
INTRODUCTION LEONARDO 250 - 300 RIG
Page 9 and 10:
GENERAL INFORMATION LEONARDO 250 -
Page 11 and 12:
Page 13 and 14:
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
PERIODIC MAINTENANCE LEONARDO 250 -
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
LEONARDO 250 - 300 LUBRICATION LUBR
Page 57 and 58:
LEONARDO 250 - 300 LUBRICATION 3.1.
Page 59 and 60:
FUEL SYSTEM LEONARDO 250 - 300 CONT
Page 61 and 62:
FUEL SYSTEM LEONARDO 250 - 300 TANK
Page 63 and 64:
FUEL SYSTEM LEONARDO 250 - 300 4.1.
Page 65 and 66:
FUEL SYSTEM LEONARDO 250 - 300 4.2.
Page 67 and 68:
FUEL SYSTEM LEONARDO 250 - 300 Key:
Page 69 and 70:
FUEL SYSTEM LEONARDO 250 - 300 •
Page 71 and 72:
COOLING SYSTEM LEONARDO 250 - 300 C
Page 73 and 74:
COOLING SYSTEM LEONARDO 250 - 300 5
Page 75 and 76:
Page 77 and 78:
Page 79 and 80:
LEONARDO 250 - 300 ENGINE ENGINE 6
Page 81 and 82:
LEONARDO 250 - 300 ENGINE 6.1. EXHA
Page 83 and 84:
LEONARDO 250 - 300 ENGINE • Relea
Page 85 and 86:
LEONARDO 250 - 300 ENGINE • Disco
Page 87 and 88:
LEONARDO 250 - 300 ENGINE • Place
Page 89 and 90:
LEONARDO 250 - 300 ENGINE 6.2.2. RE
Page 91 and 92:
LEONARDO 250 - 300 ENGINE • Conne
Page 93 and 94:
LEONARDO 250 - 300 ENGINE • Refit
Page 95 and 96:
LEONARDO 250 - 300 ENGINE • Refit
Page 97 and 98:
CYCLE PARTS LEONARDO 250 - 300 CONT
Page 99 and 100:
CYCLE PARTS LEONARDO 250 - 300 7.1.
Page 101 and 102: CYCLE PARTS LEONARDO 250 - 300 7.1.
Page 109 and 110: CYCLE PARTS LEONARDO 250 - 300 •
Page 121 and 122: CYCLE PARTS LEONARDO 250 - 300 •
Page 151: CYCLE PARTS LEONARDO 250 - 300 7.7.
Page 161 and 162: CYCLE PARTS LEONARDO 250 - 300 7.10
Page 169 and 170: LEONARDO 250 - 300 ELECTRICAL SYSTE
show all

Leonardo 250-300 Repair Manual 2004 - Wheels Academy

Create successful ePaper yourself

Delete template?

Save as template?