Tender No.: 465S/2011/12 - City of Cape Town

More documents

Recommendations

Info

Tender No.: 465S/2011/12 3.10.3.14 After the inspection of the spray paint is finished, the installation of rope lights and fairy lights can be commenced. 3.10.3.15 The old rope lights and fairy lights need to be tested and inspected to see if it can be reused. If rope lights or fairy lights are damaged, they need to be replaced with new ones. 3.10.3.16 Rope lights and fairy lights must be installed on the frames according to design. 3.10.3.17 Make sure that end caps are placed on the ends of the rope lights. These end caps need to be glued using PVC glue. 3.10.3.18 Where rope lights are jointed, splice connectors must be made use of. These joints need to be covered with a heat shrink tube. 3.10.3.19 Power leads and leads of the controller must be installed and insulated. 3.10.3.20 Wires must be connected to each other using transparent wire connectors. 3.10.3.21 Circuitry of the rope lights and fairy lights must be done according to the design. 3.10.3.22 Where light needs darkening out, black heat shrinks and insulation tape must be used. 3.10.3.23 All rope lights, fairy lights and wiring will be fixed to the set-piece frames by means of cable ties. No loose hanging wires will be allowed. 3.10.3.24 The controller/flasher unit and dinky connectors for connecting the electrical power supply cable to the set-pieces will be placed in an outdoor utility box, which will be placed on the one bottom corner of the set-pieces. 3.10.3.25 Once the rope lights and fairy lights have been fitted and is ready for installation, the setpieces must be tested. The City of Cape Town Electricity Services must be present while testing the set-pieces. 3.10.3.26 Any defects or concerns raised by the City of Cape Town Electricity Services must be rectified before those set-pieces may be installed. 3.10.4 SET-PIECE INSTALLATION SPECIFICATION (Catenary Mounted) 3.10.4.1 For crossings 1 and 3 in Adderley Str the design changes every year. For the other crossings, the old set-pieces are used, but placed in other locations as the previous year. 3.10.4.2 Make sure that the site is safe before commencement of installation works. 3.10.4.3 Place out cones and the relative signage. 3.10.4.4 Set-pieces must be installed at the catenary crossings over the road. 3.10.4.5 Set-pieces must be placed directly next to each other. 3.10.4.6 In the case where a sequence or a specific set of set-pieces need to be installed, that installation order must be followed according to the designer’s specification. 3.10.4.7 Remove the nuts from the set-piece brackets (line tap). 3.10.4.8 Set-pieces must be placed so that the catenary wire goes in the bracket (line tap). 3.10.4.9 Ensure that the catenary wire is placed in all nine (9) of the brackets (line taps). 3.10.4.10 Set-pieces must be installed so that the 2.1m side of the set-piece are in a vertical position. 3.10.4.11 Replace the nuts of the brackets, ensuring that the catenary wire is in tacked inside the bracket. 3.10.4.12 All wiring of set-pieces must be finished and it must be ensured that the City of Cape Town Electricity Services can do the termination of the set-piece at the dinky connectors, to the existing electrical supply network. 46
