Leonardo 250-300 Repair Manual 2004 - Wheels Academy

More documents

Recommendations

Info

LEONARDO 250 - 300 PERIODIC MAINTENANCE 2.9. FRONT END 2.9.1. FRONT END CHECKING THE STEERING Occasionally check the steering slack. To check the steering: • Position the vehicle on the centre stand. NOTE Prepare a support whose height should be: 185 mm the support base must measure 200 x 200 mm. • Place the support under the vehicle and a spongy cloth between them, so that the front wheel can move freely and the vehicle cannot fall down. WARNING Make sure that the vehicle is stable.. • Shake the fork in the riding direction (see figure). WARNING Do not shake the fork excessively, otherwise stand movement could be perceived, thus giving an incorrect slack reading. Repeat the previous operation several times. ADJUSTING THE BEARING SLACKS • Remove the front inner shield, see 7.1.6 (REMOVING THE INNER SHIELD). • Remove the two rear rivets (1) from diaphragm holder. • Loosen and remove the two screws (2). • Unscrew and remove the screws (3). • Move the diaphragm holder upwards. • Unscrew and remove the protection element (4). • Move the rubber gasket (5). WARNING Neither tighten, nor screw the adjusting nut (6) too firmly, in order not to damage the bearings. • Screw the adjusting nut (6) until you take up the slack. • Check the slack by shaking the fork in the driving direction and make sure that the steering rotates without problems. • Hold the adjusting nut (6) and tighten the lock nut (5) by means of a spanner. • Repeat slack check. 2 - 21
PERIODIC MAINTENANCE LEONARDO 250 - 300 INSPECTING THE FRONT • With pulled front brake lever, push the fork repeatedly downwards. The stroke must be gentle and there must be no trace of oil on the rods. • Check the fastening of all the components and the functionality of the front and rear suspension joints. 2 - 22
Page 1 and 2: 1194 4 00/2004-04 LEONARDO 250 - 30
Page 3 and 4: INTRODUCTION LEONARDO 250 - 300 CON
Page 5 and 6: INTRODUCTION LEONARDO 250 - 300 0.1
Page 7 and 8: INTRODUCTION LEONARDO 250 - 300 RIG
Page 9 and 10: GENERAL INFORMATION LEONARDO 250 -
Page 31 and 32: PERIODIC MAINTENANCE LEONARDO 250 -
Page 49: PERIODIC MAINTENANCE LEONARDO 250 -
Page 55 and 56: LEONARDO 250 - 300 LUBRICATION LUBR
Page 57 and 58: LEONARDO 250 - 300 LUBRICATION 3.1.
Page 59 and 60: FUEL SYSTEM LEONARDO 250 - 300 CONT
Page 61 and 62: FUEL SYSTEM LEONARDO 250 - 300 TANK
Page 63 and 64: FUEL SYSTEM LEONARDO 250 - 300 4.1.
Page 65 and 66: FUEL SYSTEM LEONARDO 250 - 300 4.2.
Page 67 and 68: FUEL SYSTEM LEONARDO 250 - 300 Key:
Page 69 and 70: FUEL SYSTEM LEONARDO 250 - 300 •
Page 71 and 72: COOLING SYSTEM LEONARDO 250 - 300 C
Page 73 and 74: COOLING SYSTEM LEONARDO 250 - 300 5
Page 79 and 80: LEONARDO 250 - 300 ENGINE ENGINE 6
Page 81 and 82: LEONARDO 250 - 300 ENGINE 6.1. EXHA
Page 83 and 84: LEONARDO 250 - 300 ENGINE • Relea
Page 85 and 86: LEONARDO 250 - 300 ENGINE • Disco
Page 87 and 88: LEONARDO 250 - 300 ENGINE • Place
Page 89 and 90: LEONARDO 250 - 300 ENGINE 6.2.2. RE
Page 91 and 92: LEONARDO 250 - 300 ENGINE • Conne
Page 93 and 94: LEONARDO 250 - 300 ENGINE • Refit
Page 95 and 96: LEONARDO 250 - 300 ENGINE • Refit
Page 97 and 98: CYCLE PARTS LEONARDO 250 - 300 CONT
Page 99 and 100: CYCLE PARTS LEONARDO 250 - 300 7.1.
Page 101 and 102:
CYCLE PARTS LEONARDO 250 - 300 7.1.
Page 103 and 104:
Page 105 and 106:
Page 107 and 108:
Page 109 and 110:
CYCLE PARTS LEONARDO 250 - 300 •
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
CYCLE PARTS LEONARDO 250 - 300 •
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
CYCLE PARTS LEONARDO 250 - 300 7.10
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
LEONARDO 250 - 300 ELECTRICAL SYSTE
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
show all

Leonardo 250-300 Repair Manual 2004 - Wheels Academy

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?