Comprehesive Boiler Manual Jan 2019

More documents

Info

iv. Water Hammer: Valve Induced P a g e 132
Cavitation: Sudden implosion of low pressure steam bubbles back to water causes miniature shock waves, damaging metal surface. Propeller Cavitation Flashing: when water drops in pressure by passing through a restrictive orifice, it boils. Damage from flashing is smooth. Valve Cavitation: sounds like gravel moving through pipe Cavitation is when the bubbles violently implode back to liquid. Damage from cavitation is rough P a g e 133
Page 1 and 2:
www.b-ct.net BOILERS Comprehensive
Page 3 and 4:
iii. Air Compressor ...............
Page 5 and 6:
ii. Composition ...................
Page 7 and 8:
. Fuel Line Limit Controllers .....
Page 9 and 10:
2) Fire Tube i. Multi-Pass Multi-Pa
Page 11 and 12:
ICB: InterCooled Back boiler P a g
Page 13 and 14:
iv. Stays Stays are often installed
Page 15 and 16:
Flex Tube Bryan ® Flex Tube Closed
Page 17 and 18:
Circular Coil Circular Coil Boiler
Page 19 and 20:
O, D, A Type “O” Type “A” T
Page 21 and 22:
iii. Downcomer spelling! Mud drum D
Page 23 and 24:
v. Steam Scrubber: Baffles/Dry Pipe
Page 25 and 26:
4) Water Cum Smoke Tube (Water and
Page 27 and 28:
6) Closed Loop Boilers (Hot Water C
Page 29 and 30:
Water Expansion Control Water Expan
Page 31 and 32:
PEX tubing Closed Loop Continued PE
Page 33 and 34:
Measurement Refractometer: Chemical
Page 35 and 36:
Condensing Boiler Condensing Boiler
Page 37 and 38:
7) Co-Generation a. Electricity Tes
Page 39 and 40:
c. Steam Turbine Rotors (rotating)
Page 41 and 42:
e. Non-Condensing Turbines Non-Cond
Page 43 and 44:
A) Boiler Start Up, Operation and S
Page 45 and 46:
i. Heat Pump Around 37°F many heat
Page 47 and 48:
iii. Air Compressor Atomizing and C
Page 49 and 50:
Temperature @ 0 psig = 1 Atm = sea
Page 51 and 52:
Saturation Curve Saturation Curve S
Page 53 and 54:
Extreme Precipitation A combination
Page 55 and 56:
Water to Ice Expansion to Ice Expan
Page 57 and 58:
i. Sublimation/Deposition Home Unit
Page 59 and 60:
iii. Boiling/Condensing Vapor Cone:
Page 61 and 62:
5) Steam Table Gauge Pressure Inche
Page 63 and 64:
˚F → Water Rankine Cycle: Steam
Page 65 and 66:
Digital psi sensor Aux. operations
Page 67 and 68:
Water level indicator using Differe
Page 69 and 70:
(Hydraulic Fracturing) Downward tre
Page 71 and 72:
iii. Solid Fuels / BioMass Wood Sol
Page 73 and 74:
Solid Fuels: Garbage Municipal Wast
Page 75 and 76:
iv. Electricity Very small wall mou
Page 77 and 78:
i. Combustion Air Atmospheric Draft
Page 79 and 80:
ii. Spark Ignition Transformer Spar
Page 81 and 82: Premix Flame Diffusion Flame: no Ox
Page 83 and 84: Swirler and Nozzle The diffuser, or
Page 85 and 86: Burners Premix Burner Premix Mesh B
Page 87 and 88: ii. Oil Oil Burners Light Oil Steam
Page 89 and 90: Dual iii. Duel Fuel: NG & and Oil L
Page 91 and 92: Grate Bed Bed Step Grate Chain Grat
Page 93 and 94: Circulating CFB = Circulating Fluid
Page 95 and 96: Sonic Blast Soot Blower Uses compre
Page 97 and 98: i. Thermodynamic Thermodisc When co
Page 99 and 100: Mechanical continued Inverted Bucke
Page 101 and 102: Mechanical continued Float & Thermo
Page 103 and 104: Thermostatic continued Spring Expan
Page 105 and 106: v. Automatic Pump Trap (APT) = Cond
Page 107 and 108: PRV Let Down Station P a g e 107
Page 109 and 110: Desuperheater 2) Keeping steam temp
Page 111 and 112: High Capacity Instantaneous Steam F
Page 113 and 114: Motorized solenoid incoming steam c
Page 115 and 116: ii. Plate and Frame Plate and Frame
Page 117 and 118: iv. Steam Radiators Adjustable Ther
Page 119 and 120: vi. Autoclaves High temperature and
Page 121 and 122: 4) Pumps i. Reciprocating Reciproca
Page 123 and 124: iii. Centrifugal Series vs Parallel
Page 125 and 126: v. Motor Vibration Monitoring All r
