Flight and Operation Manual Rev 3.0 on 09-04-2013 - Trixy Aviation

More documents

Recommendations

Info

Pre-rotator Check pulley <strong>and</strong> belt for wear As soon as a gentle engagement of the pre rotating mechanismis not possible apply silicon spray to the inside of the belt Driveshaft is straight <strong>and</strong> without play Check the gear box for mounts <strong>and</strong> rotation without play Check clutch lever <strong>and</strong> the wire system for playBowden cable Gas, choke <strong>and</strong> rudder cables move freely <strong>and</strong> a slightly wettedwith oil to prevent freezing<strong>Flight</strong> <strong>and</strong> operation manual G 4-2 <strong>Rev</strong>ision <strong>3.0</strong> – 09.04.2013 30
3.3 Pre-flight check01 Both Magneto switches off02 Master switch off03 Nose wheel tire pressure visual inspection OK04 Bolts of the front steering stick OK05 Bolts of the back steering stick (optional) OK06 Canopy hinges <strong>and</strong> locking system OK07 Wheel / brake right bolts <strong>and</strong> mounts OK08 Tire pressure right visual inspection OK09 Mounts of the main gear strut right OK10 Open engine compartment look for damage check11 Engine cowling <strong>and</strong> hinges right side check12 Engine compartment locks check13 Tank, filler cap <strong>and</strong> hoses right tight14 Oil level check15 Engine hoses <strong>and</strong> wiring right side tight16 sparkplug caps right side tight17 Coolant level check18 Pre-rotator drive OK19 Fuel free from water check20 Fuel level visual inspection noted21 Frame welds in engine compartment OK22 Propeller undamaged / tight / blade position check23 Rudder cable tension OK24 Empennage / rudder / cable connections tight/OK25 Engine cowling <strong>and</strong> hinges left side check26 Engine hoses <strong>and</strong> wiring left side tight27 Sparkplug caps left side tight28 Exhaust system tight30 Engine cowling closed properly OK31 Wheel / brake left bolts <strong>and</strong> mounts OK32 Tire pressure left visual inspection OK33 Mounts of the main gear strut left OK34 Vertical rotor control rods secure with no play OK35 Rotor head moves freely / bolts tight36 Head main bolts are secured check37 Rotor blades clean <strong>and</strong> undamaged check38 Cabin glass clean <strong>and</strong> undamaged OK39 Windshield clean <strong>and</strong> undamaged OK<strong>Flight</strong> <strong>and</strong> operation manual G 4-2 <strong>Rev</strong>ision <strong>3.0</strong> – 09.04.2013 31
Page 2 and 3: Flight and
Page 4 and 5: INDEX1 GENERAL 81.1 Introduction 81
Page 6 and 7: 6.8 Doors, windows and</str
Page 8 and 9: 1 GENERAL1.1 IntroductionThis manua
Page 10 and 11: Warning: This manual is not to be c
Page 12 and 13: 1.5 Side view, top view and
Page 14 and 15: 1.6 Description Gyrocopter with nos
Page 16 and 17: Starter:Generator:Electric (12V 0.6
Page 18 and 19: 1.11 Abbreviations and</str
Page 20 and 21: 1 OPERATING LIMITATIONS2.1 Introduc
Page 22 and 23: 2.3 Engine limitationsRotax 912 ULS
Page 25 and 26: 2.10 FuelTotal tank content: 34 l (
Page 29: All hub bolts are in place No defor
Page 33 and 34: 3.4 Before engine start check Passe
Page 35 and 36: 3.7 Before taxi check Close <strong
Page 37 and 38: 3.10 Take-off Accelerate with full
Page 39 and 40: 3.17 After landing
Page 41 and 42: 3.21.1 Uninstalling the rotor1. The
Page 43 and 44: 5. The second person may now releas
Page 47 and 48: 4.3 Influence of rain & insects on
Page 51 and 52: 5.2 Weighing procedureThe G 4-2 is
Page 53 and 54: 5.4 Empty weight alterationAny chan
Page 55 and 56: 5.5 Determining the center of gravi
Page 59 and 60: 6.3 Steering systemsRudder steering
Page 61 and 62: Hydraulic wheel brakesThe hydraulic
Page 63 and 64: Type PRINCESSThe stand</str
Page 65 and 66: G 4-2 is equipped with two luggage
Page 73 and 74: 6.11 Dynamic- and
Page 75 and 76: 7.2 DescriptionEMSISThe sta
Page 79 and 80: The warning window also displays th
Page 81 and 82:
Nesis II displays warnings, wheneve
Page 83 and 84:
The third main display (the flight
Page 85 and 86:
The fifth main display (the setting
Page 87 and 88:
Flight and
Page 89 and 90:
9.2 TriebwerkansichtenSide viewDire
Page 91 and 92:
9.5 Cooling systemTo check the leve
Page 93 and 94:
Flight and
Page 95 and 96:
Flight and
Page 97 and 98:
11.1.1 Frame, propeller and
Page 99 and 100:
11.4 Maintenance and</stron
Page 101 and 102:
Flight and
Page 103 and 104:
Minimum instrumentation required by
Page 105 and 106:
Flight and
Page 107 and 108:
13.2 Engine failureThe following is
Page 109 and 110:
c) Landing with de
Page 111 and 112:
The transceivers of type Funkwerk A
Page 113 and 114:
Flight and
show all

Flight and Operation Manual Rev 3.0 on 09-04-2013 - Trixy Aviation

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?