Experimental Study of Biodegradation of Ethanol and Toluene Vapors

More documents

Recommendations

Info

Lee, J. C., and D. L. Meyrick, 1970. “Gas-liquid interfacial areas in salt solutions in an agitated tank”, Trans. Instn. Chem. Engrs. (London), 48: T37. Leson, G. and A. M. Winer, 1991. “Biofiltration: An innovative air pollution control technology for VOC emissions”, J. Air and Waste Manage. Assoc., 41(8):1045-1054. Levenspiel, O., 1972. Chemical Reaction Engineering. John Wiley & Sons, Inc., New York, N. Y., 476. Lodaya, M.; F. Lakhwala; E. Rus; M. Singh; G. Lewandowski, and S. Sofer, 1991. “Biodegradation of benzene and a BTX mixture using immobilized activated sludge”, J. Environ. Sci. Health, A26(1):121-137. Luong, J. H. T., 1987. “Generalization of Monod Kinetics for Analysis of Growth Data With Substrate Inhibition”, Biotechnol. Bioeng., 29: 242-248. Lyman, W.J., W.F. Reehl, and D. H. Rosenblatt, 1982. Handbook of Chemical Property Estimation Methods, McGraw-Hill Book Company. Machado, R. J., and Leslie Grady, Jr., C. P., 1989. “Dual Substrate Removal by an Axenic Bacterial Culture”, Biotechnol. Bioeng., 33:327-337. Marek, J.; J. Paca, and A. M. Gerrard, 2000. “Dynamic responses of biofilters to changes in the operating conditions in the process of removing toluene and xylene from air”, Acta Biotechbol., 20(1): 17-29. Mason, C. A.; G. Ward; K. Abu-Salah; O. Keren, and C. G. Dosoretz, 2000. “Biodegradation of BTEX by bacteria on powdered activated carbon”, Bioprocess Eng., 23: 331-336. Merchuk, J. C., S. Yona, M. H. Siegel, and A. B. Zvi, 1990. “The first-order approximation to the response of dissolved oxygen electrodes for dynamic k L a estimation”, Biotechnol. Bioeng., 35: 1161-1163. Morales, M.; F. Perez; R. Auria, and S. Revah, 1994. “Toluene removal from air stream by biofiltration”, in “Advances in Bioprocess Engineering”, E. Galindo and O.T. Ramlrez (eds.), Kluwer Academic Publishers. pp. 405-411. Nakao, K.; M. A. Ibrahim; Y. Yasuda, and K. Fukunaga, 2000. “Removal of volatile organic compounds from waste gas in packed column with immobilized activated sludge gel beads”, Bioseparation Eng., 16: 187-192. Nielsen, J., J. Villadsen, and G. Liden, 2003. Bioreaction Engineering Principles, 2 nd Edition, Kluwer Academic /Plenum Publishers, New York. 162
Orshansky, F., and N. Narkis, 1997. “Characteristics of organics removal by PACT simultaneous adsorption and biodegradation”, Wat Res., 31 (3): 391-398. Ottengraf, S. P. P., 1986. “Exhaust gas purification”, Biotechnol., H. J. Rehm and G. Reed (eds.), VHC, Weinhem, 8: 425-451. Parvatiyar, M. G.; R. Govind, and D. F. Bishop, 1996. “Biodegradation of toluene in a membrane biofilter”, J. Membrane Sci., 119: 17-24. Passant, N. R.; S. J. Richardson; R. P. J. Swannell; M. Woodfield; J. P. van der Lugt; J. H. Wolsink; P.G.M. Hesselink; V. Hecht; D. Brebbermann and H. Bischoff, 1992. “Biodegradability of the volatile organic compound (VOC) emissions from the food, drink and metal degreasing industries”, Studies in Environ. Sci., 51:315 – 320. Pederson, A. R., and E. Arvin, 1999. “The function of a toluene-degrading bacterial community in a waste gas trickling filter”, Wat. Sci. Tech., 39(7): 131-137. Purwaningsih, I.S, 2002, Mass transfer and Bioremediation of solid polycyclic aromatic hydrocarbon (PAH) particles in bioreactors, Ph.D Thesis, University of Saskatchewan. Ramirez-Lopez, E. M.; A. Montillet; J. Comiti and P. Le Clolrec, 