Thinkpad T500 and W500 Hardware Maintenance Manual - Lenovo

More documents

Recommendations

Info

Note Before using this information and the product it supports, be sure to read the general information under “Notices” on page 261. Fifth Edition (September 2009) © Copyright Lenovo 2008, 2009. LENOVO products, data, computer software, and services have been developed exclusively at private expense and are sold to governmental entities as commercial items as defined by 48 C.F.R. 2.101 with limited and restricted rights to use, reproduction and disclosure. LIMITED AND RESTRICTED RIGHTS NOTICE: If products, data, computer software, or services are delivered pursuant a General Services Administration ″GSA″ contract, use, reproduction, or disclosure is subject to restrictions set forth in Contract No. GS-35F-05925. © Lenovo 2008, 2009
Contents About this manual . . . . . . . . . . v Safety information . . . . . . . . . . 1 General safety . . . . . . . . . . . . . . 2 Electrical safety . . . . . . . . . . . . . 3 Safety inspection guide . . . . . . . . . . . 5 Handling devices that are sensitive to electrostatic discharge . . . . . . . . . . . . . . . 6 Grounding requirements . . . . . . . . . . 6 Safety notices (multilingual translations) . . . . . 7 Laser compliance statement (multilingual translations) . . . . . . . . . . . . . . 28 Important service information . . . . . 39 Strategy for replacing FRUs . . . . . . . . . 39 Strategy for replacing a hard disk drive . . . . 40 Important notice for replacing a system board . . 40 How to use error message . . . . . . . . 40 Strategy for replacing FRUs for CTO, CMV, and GAV. . . . . . . . . . . . . . . . . 41 Product definition . . . . . . . . . . . 41 FRU identification for CTO, CMV, and GAV products . . . . . . . . . . . . . . 41 General checkout . . . . . . . . . . 43 What to do first . . . . . . . . . . . . . 44 Checkout guide . . . . . . . . . . . . . 45 Diagnostics using PC-Doctor for DOS . . . . 45 Lenovo ThinkVantage Toolbox (Lenovo System Toolbox) . . . . . . . . . . . . . . 48 PC-Doctor for Windows . . . . . . . . . 48 PC-Doctor for Rescue and Recovery . . . . . 49 FRU tests . . . . . . . . . . . . . . 50 Power system checkout . . . . . . . . . . 52 Checking the AC adapter . . . . . . . . . 52 Checking operational charging . . . . . . . 53 Checking the battery pack . . . . . . . . 53 Checking the backup battery . . . . . . . 54 Related service information. . . . . . 55 Restoring the factory contents by using Product Recovery discs . . . . . . . . . . . . . 55 Restoring the factory contents by using Recovery Disc Set . . . . . . . . . . . . . . . 56 Passwords . . . . . . . . . . . . . . . 57 Power-on password . . . . . . . . . . 57 Hard-disk password . . . . . . . . . . 57 Supervisor password . . . . . . . . . . 58 How to remove the power-on password . . . . 58 How to remove the hard-disk password . . . . 59 Power management . . . . . . . . . . . 60 Screen blank mode . . . . . . . . . . . 60 Sleep (Standby) mode . . . . . . . . . . 60 Hibernation mode . . . . . . . . . . . 61 Symptom-to-FRU index . . . . . . . . . . 62 Numeric error codes . . . . . . . . . . 62 Error messages . . . . . . . . . . . . 66 Beep symptoms . . . . . . . . . . . . 67 No-beep symptoms. . . . . . . . . . . 67 LCD-related symptoms . . . . . . . . . 68 Intermittent problems . . . . . . . . . . 69 Undetermined problems . . . . . . . . . 69 Status indicators . . . . . . . . . . 71 Fn key combinations . . . . . . . . 75 FRU replacement notices . . . . . . . 