Leonardo 250-300 Repair Manual 2004 - Wheels Academy

More documents

Recommendations

Info

LEONARDO 250 - 300 PERIODIC MAINTENANCE 2.4.2. DRIVING BELT CASING AIR CLEANER WARNING Do not use petrol or inflammable solvents to wash the air cleaner, in order to avoid fires or explosions. Check the conditions of the belt casing air cleaner and clean it every 6000 km. If the vehicle is used on dusty or wet roads, the cleaning operations and any replacement should be carried out more frequently. To remove the filter, proceed as follows: • Position the vehicle on the stand. • Unscrew and remove the three screws (1). • Remove the filter cover (2) and the filter (3). • To clean the filtering element use clean, non-inflammable solvents or solvents with high volatility point, then let it dry thoroughly. WARNING DO NOT OIL THE FILTERING ELEMENT, since the oil may penetrate the belt casing and damage the belt or make it slip. 2 - 11
PERIODIC MAINTENANCE LEONARDO 250 - 300 2.5. COOLANT 2.5.1. COOLANT CHECKING AND TOPPING UP COOLANT LEVEL • Check coolant level before each ride. Change coolant every 2 years. WARNING Check and top up coolant level when the engine is cold. • The engine should be off and completely cold. IMPORTANT Place the motorcycle on firm and level ground. • Position the vehicle on the stand. • Remove front cover, see 7.1.9 (REMOVING THE FRONT COVER). • Check that the coolant level in the expansion (2) reservoir is between the MAX and MIN marks (see figure). If not, proceed as follows: • Release and remove the filler cap (1). WARNING Coolant is toxic when ingested and is an irritant, contact with eyes or skin may cause irritation. Do not put your fingers or any tools into the filler opening to check coolant level. CAUTION Do not add any additives or other products. If you use a funnel or other similar items, make sure that they are perfectly clean. • Add coolant mixture until the level reaches just below the MAX mark. • Never overfill (top up beyond the MAX mark), or coolant will leak out when the engine is running. • Refit the filler cap (1). • Refit front cover, see 7.1.9 (REMOVING THE FRONT COVER). CAUTION In the event the motorcycle is using up exceeding coolant or the expansion (9) reservoir is empty, check the circuit for leaks. 2 - 12
Page 1 and 2: 1194 4 00/2004-04 LEONARDO 250 - 30
Page 3 and 4: INTRODUCTION LEONARDO 250 - 300 CON
Page 5 and 6: INTRODUCTION LEONARDO 250 - 300 0.1
Page 7 and 8: INTRODUCTION LEONARDO 250 - 300 RIG
Page 9 and 10: GENERAL INFORMATION LEONARDO 250 -
Page 31 and 32: PERIODIC MAINTENANCE LEONARDO 250 -
Page 39: PERIODIC MAINTENANCE LEONARDO 250 -
Page 55 and 56: LEONARDO 250 - 300 LUBRICATION LUBR
Page 57 and 58: LEONARDO 250 - 300 LUBRICATION 3.1.
Page 59 and 60: FUEL SYSTEM LEONARDO 250 - 300 CONT
Page 61 and 62: FUEL SYSTEM LEONARDO 250 - 300 TANK
Page 63 and 64: FUEL SYSTEM LEONARDO 250 - 300 4.1.
Page 65 and 66: FUEL SYSTEM LEONARDO 250 - 300 4.2.
Page 67 and 68: FUEL SYSTEM LEONARDO 250 - 300 Key:
Page 69 and 70: FUEL SYSTEM LEONARDO 250 - 300 •
Page 71 and 72: COOLING SYSTEM LEONARDO 250 - 300 C
Page 73 and 74: COOLING SYSTEM LEONARDO 250 - 300 5
Page 79 and 80: LEONARDO 250 - 300 ENGINE ENGINE 6
Page 81 and 82: LEONARDO 250 - 300 ENGINE 6.1. EXHA
Page 83 and 84: LEONARDO 250 - 300 ENGINE • Relea
Page 85 and 86: LEONARDO 250 - 300 ENGINE • Disco
Page 87 and 88: LEONARDO 250 - 300 ENGINE • Place
Page 89 and 90: LEONARDO 250 - 300 ENGINE 6.2.2. RE
Page 91 and 92:
LEONARDO 250 - 300 ENGINE • Conne
Page 93 and 94:
LEONARDO 250 - 300 ENGINE • Refit
Page 95 and 96:
LEONARDO 250 - 300 ENGINE • Refit
Page 97 and 98:
CYCLE PARTS LEONARDO 250 - 300 CONT
Page 99 and 100:
CYCLE PARTS LEONARDO 250 - 300 7.1.
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
Page 107 and 108:
Page 109 and 110:
CYCLE PARTS LEONARDO 250 - 300 •
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
CYCLE PARTS LEONARDO 250 - 300 •
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
CYCLE PARTS LEONARDO 250 - 300 7.10
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
LEONARDO 250 - 300 ELECTRICAL SYSTE
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
show all

Leonardo 250-300 Repair Manual 2004 - Wheels Academy

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?