Leonardo 250-300 Repair Manual 2004 - Wheels Academy

More documents

Recommendations

Info

LEONARDO 250 - 300 PERIODIC MAINTENANCE 2.1. PERIODIC MAINTENANCE 2.1.1. INTRODUCTION In order to preserve the motorcycle in sleek running order, aprilia recommends that you strictly observe the periodic maintenance intervals recommended for the different components. Outlined in this section are the recommended procedures for the periodic maintenance of the key components of the motorcycle. DANGER Before beginning any service operations or inspection of the vehicle, switch off the engine and remove the key, wait until the engine and the exhaust system have cooled down and, if possible, lift the vehicles with the proper equipment onto firm and flat ground. Pay particular attention to any parts of the engine or exhaust system that may still be hot to the touch to avoid burns. All component parts of the vehicle are inedible. Do not bite, suck, chew or swallow any vehicle parts. If not expressly indicated otherwise, for the reassembly of the units repeat the disassembly operations in reverse order. 2 - 3
PERIODIC MAINTENANCE LEONARDO 250 - 300 2.1.2. PERIODIC MAINTENANCE CHART Component After running-in [1000 km (625 mi)] Every 6000 km (3750 mi) or 12 months Every 12000 km (7500 mi) or 24 months Rear shock absorber - - 1 Transmission cables and controls 1 - - Accelerator cable (adjustment) - 1 - Variator belt 1 1 - Steering tube bearings and steering slack 1 1 - Wheel bearings - 1 - Brake discs 1 1 - Engine oil filter - 1 - General running of the vehicle 1 1 - Clutch shoes 2 every 3000 km (1875 mi): 2 Valve clearance 1 1 - Braking systems - 1 - Cooling system - - 4 Stop light switches 1 1 - Brake fluid 1 1 - Coolant - 1 - Fork oil and oil seal every 2 years: 3 Engine oil every 2 years: 3 Transmission oil every 12000 km (7500 mi): 1 Center stand wheel every 1000 km (625 mi): 1 / every 3000 km 3 (1875 mi): 3 Speed change gear rollers and speed change gear 3 plastic guides 1 3 Wheels/tyres and inflation pressure 1 1 - Nut, bolt, screw tightening - 1 - Fuel pipe 1 1 - Clutch wear 1 1 - Speed change gear (front pulleys and rear pulleys) - 1 every 4 years: 3 Rear shock absorber - 1 - Transmission cables and controls - 2 1 Battery - Terminal fastening - Electrolyte level 1 1 - Spark plug 1 1 3 Carburettor - idling 4 1 - Air cleaner - 2 - Speed change gear filter - 2 - Accelerator operation 1 1 - Brake locking operation 1 1 - Light system 1 1 - Stop light switches - 1 - Brake fluid 1 1 - Coolant every 2000 km (1250 mi): 1 Engine oil every 1000 km (625 mi): 1 Headlight beam direction - operation - 1 - Wheels/tyres and inflation pressure every month: 1 Suspensions 1 1 - Engine oil change warning light at every start: 1 Front and rear brake pad wear 1 every 2000 km (1250 mi): 1 1 = inspect and clean, set or adjust, lubricate or replace as required; 2 = clean; 3 = replace; 4= set or adjust. Service the motorcycle more frequently when you ride in the rain, on dusty or bumpy roads, or in competition trials. ( ) = THESE OPERATIONS CAN BE CARRIED OUT BY THE OWNER (*) = For inspection, refer to INSTRUMENTS AND INDICATORS TABLE (**) = Check every two weeks or at the indicated interval. 2 - 4
Page 1 and 2: 1194 4 00/2004-04 LEONARDO 250 - 30
Page 3 and 4: INTRODUCTION LEONARDO 250 - 300 CON
Page 5 and 6: INTRODUCTION LEONARDO 250 - 300 0.1
Page 7 and 8: INTRODUCTION LEONARDO 250 - 300 RIG
Page 9 and 10: GENERAL INFORMATION LEONARDO 250 -
Page 31: PERIODIC MAINTENANCE LEONARDO 250 -
Page 35 and 36: PERIODIC MAINTENANCE LEONARDO 250 -
Page 55 and 56: LEONARDO 250 - 300 LUBRICATION LUBR
Page 57 and 58: LEONARDO 250 - 300 LUBRICATION 3.1.
Page 59 and 60: FUEL SYSTEM LEONARDO 250 - 300 CONT
Page 61 and 62: FUEL SYSTEM LEONARDO 250 - 300 TANK
Page 63 and 64: FUEL SYSTEM LEONARDO 250 - 300 4.1.
Page 65 and 66: FUEL SYSTEM LEONARDO 250 - 300 4.2.
Page 67 and 68: FUEL SYSTEM LEONARDO 250 - 300 Key:
Page 69 and 70: FUEL SYSTEM LEONARDO 250 - 300 •
Page 71 and 72: COOLING SYSTEM LEONARDO 250 - 300 C
Page 73 and 74: COOLING SYSTEM LEONARDO 250 - 300 5
Page 79 and 80: LEONARDO 250 - 300 ENGINE ENGINE 6
Page 81 and 82: LEONARDO 250 - 300 ENGINE 6.1. EXHA
Page 83 and 84:
LEONARDO 250 - 300 ENGINE • Relea
Page 85 and 86:
LEONARDO 250 - 300 ENGINE • Disco
Page 87 and 88:
LEONARDO 250 - 300 ENGINE • Place
Page 89 and 90:
LEONARDO 250 - 300 ENGINE 6.2.2. RE
Page 91 and 92:
LEONARDO 250 - 300 ENGINE • Conne
Page 93 and 94:
LEONARDO 250 - 300 ENGINE • Refit
Page 95 and 96:
LEONARDO 250 - 300 ENGINE • Refit
Page 97 and 98:
CYCLE PARTS LEONARDO 250 - 300 CONT
Page 99 and 100:
CYCLE PARTS LEONARDO 250 - 300 7.1.
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
Page 107 and 108:
Page 109 and 110:
CYCLE PARTS LEONARDO 250 - 300 •
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
CYCLE PARTS LEONARDO 250 - 300 •
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
CYCLE PARTS LEONARDO 250 - 300 7.10
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
LEONARDO 250 - 300 ELECTRICAL SYSTE
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
show all

Leonardo 250-300 Repair Manual 2004 - Wheels Academy

Create successful ePaper yourself

Delete template?

Save as template?