RT120Q Operator's Manual - Ditch Witch

More documents

Recommendations

Info

RT120Q Operator’s Manual Overview - 3 Intended Use Intended Use The RT120Q is a riding trencher designed to install buried service lines of various sizes using a variety of Ditch Witch attachments. Attachment Max. width/diameter Max. depth H910 trencher 24” (610 mm) 96” (2.4 m) H911 trencher 24” (610 mm) 92” (2.3 m) H1032 plow 3” (80 mm) 42” (1.07 m) H1052 combo n/a 70” (1.78 m) H1140 saw 103” (1.03 m) 40.5” (1.03 m) RC120 reel carrier 84” (2.13 m) reel dia n/a A920 backhoe 24” (610 mm) 105” (2.7 m) This unit is designed for operation in temperatures typically experienced in earth moving and construction work environments. Provisions may be required to operate in extreme temperatures. Contact your Ditch Witch dealer. Use in any other way is considered contrary to the intended use. The RT120Q should be used with genuine Ditch Witch chain, teeth, and sprockets. It should be operated, serviced, and repaired only by persons familiar with their particular characteristics and acquainted with the relevant safety procedures. Equipment Modification This equipment was designed and built in accordance with applicable standards and regulations. Modification of equipment could mean that it will no longer meet regulations and may not function properly or in accordance with the operating instructions. Modification of equipment should only be made by competent personnel possessing knowledge of applicable standards, regulations, equipment design functionality/requirements and any required specialized testing. The protection offered by the Rollover Protective System (ROPS) will be impaired if it has been subjected to any modification, structural damage, or has been involved in an overturn accident. The ROPS must be replaced after a roll-over. CMW
Overview - 4 Unit Components RT120Q Operator’s Manual Unit Components 2 3 4 1 5 t37om003w.eps 1. Rollover Protective Structure (ROPS) 2. Operator station 3. Control console 4. Engine compartment 5. Backfill blade (optional) WARNING: The protection offered by the Rollover Protective System (ROPS) will be impaired if it has been subjected to any modification, structural damage, or has been involved in an overturn accident. The ROPS must be replaced after a roll-over. CMW
Page 1 and 2: RT120Q Operator’s Manual Issue 1.
Page 3: Overview - 2 Serial Number Location
Page 7 and 8: Overview - 6 RT120Q Operator’s Ma
Page 9 and 10: Foreword - 8 RT120Q Operator’s Ma
Page 11 and 12: Contents - 10 RT120Q Operator’s M
Page 13 and 14: Safety - 12 RT120Q Operator’s Man
Page 15 and 16: Safety - 14 Safety Alerts RT120Q Op
Page 17 and 18: Safety - 16 RT120Q Operator’s Man
Page 19 and 20: Safety - 18 If an Electric Line is
Page 21 and 22: Safety - 20 If a Fiber Optic Cable
Page 23 and 24: Controls - 22 Center Console RT120Q
Page 25 and 26: Controls - 24 RT120Q Operator’s M
Page 27 and 28: Controls - 26 Graphic Display RT120
Page 37 and 38: Controls - 36 Diagnostics RT120Q Op
Page 43 and 44: Controls - 42 Left Console RT120Q O
Page 55 and 56:
Controls - 54 RT120Q Operator’s M
Page 57 and 58:
Controls - 56 Backhoe Console RT120
Page 59 and 60:
Page 61 and 62:
Controls - 60 Saw Controls RT120Q O
Page 63 and 64:
Controls - 62 Drill Controls RT120Q
Page 65 and 66:
Page 67 and 68:
Operation Overview - 66 Planning RT
Page 69 and 70:
Operation Overview - 68 RT120Q Oper
Page 71 and 72:
Prepare - 70 Gather Information RT1
Page 73 and 74:
Prepare - 72 Classify Jobsite RT120
Page 75 and 76:
Prepare - 74 Check Supplies and Pre
Page 77 and 78:
Drive - 76 Start Unit RT120Q Operat
Page 79 and 80:
Drive - 78 Drive RT120Q Operator’
Page 81 and 82:
Drive - 80 Shut Down RT120Q Operato
Page 83 and 84:
Transport - 82 Lift RT120Q Operator
Page 85 and 86:
Transport - 84 RT120Q Operator’s
Page 87 and 88:
Page 89 and 90:
Transport - 88 Haul RT120Q Operator
Page 91 and 92:
Page 93 and 94:
Page 95 and 96:
Trench - 94 Setup RT120Q Operator
Page 97 and 98:
Trench - 96 Operation RT120Q Operat
Page 99 and 100:
Trench - 98 RT120Q Operator’s Man
Page 101 and 102:
Trench - 100 RT120Q Operator’s Ma
Page 103 and 104:
Plow - 102 Setup RT120Q Operator’
Page 105 and 106:
Plow - 104 RT120Q Operator’s Manu
Page 107 and 108:
Plow - 106 Prepare RT120Q Operator
Page 109 and 110:
Plow - 108 Finish Plowing RT120Q Op
Page 111 and 112:
Plow - 110 RT120Q Operator’s Manu
Page 113 and 114:
Reel Carrier - 112 Setup RT120Q Ope
Page 115 and 116:
Reel Carrier - 114 RT120Q Operator
Page 117 and 118:
Backhoe - 116 Setup RT120Q Operator
Page 119 and 120:
Backhoe - 118 Stow RT120Q Operator
Page 121 and 122:
Backhoe - 120 RT120Q Operator’s M
Page 123 and 124:
Drill - 122 Drilling Attachment RT1
Page 125 and 126:
Drill - 124 Drill Rod and Equipment
Page 127 and 128:
Drill - 126 Using Drill String Guid
Page 129 and 130:
Drill - 128 Disassemble Joints RT12
Page 131 and 132:
Saw - 130 Setup RT120Q Operator’s
Page 133 and 134:
Saw - 132 Operation RT120Q Operator
Page 135 and 136:
Saw - 134 RT120Q Operator’s Manua
Page 137 and 138:
Saw - 136 RT120Q Operator’s Manua
Page 139 and 140:
Systems and Equipment - 138 Cruise
Page 141 and 142:
Systems and Equipment - 140 Chain,
Page 143 and 144:
Systems and Equipment - 142 Optiona
Page 145 and 146:
Complete the Job - 144 Restore Jobs
Page 147 and 148:
Service - 146 Service Precautions R
Page 149 and 150:
Service - 148 Tier 4i Engine RT120Q
Page 151 and 152:
Service - 150 RT120Q Operator’s M
Page 153 and 154:
Service - 152 Approved Coolant RT12
Page 155 and 156:
Service - 154 Tractor RT120Q Operat
Page 157 and 158:
Page 159 and 160:
Service - 158 Trencher RT120Q Opera
Page 161 and 162:
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
Service - 168 Check Track Tension C
Page 171 and 172:
Service - 170 250 Hour RT120Q Opera
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Service - 176 1000 Hour RT120Q Oper
Page 179 and 180:
Service - 178 2000 Hour RT120Q Oper
Page 181 and 182:
Service - 180 As Needed RT120Q Oper
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
Page 189 and 190:
Specifications - 188 RT120Q Operato
Page 191 and 192:
Page 193 and 194:
Page 195 and 196:
Page 197 and 198:
Page 199 and 200:
Page 201 and 202:
Page 203 and 204:
Page 205 and 206:
Specifications - 204 H1140 Saw RT12
Page 207:
Warranty - 206 RT120Q Operator’s
Page 211:
Service Record - 210 RT120Q Operato
show all

RT120Q Operator's Manual - Ditch Witch

Create successful ePaper yourself

Delete template?

Save as template?