Traction Rolling Stock - Indian Railways Institute of Electrical ...

More documents

Recommendations

Info

PREFACE The book on "Traction Rolling Stock - Maintenance" was brought out by Institution of Railway Electrical Engineers (IREE) long back. Since, lot of changes have taken place in the maintenance practices in the field of Traction Rolling Stock, it has become necessary to incorporate the changes in this volume. Few additions and modifications in the field of Traction Rolling Stock maintenance are included in this book. For bringing out this book Shri Suryawanshi M.A., Raj Bhasha Supdtt. And Shri K.V.Gaikwad, Section Engineer(Loco) have made substantial efforts, under the guidance of Shri A.T.Dharmik, Professor (Computer). I am delighted to note that lot of efforts have been undertaken in bringing out this book of "Traction Rolling Stock Maintenance" in the present form. I am sure that this book will serve the needs of Electrical Engineers working in the field of Electrical Traction Rolling Stock. Nasik Road A.K.RAWAL 21 st May, 2010 DIRECTOR
MAINTENANCE CONTENTS Chapter No. Subject Pg. No. 01. A.C. Loco Equipments 01-15 02. Locomotive Bogies 16-23 03. Power Transmission & Drives 24-30 04. Wheels 31-32 05. Power Control & Auxiliary Circuit. 33-72 06. Air Compressor 73-80 07. Brake System of Electric Locomotive & EMU 81-103 08. Maintenance and Overhaul Schedules of Locomotives 104-124 09. Safety & Fire Prevention Precautions 125-128 10. AC EMU Description of Electrical Circuits 129-141
Page 4 and 5: A.C. LOCO EQUIPMENTS 1.1: ROOF EQUI
Page 6 and 7: Fig.1.1.3
Page 8 and 9: Leg I A I = 704 cm 2 (Regulating tr
Page 10 and 11: Voltage Primary output : Primary ma
Page 12 and 13: y the main shaft through gear arran
Page 14 and 15: Base load … 500 ohms,300W (12nos.
Page 16 and 17: 1.4.6 Over-voltage Over -voltage in
Page 18 and 19: 2.3 BOGIE COMPONENTS Bogie of a loc
Page 20 and 21: Fig. 2.5. Primary and secondary sus
Page 23: 2.8 BOGIE OF WAG/7 This is a 3 axle
Page 26 and 27: Fig. 1. Single Reduction Gear Drive
Page 31 and 32: FIG.3.6 ROTOR HOLLOW SHAFT DRIVE
Page 34 and 35: 5. POWER CONTROL AND AUXILIARY CIRC
Page 36 and 37: Permanent field weakening resistanc
Page 38 and 39: 5.4.1 Arno converter (CVAR) The sin
Page 40 and 41: pantographs 1 and 2 are lowered. Po
Page 42 and 43: the tap changer comes to a standsti
Page 44 and 45: d) The tap changer GR must be at po
Page 46 and 47: 5.7.3.1 Control of transformer tap
Page 48 and 49: VE2. The limit contacts of 61-62 fo
Page 50 and 51: With multiple unit operation the ma
Page 52 and 53:
elay Q48. If the wheels on one bogi
Page 54 and 55:
5.9.1.4 Lamp LSGR (Green) Tap chang
Page 56 and 57:
cabs are controlled by means of the
Page 73 and 74:
6. AIR COMPRESSOR 6.0 INTRODUCTION
Page 75 and 76:
6.3 COMPRESSOR DETAILS Model : TRC
Page 77 and 78:
1) Type & Make : 1) Northey Type 25
Page 79 and 80:
one shaft to the other, and maintai
Page 81 and 82:
7. BRAKE SYSTEM OF ELECTRIC LOCOMOT
Page 83 and 84:
y the driver’s vacuum brake valve
Page 87 and 88:
7.2 DUAL BRAKE SYSTEM ON ELECTRIC L
Page 89 and 90:
is run to maintain vacuum in the sy
Page 91 and 92:
1. MR equalising pipe 2. BC equalis
Page 97 and 98:
7.2.11 Gauges There are five gauges
Page 99 and 100:
akes. e) When Driver makes an emerg
Page 101 and 102:
train. Failure of the orange lamps
Page 104 and 105:
8. MAINTENANCE, AND OVERHAUL SCHEDU
Page 106 and 107:
e made to increase the interval bet
Page 108 and 109:
8.5.2.6 Battery: Check and record b
Page 110 and 111:
cab 1 a) Raising of pantograph. b)
Page 112 and 113:
d) Check containers of batteries fo
Page 114 and 115:
Section E4 Carry out following: a)
Page 116 and 117:
f) Inspect all resistance, includin
Page 118 and 119:
) Check capacitor of headlight stab
Page 120 and 121:
8.11.4.12 Speedometers- Calibration
Page 122 and 123:
8.15.3 One copy of the certificate
Page 124 and 125:
to eliminate the possibility of fir
Page 126 and 127:
invariably be a member of the inqui
Page 128 and 129:
Two capacitors of 0.05 microfarads
Page 130 and 131:
Notch 18 T3 and T8 closed, connecti
Page 132 and 133:
These machines are capacitor start
Page 134:
The main lighting circuits are fed
show all

Traction Rolling Stock - Indian Railways Institute of Electrical ...

Create successful ePaper yourself

Delete template?

Save as template?