Plant 44 Audit Reports - Wright-Patterson Air Force Base

More documents

Recommendations

Info

FOR OFFICIAL USE ONLYDistribution authorized to 000 components and their contractors only; administrative/operational use; August19,2005. Other requests for this'document shall be referred to the Chief, Acquisition Environmental Safety &Health Division, Engineering Directorate, ASCIENV, Wright Patterson Air Force Base, OH 45433No - since they believe they are/were meeting standards, no ORM plans have not been developed.Ref: AFI 32-2001. 2.3Item # 004 Has the Fire Chief developed and implemented management plans for the following areas:a. Fire risk management plans and operational policies when resources and staffing levels fall below AirForce standards?Yes - Raytheon has Standard Operating Procedures that establish staffing requirements and providesguidance in event a backfill is required.b. ORM plans when the fire department fails to comply with DoD and Air Force instructions. OSHAregulations, and NFPA standards?No - There are no ORM plans in place.c. Firefighter occupational and health program?Yes - There is an occupational and health program in effect.d. Procedures to ensure environmental pOllution control during all fire protection activities?No - It was not readily evident that procedures are in place to ensure there is environmental pollution control.e. Hazardous materials emergency response?Yes - There is a plan in place to handle hazardous materials response.f. Responses to incidents occurring in rough and difficult to reach terrain and off-installation AirfieldCompatibility Use Zone (AICUZ) areas.N/A. This is not applicable since Raytheon does not have any ARFF responsibilities.g. Selective response procedures to reduce the number of aircraft rescue and fire fighting vehiclesresponding to an emergency when appropriate?N/A. This is not applicable since Raytheon does not have any ARFF responsibilities.h. Confined space rescue?Yes - There is a confined space rescue plan in place.Yes but limited.Emergency medical response?j. Off-installation responses?Yes - The off installation response is limited to mutual aid agreements.Ref: AFI 32-2001, 3.1.2ATCH 1
FOR OFFICIAL USE ONLYDistribution authorized to DoD components and their contractors only; administrative/operational use; August19,2005. Other requests for this document shall be referred to the Chief, Acquisition Environmental Safety &Health Division, Engineering Directorate, ASCIENV, Wright Patterson Air Force Base, OH 45433Item # 005 Are sufficient number and type of vehicles available to meet mission requirements?Raytheon has one 1250 gpm engine and one 750 gpm engine. They also have one rescue vehicle. A fuelloading analysis needs to be made of Raytheon's most hazardous non sprinkled facility to determine fire flowrequirements. This will determine if the current pumpers can meet the fire flow demand. (action item)Ref: AFI 32·2001, 3.1.2.1Item # 006 Are sufficient personnel on duty to properly staff vehicles?No. There are 5-8 fire fighters on duty. Required per DoD! 6055 is 4 fire fighters per truck per shift andthey'll need two trucks for first response. A rescue vehicle also has to be staffed with three fire fighters.Including the incident commander, this translate to 12 fire fighters per shift. (action item)Ref: AFI 32-2001, 3.1.2Item # 007 How do the Fire Chief and Base Civil Engineer inform the installation commander of fire departmentcapabilities?Within Raytheon's management structure, the telephone is the most common means of communicating firedepartment capabilities.Ref: AFI 32-2001, 3.1.2Item # 008 Has the Fire Chief established standard operating procedures on incident response priorities for approval bythe installation commander?No - Raytheon's management structure does not require a SOP (action item).Ref: AFI 32-2001, 3.12.3Item # 009 Do firefighters perform additional duties outside the fire department compromising mission support and AirForce acceptable levels of risk for safe fire fighting as determined by the Fire Chief?No - The fire fighters do not perform additional duties outside the fire department mission.Ref: AFI 32-2001, 3.16 & Atch 3Item # 010 Are emergency responses reported lAW the automated Fire Incident Reporting System?No - Raytheon does not use FIRS or any other type of automated reporting system. (action item to establishprocedures)Ref: AFI 32-2001, 3.1.7 & Atch 4 and 6ATeH 1
Page 1 and 2: RECORD REPRODUCTION COVER SHEETThe
Page 3 and 4: TRIP REPORT1. PERSONS MAKING THIS T
Page 5 and 6: ATTACHMENTS:I. Normal Maintenance R
Page 7 and 8: d. Building 811 A walk-through of t
Page 9 and 10: ii. Exterior wall is damaged and bi
Page 11 and 12: Photo 3Building 833 Damaged WallPho
Page 13 and 14: 4. FACILITY REVIEW OBSERVATIONSThe
Page 15 and 16: 4.4.2. Building 80 I, room G 1315.
Page 17 and 18: Air Force Plant 44 Facilities Revie
Page 19 and 20: 3.17 Finding 04-17. Bldg 830. Cinci
Page 21 and 22: The audit followed an audit protoco
Page 23 and 24: AFP 44 ANNUAL FACILITIES REVIEW8 -
Page 25 and 26: local standards and procedures and
Page 27 and 28: FOR OFFICIAL USE ONLYDistribution a
Page 37 and 38: •FOR OFFICIAL USE ONLYDistributio
Page 45: FOR OFFICIAL USE ONLYDistribution a
Page 97 and 98:
FOR OFFICIAL USE ONLYDistribution a
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 106 and 107:
FOR OFFICIAL USE ONLYTRIP REPORT1.
Page 108 and 109:
FOR OFFICIAL USE ONLY8. IMPACT ON A
Page 110 and 111:
FOR OFFICIAL USE ONLYc. Building 81
Page 112 and 113:
FOR OFFICIAL USE ONLYbb. Building 8
Page 114 and 115:
FOR OFFICIAL USE ONLYThe review fol
Page 116 and 117:
FOR OFFICIAL USE ONLY3.0. Structura
Page 118 and 119:
-_._-----~-,FOR F Ie N3.1. I I. Acc
Page 120 and 121:
FOR OFFICIAL USE ONLY4.0 Any questi
Page 122 and 123:
For Official Use Onlysprinkler cove
Page 124 and 125:
,TRIP REPORTl. PERSONS MAKING THIS
Page 126:
g. Equipment Issues1) The Raytheon
show all

Plant 44 Audit Reports - Wright-Patterson Air Force Base

Create successful ePaper yourself

Delete template?

Save as template?