79 Screw notices . . . . . . . . . . . . . . 79 Retaining serial numbers . . . . . . . . . . 80 Restoring the serial number of the system unit 80 Retaining the UUID . . . . . . . . . . 80 Reading or writing the ECA information . . . 81 Removing and replacing a FRU . . . . 83 1010 Battery pack . . . . . . . . . . . . 84 1020 Serial Ultrabay Slim device . . . . . . . 85 1030 Hard disk drive (HDD) cover, HDD and HDD rubber rails or solid state drive (SSD) and storage converter . . . . . . . . . . . . . . . 86 1040 Palm rest or palm rest with fingerprint reader 88 1050 DIMM . . . . . . . . . . . . . . 91 1060 Keyboard . . . . . . . . . . . . . 92 1070 Modem daughter card (MDC-3.0) . . . . . 94 1080 PCI Express Mini Card for wireless LAN/WiMAX . . . . . . . . . . . . . 96 1090 Intel Turbo Memory Minicard or Wireless USB adapter . . . . . . . . . . . . . . . . 98 1100 Backup battery . . . . . . . . . . . 100 1110 SIM card slot . . . . . . . . . . . . 101 1120 Keyboard bezel . . . . . . . . . . . 102 1130 PCI Express Mini Card for wireless WAN . . 104 1140 Speaker assembly . . . . . . . . . . 106 1150 Fan assembly. . . . . . . . . . . . 108 1160 CPU. . . . . . . . . . . . . . . 112 1170 LCD unit . . . . . . . . . . . . . 113 1180 Base cover and USB sub card with cable. . . 116 1190 Structure frame . . . . . . . . . . . 121 1200 System board and ExpressCard slot assembly 124 2010 LCD front bezel (LCD cover kit) . . . . . 127 2020 LCD rear cover (LCD cover kit) . . . . . 129 2030 Inverter card or LED control card . . . . . 130 2040 Integrated camera . . . . . . . . . . 131 2050 Bluetooth daughter card (BDC-2.1) . . . . 132 2060 Antenna assembly . . . . . . . . . . 133 2070 LCD panel and LCD cable . . . . . . . 136 2080 Hinges and LCD magnesium frame . . . . 139 © Copyright Lenovo 2008, 2009 iii
Page 1: ThinkPad T500 and W500 Hardware Mai
Page 6 and 7: Locations . . . . . . . . . . . . .
Page 8 and 9: vi ThinkPad T500 and W500 Hardware
Page 10 and 11: General safety Follow these rules t
Page 12 and 13: v Do not touch live electrical circ
Page 14 and 15: Handling devices that are sensitive
Page 16 and 17: DANGER Before the computer is power
Page 18 and 19: 10 ThinkPad T500 and W500 Hardware
Page 20 and 21: PERIGO Antes de ligar o computador
Page 22 and 23: DANGER Avant de remettre l’ordina
Page 24 and 25: VORSICHT Bevor nach einem FRU-Austa
Page 32 and 33: PELIGRO Antes de encender el sistem
Page 36 and 37: Laser compliance statement (multili
Page 38 and 39: Alguns modelos de computador ThinkP
Page 40 and 41: Einige ThinkPad-Modelle sind werkse
Page 44 and 45: Algunos modelos de sistemas ThinkPa
Page 48 and 49: Use the following strategy to preve
Page 50 and 51: v Business Partners using Eclaim wi
Page 52 and 53: What to do first When you do return
Page 54 and 55:
Testing the computer Note: The PC-D
Page 56 and 57:
v DOS Shell v Tech Support Form v B
Page 58 and 59:
FRU tests The following table shows
Page 60 and 61:
Power system checkout To verify a s
Page 62 and 63:
Checking the backup battery Do the
Page 64 and 65:
8. When the recovery process is com
Page 66 and 67:
Note: There are two modes for the H
Page 68 and 69:
Power management To reduce power co
Page 70 and 71:
Symptom-to-FRU index This section c
Page 72 and 73:
Table 2. Numeric error codes (conti
Page 74 and 75:
Error messages Table 3. Error messa
Page 76 and 77:
LCD-related symptoms Important: The
Page 78 and 79:
70 ThinkPad T500 and W500 Hardware
Page 80 and 81:
Table 7. Status indicators Indicato
