2000 Hook-up Book - Spirax Sarco

More documents

Recommendations

Info

HOOK-UP DIAGRAMS 96 Figure II-26 Controlling and Draining Preheat and Reheat Coils in Vented Condensate System with Freeze Resistant Piping for Makeup Air Liquid Expansion Steam Trap Thermostati c Outdoor Air Vacuum Breaker Drain to Safe Place Spira-tec Loss Detector Each coil must be individually drained to provide for proper and accurate control. Strainers are not fitted in front of the traps in case they become partially blocked. Freeze resistant coils must have vacuum breaker, traps sized for full load with 1/2 psi differential and unobstructed piping to an atmospheric return system. Pilot Operated Temperature Control Valve Float & Thermostatic Steam Trap Thermo- Dynamic Steam Trap with Integral Strainer Temperature Control Sensor Vented Receiver Steam Supply Vacuum Breaker Float & Thermostatic Steam Trap Pressure Powered Pump Pilot Operated Temperature Control Valve Drain to Safe Place Motive Supply Thermostati c Heated Air Spira-tec Loss Detector Strainer Strainer Spira-tec Loss Detector Thermo- Dynamic Steam Trap with Integral Strainer Temperature Control Sensor Float & Thermostatic Steam Trap Liquid Expansion Steam Trap Condensate Return Steam Supply
Steam Supply Steam Supply Figure II-27 Freeze Proof Piping of Large Vertical Air Heater Coil to Atmospheric Condensate Return System * To preclude accidental closing, these valves should be chain locked in open position, or they may be omitted. Pilot Operated Back Pressure Control Valve Vent Strainer Spira-tec Loss Detector Thermo- Dynamic Steam Trap with Integral Strainer Figure II-28 High Pressure Steam Coils Trapped for Flash Recovery to LP Steam System Pilot Operated Temperature Control Valve Pilot Operated Pressure Control Valve Moisture Separator Drip Pan Elbow Safety Valve Flash Recovery Vessel Vacuum Breaker Float & Thermostatic Steam Trap Temperature Sensor Strainer Spira-tec Loss Detector * Vertical Air Coil Low Pressure Steam Float & Thermostatic Steam Trap * Packaged Pressure Powered Pump Unit Air Heating Coils Check Valve Vacuum Breaker Float & Thermostatic Steam Trap Pressure Powered Pump Vent Thermostati c Condensate Return Pitch Down To Condensate Return Motive Supply Drip Pan Elbow Strainer Strainer Safety Valve Float & Thermostatic Steam Trap Condensate Return Thermo- Dynamic Steam Trap Air Vent Drain to Safe Place Strainer Float & Thermostatic Steam Trap 97 HOOK-UP DIAGRAMS
Page 1 and 2:
DESIGN OF FLUID SYSTEMS HOOK-UPS
Page 3 and 4:
Spirax Sarco Spirax Sarco is the re
Page 5:
Section 1: System Design Informatio
Page 8 and 9:
SYSTEM DESIGN 2 The Working Pressur
Page 10 and 11:
SYSTEM DESIGN 4 Sizing Steam Lines
Page 12 and 13:
SYSTEM DESIGN 6 Sizing Superheated
Page 14 and 15:
SYSTEM DESIGN 8 Draining Steam Main
Page 16 and 17:
SYSTEM DESIGN 10 Draining Steam Mai
Page 18 and 19:
SYSTEM DESIGN 12 Steam Tracing The
Page 20 and 21:
SYSTEM DESIGN 14 Steam Tracing Sizi
Page 22 and 23:
SYSTEM DESIGN 16 Steam Tracing Trac
Page 24 and 25:
SYSTEM DESIGN 18 Steam Tracing A si
Page 26 and 27:
SYSTEM DESIGN 20 Pressure Reducing
Page 28 and 29:
SYSTEM DESIGN 22 Parallel and Serie
Page 30 and 31:
SYSTEM DESIGN 24 How to Size Temper
Page 32 and 33:
SYSTEM DESIGN 26 Temperature Contro
Page 34 and 35:
Page 36 and 37:
Page 38 and 39:
SYSTEM DESIGN 32 Makeup Air Heating
Page 40 and 41:
SYSTEM DESIGN 34 Draining Temperatu
Page 42 and 43:
SYSTEM DESIGN 36 Draining Temperatu
Page 44 and 45:
SYSTEM DESIGN 38 Steam Trap Selecti
Page 46 and 47:
SYSTEM DESIGN 40 Steam Trap Selecti
Page 48 and 49:
SYSTEM DESIGN 42 Flash Steam Flash
Page 50 and 51:
SYSTEM DESIGN 44 Flash Steam Flash
Page 52 and 53: SYSTEM DESIGN 46 Condensate Recover
Page 54 and 55: SYSTEM DESIGN 48 Condensate Pumping
Page 56 and 57: SYSTEM DESIGN 50 Clean Steam Printi
Page 58 and 59: SYSTEM DESIGN 52 Clean Steam Overal
Page 60 and 61: SYSTEM DESIGN 54 Clean Steam Figure
Page 62 and 63: SYSTEM DESIGN 56 Testing Steam Trap
Page 64 and 65: SYSTEM DESIGN 58 Spira-tec Trap Lea
Page 66 and 67: SYSTEM DESIGN 60 Steam Meters Densi
Page 68 and 69: SYSTEM DESIGN 62 Compressed Air Sys
Page 70 and 71: SYSTEM DESIGN 64 Compressed Air Sys
Page 72 and 73: SYSTEM DESIGN 66 Compressed Air Lin
Page 74 and 75: SYSTEM DESIGN 68 Typical Steam Cons
Page 76 and 77: SYSTEM DESIGN 70 Specific Heats and
Page 78 and 79: SYSTEM DESIGN 72 Specific Heats and
Page 80 and 81: SYSTEM DESIGN 74 Conversions To Con
Page 82 and 83: SYSTEM DESIGN 76 Flow of Water thro
Page 84 and 85: SYSTEM DESIGN 78 Moisture Content o
Page 86 and 87: SYSTEM DESIGN 80 ANSI Flange Standa
Page 89 and 90: HOOK-UP APPLICATION DIAGRAMS Sectio
Page 91 and 92: Figure II-3 Draining and Air Ventin
Page 93 and 94: Figure II-8 Draining Steam Main whe
Page 95 and 96: Figure II-12 Typical Pressure Reduc
Page 97 and 98: Figure II-16 Installation of Pressu
Page 99 and 100: Figure II-20 Typical Pneumatic Sing
Page 101: Condensate Return Steam Supply Stea
Page 105 and 106: Figure II-31 Temperature Control of
Page 107 and 108: Elevated or Pressurized Return P 2
Page 109 and 110: Figure II-39 Controlling Temperatur
Page 115 and 116: Figure II-50 Trapping Small Utensil
Page 117 and 118: Figure II-55 Draining and Air Venti
Page 119 and 120: Figure II-59 Air Venting and Conden
Page 121 and 122: Evaporator Pressure Figure II-64 Dr
Page 123 and 124: Figure II-68 Installation of Pump/T
Page 125 and 126: Figure II-73 Draining Small Condens
Page 127 and 128: Figure II-78 Flash Steam Recovery a
Page 129 and 130: Figure II-80 Heating Water using Re
Page 131 and 132: Figure II-82 Recovery of Flash Stea
Page 133 and 134: Figure II-84 Flash Steam Condensing
Page 135 and 136: Figure II-87 Tank Sterilization Cle
Page 137 and 138: Steam Supply Figure II-93 Typical S
Page 139 and 140: Figure II-97 Hand Operated Rotary F
Page 141 and 142: Figure II-102 Freeze Proof Safety S
Page 143 and 144: Figure II-106 Continuous Boiler Blo
Page 145 and 146: Figure II-111 Controlling Temperatu
Page 147 and 148: 141
Page 149 and 150: PRODUCT INFORMATION Section 3
Page 151 and 152: Steam Traps • Balanced Pressure T
Page 153 and 154:
147
Page 155 and 156:
Subject Index Safety...............
Page 157 and 158:
Subject Index Radiation—Baseboard
Page 159 and 160:
Argentina Spirax Sarco S.A. Ruta Pa
show all

2000 Hook-up Book - Spirax Sarco

Create successful ePaper yourself

Delete template?

Save as template?