2000. “Biofiltration of volatile organic compounds – application to air treatment”, Wat. Sci. Technol., 41 (12):183-190. Reardon, K. F.; J. R. Conuel, and D. C. Mosteller, 1994. “Biodegradation kinetics and bioreactor strategy for aromatic hydrocarbon and trichloroethylene mixtures”, Proceedings of the 9 th Annual Conferences on Hazardous Waste Remediation, June 8-10, pp. 51-65. Reardon, K. F.; D. C. Mosteller; and J. D. B. Rogers, 2000. “Biodegradation kinetics of benzene, toluene, and phenol as single and mixed substrates for Pseudomonas putida F1”, Biotechnol. Bioeng., 69(4): 385-400. Reece, C. S.; M. Lordgooei, and M. J. Rood, “Activated carbon fiber cloth adsorber with cryogenic condensation to capture and recover MEK and toluene from gas streams”, Air & Waste Management Association’s 91 st Meetings & Exhibition, June 14-18, 1998, San Diego, California. Robinson, C. W. and C. R. Wilke, 1973. “Oxygen absorption in stirred tanks: a correlation for ionic strength effects”, Biotechnol. Bioeng., XV: 755-782. Robinson, C. W. and C. R. Wilke, 1974. “Simultaneous measurement of interfacial area and mass transfer coefficients for a well-mixed gas dispersion in aqueous electrolyte solutions”, AIChE J., 20(2): 285-294. 163
Page 1 and 2:
BIOREMEDIATION OF VOLATILE ORGANIC
Page 3 and 4:
ABSTRACT The mass transfer of ethan
Page 5 and 6:
effect on the growth of P. putida.
Page 7 and 8:
ACKNOWLEDGMENT Of the countless peo
Page 9 and 10:
TABLE OF CONTENTS PERMISSION TO USE
Page 11 and 12:
4.3 Batch Growth on Ethanol and Ben
Page 13 and 14:
LIST OF FIGURES Figure 3-1. Schemat
Page 15 and 16:
Figure 5.3 (b) Simulation of ethano
Page 17 and 18:
Figure 5-16. Continuous removal of
Page 19 and 20:
NOMENCLATURE a - Interfacial area,
Page 21 and 22:
CHAPTER ONE - INTRODUCTION 1.1 Air
Page 23 and 24:
esults (van Groenestijn and Hesseli
Page 25 and 26:
experimental results are presented
Page 27 and 28:
Table 2.2 VOC Emissions in the U.S.
Page 29 and 30:
(paint shop effluents, for instance
Page 31 and 32:
combustion provides 70 to 90% air p
Page 33 and 34:
used to degrade ethanol vapours and
Page 35 and 36:
g m -3 . This would suggest that th
Page 37 and 38:
treatment, This excessive biomass f
Page 39 and 40:
The simultaneous degradation of tol
Page 41 and 42:
emoves only water-soluble gases. Wa
Page 43 and 44:
2.2.6 Pseudomonas It is well known
Page 45 and 46:
2.3.2 Growth Models with Inhibition
Page 47 and 48:
where µ is the total specific grow
Page 49 and 50:
2.4.1 Batch Reactor In a batch reac
Page 51 and 52:
discharged from the other end. The
Page 53 and 54:
element solution consisted of (gram
Page 55 and 56:
growth on ethanol, 20-48 hours for
Page 57 and 58:
Gas phase samples of toluene were c
Page 59 and 60:
Inlet sampler Exit sampler To fume
Page 61 and 62:
Once the oxygen meter indicated a s
Page 63 and 64:
centrifuged and the supernatant was
Page 65 and 66:
where k L a is the volumetric mass
Page 67 and 68:
Figure 4-2a shows ethanol liquid co
Page 69 and 70:
coefficient (k L a) in the well-mix
Page 71 and 72:
calculated by dividing the gas volu
Page 73 and 74:
Average bubble diameter, mm 8 7 6 5
Page 75 and 76:
Bioflow III bioreactor. Equation (4
Page 77 and 78:
3.5 y=Ln(S0/S) 3 2.5 2 1.5 1 y = 12
Page 79 and 80:
Ethanol and biomass concentration,
Page 81 and 82:
4.3.2 Batch Growth on Benzyl Alcoho
Page 83 and 84:
Biomass and benzyl alcohol concentr
Page 85 and 86:
ethanol loading was beyond the maxi
