Operation Manual for - Mrclab.com

More documents

Recommendations

Info

Ultrasonic milk analyzerIMPORTANTTHE MAIN REASON FOR MALFUNCTIONING OF THEDEVICE IS THE BAD CLEANING OF THE SYSTEM AFTERMAKING ANALYSIS.In case of malfunction due to the bad cleaning of theanalyser your guarantee is not valid anymore and anyrepair has to be paid.4.3. Peristaltic pump serviceFig.7 Peristaltic pumpOperation manual 22/98
Ultrasonic milk analyzer5. POSSIBLE MALFUNCTIONS AND ERROR MESSAGES,TROUBLESHOOTINGIn the table below are described the possible malfunctions during the milkanalyzer’s exploitation and ways for their repair/remedy. If the problempersists after all recommended measures are taken, please, connect thenearest service center for help. Do not forget to tell the analyser’s identity.To receive the analyzer’s identity, refer to point 3.2.1.3.ErrormessageMAoverheatedAccompaniedby acontinuoussound signalEmptyCameraPossibleproblem/causeOverheatedmilkanalyzerInsufficientquantity ofthe milksamplesucked inthe systemor air in thesampleRepair/remedyImmediately switch off the analyzer.Pay attention the analyzer to be situatedaway from direct sunlight or heating devices.Wait 5-10 minutes the device to cool down orto be normalized the ambient temperatureand switch it on again.The analyzer is ready to measure the nextsample. In order to avoid the futureappearance of the same error message,please, check the following:- The sample is prepared according theinstructions and there aren’t air bubblesin it.- There is a real suction of the sampleafter starting measurement, i.e. it isobvious that the level of the milk samplein the sample holder decreases. In othercase – there is damage in the suctionsystem.- Avoid the end of the suction pipe to beabove the surface of the liquid (notdipped enough).- Avoid curdling of the milk sample. Cleanimmediately if there is a sample curdledin the system.- In mode Measurement, after starting themeasurement, remove the sampleholder and see if there is no milk pouredOperation manual 23/98
Page 2 and 3: Ultrasonic milk analyzerSwitching A
Page 4 and 5: Ultrasonic milk analyzerPARTS AND A
Page 6 and 7: Ultrasonic milk analyzer1. FUNCTION
Page 8 and 9: Ultrasonic milk analyzer2.2. Measur
Page 11 and 12: Ultrasonic milk analyzerfig. 2 Back
Page 13 and 14: Ultrasonic milk analyzerFig. 4Perip
Page 15 and 16: Ultrasonic milk analyzer3. QUALIFIC
Page 17 and 18: Ultrasonic milk analyzerThe analyze
Page 19 and 20: Ultrasonic milk analyzer4. CLEANING
Page 21: Ultrasonic milk analyzerFill in the
Page 25 and 26: Ultrasonic milk analyzer6. MAKING C
Page 27 and 28: Ultrasonic milk analyzer6.3.2. Prep
Page 29 and 30: Ultrasonic milk analyzerMilkanalyze
Page 31 and 32: Ultrasonic milk analyzerCalibration
Page 33 and 34: Ultrasonic milk analyzerCal 1 Samp
Page 35 and 36: Ultrasonic milk analyzer7. STARTING
Page 37 and 38: Ultrasonic milk analyzer7.2.3. Sett
Page 39 and 40: Ultrasonic milk analyzerAfter choos
Page 41 and 42: Ultrasonic milk analyzerLarge Resul
Page 43 and 44: Ultrasonic milk analyzerStart diffe
Page 45 and 46: Ultrasonic milk analyzerFan TempOff
Page 47 and 48: Ultrasonic milk analyzer8. ADDITION
Page 50 and 51: Ultrasonic milk analyzerAPPENDICESA
Page 52 and 53: Ultrasonic milk analyzer• Glasses
Page 54 and 55: Ultrasonic milk analyzer3.4. Making
Page 56 and 57: Ultrasonic milk analyzerstirred and
Page 58 and 59: Ultrasonic milk analyzer5.3. Basic
Page 60 and 61: Ultrasonic milk analyzertransparent
Page 62 and 63: Ultrasonic milk analyzerAPPENDIX 3
Page 64 and 65: Ultrasonic milk analyzerWhen examin
Page 66 and 67: Ultrasonic milk analyzerExemplary r
Page 68 and 69: Ultrasonic milk analyzer1.8-2% FAT;
Page 70 and 71: Ultrasonic milk analyzerI Ist sampl
Page 72 and 73:
Ultrasonic milk analyzerAPPENDIX 5:
Page 74 and 75:
Ultrasonic milk analyzerThis is an
Page 76 and 77:
Ultrasonic milk analyzerconfidence
Page 78 and 79:
Ultrasonic milk analyzerAPPENDIX 7
Page 80 and 81:
Ultrasonic milk analyzerjunction ca
Page 82 and 83:
Ultrasonic milk analyzerFor Sensore
Page 84 and 85:
Ultrasonic milk analyzer7. pH Calib
Page 86 and 87:
Ultrasonic milk analyzerWhere XXX i
Page 88 and 89:
Ultrasonic milk analyzermS/cm (18°
Page 90 and 91:
Ultrasonic milk analyzerCond Measur
Page 92 and 93:
Ultrasonic milk analyzerContents:1.
Page 94 and 95:
Ultrasonic milk analyzer2.5. MAKING
Page 96 and 97:
Ultrasonic milk analyzer2.8. ELECTR
Page 98:
Ultrasonic milk analyzerGUARANTEE C
show all

Operation Manual for - Mrclab.com

Create successful ePaper yourself

Delete template?

Save as template?