Page 82 and 83:
Page 84 and 85:
Table 8. Fn key combinations (conti
Page 86 and 87:
Page 88 and 89:
Retaining serial numbers This secti
Page 90 and 91:
Page 92 and 93:
1010 Battery pack Important notice
Page 94 and 95:
1030 Hard disk drive (HDD) cover, H
Page 96 and 97:
1040 Palm rest or palm rest with fi
Page 98 and 99:
Table 13. Installation of the palm
Page 100 and 101:
1060 Keyboard For access, remove th
Page 102 and 103:
1070 Modem daughter card (MDC-3.0)
Page 104 and 105:
1080 PCI Express Mini Card for wire
Page 106 and 107:
1090 Intel Turbo Memory Minicard or
Page 108 and 109:
1100 Backup battery DANGER Use only
Page 110 and 111:
1120 Keyboard bezel For access, rem
Page 112 and 113:
1130 PCI Express Mini Card for wire
Page 114 and 115:
1140 Speaker assembly For access, r
Page 116 and 117:
1150 Fan assembly For access, remov
Page 118 and 119:
Table 26. Installation of the fan a
Page 120 and 121:
1160 CPU For access, remove these F
Page 122 and 123:
Table 28. Removal steps of LCD asse
Page 124 and 125:
1180 Base cover and USB sub card wi
Page 126 and 127:
Table 29. Removal steps of base cov
Page 128 and 129:
Note: Applying labels to the base c
Page 130 and 131:
Table 30. Removal steps of structur
Page 132 and 133:
1200 System board and ExpressCard s
Page 134 and 135:
Table 31. Removal steps of system b
Page 136 and 137:
Table 32. Removal steps of LCD fron
Page 138 and 139:
2030 Inverter card or LED control c
Page 140 and 141:
2050 Bluetooth daughter card (BDC-2
Page 142 and 143:
Table 37. Removal steps of antenna
Page 144 and 145:
2070 LCD panel and LCD cable For ac
Page 146 and 147:
Table 38. Removal steps of LCD pane
Page 148 and 149:
Page 150 and 151:
Rear view Bottom view ▌1▐ Statu
Page 152 and 153:
Overall 144 ThinkPad T500 and W500
Page 154 and 155:
Table 40. Parts list—Overall (con
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162 and 163:
Page 164 and 165:
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Page 176 and 177:
Page 178 and 179:
Page 180 and 181:
Page 182 and 183:
Page 184 and 185:
Page 186 and 187:
Page 188 and 189:
Page 190 and 191:
Page 192 and 193:
Page 194 and 195:
Page 196 and 197:
Page 198 and 199:
Page 200 and 201:
Page 202 and 203:
Page 204 and 205:
Page 206 and 207:
Page 208 and 209:
Page 210 and 211:
Page 212 and 213:
Page 214 and 215:
Page 216 and 217:
Page 218 and 219:
Page 220 and 221:
Page 222 and 223:
Page 224 and 225:
Page 226 and 227:
Page 228 and 229:
Table 41. Parts list—15.4-in. WXG
Page 230 and 231:
Page 232 and 233:
Page 234 and 235:
Page 236 and 237:
Page 238 and 239:
Table 42. Parts list—15.4-in. WSX
Page 240 and 241:
Table 42. Parts list—15.4-in. WSX
Page 242 and 243:
Table 43. Parts list—15.4-in. WUX
Page 244 and 245:
Table 43. Parts list—15.4-in. WUX
Page 246 and 247:
Table 45. Parts list—Keyboard Lan
Page 248 and 249:
Table 46. Parts list—Miscellaneou
Page 250 and 251:
Power cords A ThinkPad power cord f
Page 252 and 253:
Table 51. Parts list—Windows XP P
Page 254 and 255:
Table 52. Parts list—Windows Vist
Page 256 and 257:
Windows Vista Business (32 bit) DVD
Page 258 and 259:
Windows Vista Business (64 bit) DVD
Page 260 and 261:
Table 56. Parts list—Windows Vist
Page 262 and 263:
Windows 7 Home Premium (32 bit) DVD
Page 264 and 265:
Windows 7 Professional (32 bit) DVD
Page 266 and 267:
Windows 7 Professional (64 bit) DVD
Page 268 and 269:
Page 270:
Trademarks vary significantly. Some
show all

Thinkpad T500 and W500 Hardware Maintenance Manual - Lenovo

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?