Page 87 and 88:
Table 4-2. Comparison of bioremedia
Page 89 and 90:
Biomass, benzyl alcohol and toluene
Page 91 and 92:
4.4.3 Toluene-ethanol Bioremediatio
Page 93 and 94:
Substrate and biomass concentration
Page 95 and 96:
Biomass and benzyl alcohol concentr
Page 97 and 98:
Biomass and benzoic acid concentrat
Page 99 and 100:
ethanol. These results clearly indi
Page 101 and 102:
CHAPTER FIVE - MATHEMATICAL MODELIN
Page 103 and 104:
The stoichiometry of the biomass sy
Page 105 and 106:
synthesis and in the ethanol catabo
Page 107 and 108:
1 max Y ex = − 0.635 + 2δ + K 3
Page 109 and 110:
Biomass Eq.5-18 Benzyl Alcohol Eq.5
Page 111 and 112:
r x r N -1.27 -1 0 1 0 0 -0.2 0 0 2
Page 113 and 114:
φ = −θ b ⋅ν (5-31) φ b = 1.
Page 115 and 116:
The data sets used to evaluate the
Page 117 and 118:
Figures 5.4a and 5.4b present 95% c
Page 119 and 120:
Ethanol and biomass concentration (
Page 121 and 122:
Ethanol measured (C-mol/L) 0.3 0.25
Page 123 and 124:
Figures 5.5 (a-d) demonstrate the s
Page 125 and 126:
Benzyl alcohol and biomass concentr
Page 127 and 128:
Benzyl alcohol measured (C-mol/L) 0
Page 129 and 130:
x = 5 ∑ i= 1 x N i (5-40) where x
Page 131 and 132: ethanol in a steady state mode is l
Page 133 and 134: where ν 1 , ν 2 , ν 3, ν 4 are
Page 135 and 136: Biomass concentration, g/L 1.5 1 0.
Page 137 and 138: φ T =ν 4 (5-53b) φx = −ν 1 (5
Page 139 and 140: In this study, a metabolic model ha
Page 141 and 142: Equations (5-34) and (5-35) and the
Page 143 and 144: ATP 1 = Y max ATP r x + m ATP ⋅ C
Page 145 and 146: Ethanol, biomass and ammonium conce
Page 147 and 148: Figure 5-13a shows that the lower t
Page 149 and 150: Biomass, substrate concentrations,
Page 151 and 152: C e DKe = (5-63) μ − D m Equatio
Page 153 and 154: corresponds with the value associat
Page 155 and 156: Biomass and ethanol concentrations
Page 157 and 158: than 4.0 mg/L at all dilution rates
Page 159 and 160: Biomass, benzyl alcohol and ammonia
Page 161 and 162: negligible ( y out , e = 0) , and e
Page 163 and 164: Figure 5-17 shows the results at a
Page 165 and 166: Biomass Concentrations, g/L 3.5 3 2
Page 167 and 168: C x ( 1 max Q max = ⋅{ D( Cb0 −
Page 169 and 170: 1.2 g/L, the system could not be op
Page 171 and 172: The continuous models can capture a
Page 173 and 174: • Air stripping coefficients obta
Page 175 and 176: Toluene acts as an inhibitor on the
Page 177 and 178: Bruining, W. J., G. E. H. Joosten,
Page 179 and 180: Falatko, D. M., and J. T. Novak, 19
Page 181: Keuning, S., and D. Jager, 1994.
Page 185 and 186: Togna, A. P, M. Singh, 1994. “Bio
Page 187 and 188: APPENDIX A. Important Metabolic Pat
Page 189 and 190: III. Toluene Pathway (Adapted from
Page 191 and 192: Appendix B. Calibration Procedure a
Page 193 and 194: Figure B-2. Pseudomonas putida (ATC
Page 195 and 196: Appendix B-3. Calibration of Chemic
Page 197 and 198: Appendix B-4. Calibration of Toluen
Page 199 and 200: Appendix C. Experimental Results: A
Page 201 and 202: Probe response time, s 12 10 8 6 4
Page 203 and 204: Appendix C-2. Fed-batch Operation B
Page 205 and 206: Appendix D: Mathematical Solutions
Page 207 and 208: The microscopic model allows the fo
Page 209 and 210: 13δ Y o , = 0.585 2 x = (D-24) (8K
Page 211 and 212: 2 σ = −1.3E − 06 (E-11) Y xe Y
Page 213: Biomass, ethanol, and acetic acid c
show all

Experimental Study of Biodegradation of Ethanol and Toluene Vapors

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?