Tender No.: 465S/2011/12 3.10.4.13 Ensure that there are no loose hanging wires. All wires need to be made neat by means of cable ties. 3.10.4.14 After installation, the City of Cape Town Electricity Services must be informed and an inspection must be done. 3.10.4.15 In the case where the installation is not as required, or if there is any defects with respect to the installation, design or sequence of the set-pieces, the Contractor need to fix that defect with no additional cost or claim. 3.10.5 TYPICAL EXAMPLES OF SET-PIECES Set-pieces installed on catenary wire. Set-piece size is 2 x 2.1m. Adderley Str 47
Page 1 and 2: Tender No.: 465S/2011/12 TENDER DOC
Page 3 and 4: Tender No.: 465S/2011/12 Name of Co
Page 5 and 6: Tender No.: 465S/2011/12 (3) CONTRA
Page 7 and 8: Tender No.: 465S/2011/12 PART 2 (TO
Page 9 and 10: Tender No.: 465S/2011/12 ITEM NO. 1
Page 11 and 12: Tender No.: 465S/2011/12 ITEM NO. 5
Page 13 and 14: Tender No.: 465S/2011/12 ITEM NO. D
Page 15 and 16: Tender No.: 465S/2011/12 ITEM NO. D
Page 17 and 18: Tender No.: 465S/2011/12 1. SCOPE O
Page 19 and 20: Tender No.: 465S/2011/12 3.6.2.15 A
Page 21 and 22: Tender No.: 465S/2011/12 3.6.4 TYPI
Page 23 and 24: Tender No.: 465S/2011/12 Set-piece
Page 25 and 26: Tender No.: 465S/2011/12 � Hout B
Page 27 and 28: Tender No.: 465S/2011/12 � Manenb
Page 29 and 30: Tender No.: 465S/2011/12 � Bothas
Page 31 and 32: Tender No.: 465S/2011/12 � Aeroso
Page 35 and 36: Tender No.: 465S/2011/12 3.8 MOTIFS
Page 37 and 38: Tender No.: 465S/2011/12 3.8.2.20 W
Page 43 and 44: Tender No.: 465S/2011/12 3.10.1.4 G
Page 45: Tender No.: 465S/2011/12 3.10.2.32
Page 49 and 50: Tender No.: 465S/2011/12 Difficult
Page 51 and 52: Tender No.: 465S/2011/12 3.12 POLE
Page 53 and 54: Tender No.: 465S/2011/12 5.4 The Co
Page 55 and 56: Tender No.: 465S/2011/12 13.5 Quali
Page 57 and 58: Tender No.: 465S/2011/12 20.6 By do
Page 59 and 60: Tender No.: 465S/2011/12 (6) CONDIT
Page 61 and 62: Tender No.: 465S/2011/12 6.16 COIDA
Page 63 and 64: Tender No.: 465S/2011/12 7.1 Invali
Page 65 and 66: Tender No.: 465S/2011/12 7.5 Functi
Page 67 and 68: Tender No.: 465S/2011/12 (8) SPECIA
Page 69 and 70: Tender No.: 465S/2011/12 8.8 Settle
Page 71 and 72: Tender No.: 465S/2011/12 TABLE OF C
Page 73 and 74: Tender No.: 465S/2011/12 2.1 These
Page 75 and 76: Tender No.: 465S/2011/12 11. Insura
Page 77 and 78: Tender No.: 465S/2011/12 22. Penalt
Page 79 and 80: Tender No.: 465S/2011/12 31. Notice
Page 81 and 82: Tender No.: 465S/2011/12 Schedule 2
Page 83 and 84: Tender No.: 465S/2011/12 1 Definiti
Page 85 and 86: Tender No.: 465S/2011/12 1) With re
Page 87 and 88: Tender No.: 465S/2011/12 Section 6:
Page 89 and 90: Tender No.: 465S/2011/12 Schedule 7
Page 91 and 92: Tender No.: 465S/2011/12 GUARANTOR
Page 93 and 94: Tender No.: 465S/2011/12 Annexure A
Page 95 and 96: Tender No.: 465S/2011/12 PRICE ADJU
Page 97 and 98:
Tender No.: 465S/2011/12 1. Tendere
Page 99 and 100:
Tender No.: 465S/2011/12 The Mandat
Page 101 and 102:
Tender No.: 465S/2011/12 SCHEDULE 1
Page 103 and 104:
Tender No.: 465S/2011/12 Company Na
Page 105 and 106:
Tender No.: 465S/2011/12 ANNEXURE C
Page 107:
Tender No.: 465S/2011/12 107
show all

Tender No.: 465S/2011/12 - City of Cape Town

Create successful ePaper yourself

Delete template?

Save as template?