BZ-33, 44 Series - Waltco

More documents

Recommendations

Info

Chapter 4 Liftgate Installation 24
Chapter 4 Liftgate Installation INSTALL REAR SILL EXTENSION Cut extension so it will extend to within ½” of each side to vehicle body. Position and weld extension, centered on door opening. Note: If the full door seal kit, or flip-up door option are to be used, they will use a different type of sill extension. Note: For vehicles with swing doors, refer to the section in the back of this chapter “Swing door application”. GR00086 POSITIONING OF PLATFORM Using the raise switch, raise lift arms up off the ground as shown. Lift Platform Using an Over-Head Crane or Forklift as shown. Other means may be used to support the platform in position. ALWAYS verify the safety of your supporting method before proceeding. GR00087 INSTALLATION OF LIFT ARMS Align the Lift Arms with the upper holes in the Platform Hinges. Pin the Lift Arms to the Platform Hinges as shown. Secure pins with lock nuts. Platform hinge (inner plate) Platform hinge (outer plate) Platform hinge (middle plate) Pin tang to fully engage in hole of platform hinge (middle plate) GR01762 25
Page 1 and 2: www.waltco.com Phone: 800.411.5685
Page 3 and 4: Introduction If anyone observes imp
Page 5 and 6: Liftgates with Tilt Function Prope
Page 7 and 8: Chapter 2 Liftgate Terminology EXPL
Page 9 and 10: Chapter 3 Basic Mounting Requiremen
Page 11 and 12: Chapter 4 Liftgate Installation CON
Page 13 and 14: Chapter 4 Liftgate Installation Jac
Page 15 and 16: Chapter 4 Liftgate Installation 15
Page 17 and 18: Chapter 4 Liftgate Installation Ele
Page 19 and 20: Chapter 4 Liftgate Installation SHU
Page 21 and 22: Chapter 4 REMOVE TRANSPORT PLUG Lif
Page 23: Chapter 4 Liftgate Installation Fun
Page 27 and 28: Chapter 4 Liftgate Installation WEL
Page 29 and 30: Chapter 4 Liftgate Installation HYD
Page 31 and 32: Chapter 4 ADJUSTING TILT DOWN ANGLE
Page 33 and 34: Chapter 4 INSTALLATION OF 3-PIECE B
Page 35 and 36: Chapter 4 Liftgate Installation FIN
Page 37 and 38: Chapter 5 Placement of Decals INSTA
Page 39 and 40: Chapter 5 Placement of Decals SAFET
Page 41 and 42: Chapter 6 Lubrication LUBRICATION I
Page 43 and 44: BATTERY KIT INSTALLATIONS 80101387
Page 49 and 50: INSTALLATION OF FULL-DOOR SEAL KIT
Page 51 and 52: 5. Insert the Rubber Seal & Air Foi
Page 53 and 54: FLIP-UP DOOR INSTALLATION Install R
Page 55 and 56: FLIP-UP DOOR INSTALLATION Insert bu
Page 57 and 58: FLIP-UP DOOR INSTALLATION Install P
Page 59 and 60: FLIP-UP DOOR INSTALLATION Size door
Page 61 and 62: FLIP-UP DOOR INSTALLATION Install c
Page 63 and 64: FLIP-UP DOOR INSTALLATION Install d
Page 65 and 66: FLIP-UP DOOR INSTALLATION Secure Do
Page 67 and 68: Every vehicle that has a WALTCO Lif

BZ-33, 44 Series - Waltco

Create successful ePaper yourself

Delete template?

Save as template?