Leonardo 250-300 Repair Manual 2004 - Wheels Academy

More documents

Recommendations

Info

LEONARDO 250 - 300 FUEL SYSTEM 4.1.2. REMOVING THE FUEL TANK • Position the vehicle on the central stand. WARNING Wait until the engine and the exhaust silencer have completely cooled down. • Remove the footrest, see 7.1.5 (REMOVING THE FOOTPEG). • Remove the lower shield, see 7.1.8 (REMOVING THE LOWER SHIELD). WARNING Fuel vapours are noxious. Before proceeding, make sure that the room in which you are working is properly ventilated. Do not inhale fuel vapours. Neither smoke, nor use free flames. Do not dispose of fuel in the environment. • Drain the fuel tank completely. • Put the fuel in a container, plug it and keep it in a safe place. WARNING Mark the pipes, in order to be able to reconnect them correctly. • Withdraw the two pipes (1-2) from the connections on the filler neck. • Disconnect the electric connector (3) from the fuel level gauge unit. • Working on the lower part of the vehicle, unscrew and remove the screw (4) and take the relevant washer. NOTE Before inserting the screw (4) (right side of the vehicle), position the guide of the accelerator cable and of the rear brake pipe. • Remove the whole fuel tank, withdrawing it from below. 4 - 5
FUEL SYSTEM LEONARDO 250 - 300 4.1.3. REMOVING THE PUMP UNIT • Remove the fuel tank, see 7.1.9 (REMOVING THE REAR-VIEW MIRRORS). WARNING Handle with care. Upon removal, take care not to damage the fuel gauge unit. • Rotate the fuel gauge unit (1) anticlockwise and extract it with care. • Unscrew and remove the ten nuts (2) that fasten the flange (3) to the fuel tank (4). WARNING Handle with care. Upon removal, take care not to damage the fuel pump filter. • Withdraw the flange (3) complete with the fuel pump unit. • Make sure that there are neither deposits, nor impurities on the filter and if necessary clean it. • Wash the inside of the fuel tank. • Withdraw the gasket (5); if it is damaged or its volume has increased, replace it. 4 - 6
Page 1 and 2:
1194 4 00/2004-04 LEONARDO 250 - 30
Page 3 and 4:
INTRODUCTION LEONARDO 250 - 300 CON
Page 5 and 6:
INTRODUCTION LEONARDO 250 - 300 0.1
Page 7 and 8:
INTRODUCTION LEONARDO 250 - 300 RIG
Page 9 and 10:
GENERAL INFORMATION LEONARDO 250 -
Page 11 and 12: GENERAL INFORMATION LEONARDO 250 -
Page 31 and 32: PERIODIC MAINTENANCE LEONARDO 250 -
Page 55 and 56: LEONARDO 250 - 300 LUBRICATION LUBR
Page 57 and 58: LEONARDO 250 - 300 LUBRICATION 3.1.
Page 59 and 60: FUEL SYSTEM LEONARDO 250 - 300 CONT
Page 61: FUEL SYSTEM LEONARDO 250 - 300 TANK
Page 65 and 66: FUEL SYSTEM LEONARDO 250 - 300 4.2.
Page 67 and 68: FUEL SYSTEM LEONARDO 250 - 300 Key:
Page 69 and 70: FUEL SYSTEM LEONARDO 250 - 300 •
Page 71 and 72: COOLING SYSTEM LEONARDO 250 - 300 C
Page 73 and 74: COOLING SYSTEM LEONARDO 250 - 300 5
Page 79 and 80: LEONARDO 250 - 300 ENGINE ENGINE 6
Page 81 and 82: LEONARDO 250 - 300 ENGINE 6.1. EXHA
Page 83 and 84: LEONARDO 250 - 300 ENGINE • Relea
Page 85 and 86: LEONARDO 250 - 300 ENGINE • Disco
Page 87 and 88: LEONARDO 250 - 300 ENGINE • Place
Page 89 and 90: LEONARDO 250 - 300 ENGINE 6.2.2. RE
Page 91 and 92: LEONARDO 250 - 300 ENGINE • Conne
Page 93 and 94: LEONARDO 250 - 300 ENGINE • Refit
Page 95 and 96: LEONARDO 250 - 300 ENGINE • Refit
Page 97 and 98: CYCLE PARTS LEONARDO 250 - 300 CONT
Page 99 and 100: CYCLE PARTS LEONARDO 250 - 300 7.1.
Page 109 and 110: CYCLE PARTS LEONARDO 250 - 300 •
Page 113 and 114:
CYCLE PARTS LEONARDO 250 - 300 7.1.
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
CYCLE PARTS LEONARDO 250 - 300 •
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
CYCLE PARTS LEONARDO 250 - 300 7.10
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
LEONARDO 250 - 300 ELECTRICAL SYSTE
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
show all

Leonardo 250-300 Repair Manual 2004 - Wheels Academy

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?