Page 127 and 128: 5) Valves i. Types Ball Gate Butter
Page 129 and 130: iii. Actuators Actuators remotely o
Page 131: A Solenoid: Electricity creates a t
Page 135 and 136: ii. Condensate Vacuum Pump During m
Page 137 and 138: Variable Frequency Drive ii. VFD: A
Page 139 and 140: D) Piping Systems 1) Pipes i. Manuf
Page 141 and 142: ii. Composition Carbon Steel Black
Page 143 and 144: iv. Poiseuille’s Law Poiseuille
Page 145 and 146: Inline Steam Separators iii. Inline
Page 147 and 148: E) Water Quality 1) Water Chemistry
Page 149 and 150: pH Probe Acids have more positive i
Page 151 and 152: Conductivity vs. TDS Total dissolve
Page 153 and 154: 2) Make Up Water Up Water The term
Page 155 and 156: Water Softener Sodium (Na+) changes
Page 157 and 158: KCl vs. NaCl The potassium (K) atom
Page 159 and 160: iii. Filtration Suspended Solids Fi
Page 161 and 162: Slime Buildup on RO Membrane Foulin
Page 163 and 164: 3) Feed Water: DA Tank DeAerator i.
Page 165 and 166: Page 3 Overflow Valve controller, H
Page 167 and 168: 4) Boiler Water i. Caustic Embrittl
Page 169 and 170: iii. Residual Oxygen Pitting Contro
Page 171 and 172: v. Sludge and Settlement Control: B
Page 173 and 174: vi. Water Column Blowdown Normal co
Page 175 and 176: Most common amines pH controlling a
Page 177 and 178: LDI - Liquid Droplet Impingement ii
Page 179 and 180: 7) Chemical Feed Pumps Peristaltic
Page 181 and 182: G) System Documentation / Plant Per
Page 183 and 184:
2) Flow Meters i. Differential Pres
Page 185 and 186:
ii. Ultrasonic 2. Ultrasonic Dopple
Page 187 and 188:
3) Energy Measurement Energy: measu
Page 189 and 190:
Acid Rain Acid Rain Nitric Acid Sul
Page 191 and 192:
SO₂ Control Sulfur Dioxide Contro
Page 193 and 194:
Stoichiometric flame → Flame exti
Page 195 and 196:
Premix Low NO x Burners By mixing t
Page 197 and 198:
Flue Gas Recirculation, recycles a
Page 199 and 200:
SCR Ammonia Free 3 Way Catalytic Co
Page 201 and 202:
SCR Ammonia Injection Grid = AIG Th
Page 203 and 204:
3 Way Dual Bed 3 Way Single Bed Pla
Page 205 and 206:
(Particulate Matter) Control Electr
Page 207 and 208:
, Bag House (Particulate Matter) Co
Page 209 and 210:
New Technology New Technology Emiss
Page 211 and 212:
CO₂ (Green House Gasses) Greenhou
Page 213 and 214:
2) Generator System Components Turb
Page 215 and 216:
I) Routine Equipment Maintenance 1)
Page 217 and 218:
3) Small Boiler Layup/Seasonal Down
Page 219 and 220:
2) Refractory Fire box lining (bric
Page 221 and 222:
K) Safety Systems 1) Emergency Stop
Page 223 and 224:
5) Hartford Loop The Hartford Loop
Page 225 and 226:
. Fuel Line Limit Controllers Any o
Page 227 and 228:
Using positive pressure air flow fr
Page 229 and 230:
Boiler Gas Train PRVs Strainers Iso
Page 231 and 232:
Pilot Line: NG pilot line extractio
Page 233 and 234:
Atomizing Air/Steam for Fuel Oil At
Page 235 and 236:
K = Potassium, Ag = Silver, Cs = Ce
Page 237 and 238:
Flame Rod Flame Rod = Ionization Se
Page 239 and 240:
Magnetic Float = gauge glass tubula
Page 241 and 242:
L) Facilitating and monitoring rece
Page 243 and 244:
M) Efficiency 1) LEED Program In th
Page 245 and 246:
Hole Size 20 psi 25 psi 100 psi 200
Page 247 and 248:
The difference in Oxygen concentrat
Page 249 and 250:
Increase Effects (symptoms) 3) Effe
Page 251 and 252:
Combustion Air Pre-Heaters 5) Combu
Page 253 and 254:
6) Blowdown Heat Recovery i. Surfac
Page 255 and 256:
Usable low psi steam 7) Flash Steam
Page 257 and 258:
3) Periodic Table P a g e 257
Page 259 and 260:
5) Boiler Device Nomenclature AFOSV
Page 261 and 262:
Bypass Feeder .....................
Page 263 and 264:
Hydrogen ..........................
Page 265 and 266:
Reverse Osmosis ...................
show all

Comprehesive Boiler Manual Jan 2019

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?