Installation Operation and Maintenance Manual

More documents

Recommendations

Info

Troubleshooting (Continued)i-ALERT Condition Monitor troubleshootingSymptom Cause RemedyThere are no green or red flashing LEDs. The battery is dead. Replace the condition monitor.The red LEDs are flashing, but the temperature andvibration are at acceptable levels.The unit is deactivated.The unit is malfunctioning.The baseline is bad.The unit is malfunctioning.Activate the condition monitor.Consult your ITT representativefor a warranty replacement.Check the temperature andvibration levels and reset thecondition monitor.Consult your ITT representativefor a warranty replacement.118 Model 3796 i-FRAME Installation, Operation, and Maintenance Manual
Parts Listings and Cross-SectionalDrawingsParts listTable 24: Construction material and quantityItem Quantity Part name Pump MaterialAll D.I. D.I. With316 SSimpellerAll 316SSAllCD4MCu100 1 Casing 1012 1012 1203 1216 1204101 1 Impeller 1013 1203 1203 1216 1204105 1 Lantern Ring Teflon106 1 set Stuffing Box Packing Non-asbestos braid107 1 Gland—Packed Box 1203 1204108 1 Frame Adapter 1013109C 1*** Outboard Bearing End Cover 1001112A 1 Outboard Bearing Double row angular contact (duplex pair for LTi)113 2 Plug—Grease Relief 2210113B 1 Plug—Oil Fill 2210122 1 Shaft—Without Sleeve 2229 2230122 1 Shaft—With Sleeve 2238126 1 Shaft Sleeve 2229 2230134 1 Bearing Housing 1001136 1 Bearing Locknut Steel168A 1 Radial Bearing Single row ball184 1 Seal Chamber/Stuffing Box Cover 1012 1012 1203 1216 1204193 2 Grease Fitting Steel228 1 Bearing Frame STi 1013, All others - 1001236A 10 Cap Screw—Bearing Clamp Ring 2210239 1 Support, Casing – – 2201* 2201* 2201*241 1 Frame Foot 1001248 1 Oil Thrower 2210250 1 Gland—Mechanical Seal Material varies253B 1 Bearing Clamp Ring 2210319 1 Sight Glass Glass/steel332A 1 Outboard Labyrinth Seal w/O-rings Brass ASTM B505-96333A 1 Inboard Labyrinth Seal w/O-rings Brass ASTM B505-96351 1 Casing Gasket Aramid fiber w/EPDM353 4 Gland Stud 2228355 4 Gland Stud Nut 2228358 1 Plug—Casing Drain 2210 2229 2230358Y 1 *** Plug, Impeller 2229 2230Parts Listings and Cross-Sectional DrawingsAll Alloy 20Model 3796 i-FRAME Installation, Operation, and Maintenance Manual 119
Page 1:
Goulds PumpsInstallation, Operation
Page 4 and 5:
Table of ContentsImpeller-clearance
Page 6 and 7:
Introduction and SafetyIntroduction
Page 8 and 9:
Introduction and Safety (Continued)
Page 10 and 11:
Page 12 and 13:
Page 14 and 15:
Page 16 and 17:
Page 18 and 19:
Page 20 and 21:
Transportation and Storage (Continu
Page 22 and 23:
Product DescriptionProduct Descript
Page 24 and 25:
Product Description (Continued)Cove
Page 26 and 27:
Product Description (Continued)Tabl
Page 28 and 29:
InstallationInstallationPreinstalla
Page 30 and 31:
Installation (Continued)Piping chec
Page 32 and 33:
Installation (Continued)Liquid sour
Page 34 and 35:
Installation (Continued)Example: Di
Page 36 and 37:
Installation (Continued)d) Make sur
Page 38 and 39:
Installation (Continued)76152341. U
Page 40 and 41:
Installation (Continued)Baseplate-l
Page 42 and 43:
Installation (Continued)WhenPeriodi
Page 44 and 45:
Installation (Continued)1. Set the
Page 46 and 47:
Installation (Continued)C-face adap
Page 48 and 49:
Commissioning, Startup, Operation,
Page 50 and 51:
Page 52 and 53:
Page 54 and 55:
Page 56 and 57:
Page 58 and 59:
Page 60 and 61:
Page 62 and 63:
Page 64 and 65:
Page 66 and 67:
MaintenanceMaintenanceMaintenance s
Page 68 and 69:
Maintenance (Continued)Regrease the
Page 70 and 71: Maintenance (Continued)Packed stuff
Page 72 and 73: Maintenance (Continued)1. Is your b
Page 74 and 75: Maintenance (Continued)Clean surfac
Page 76 and 77: Maintenance (Continued)5. Remove th
Page 78 and 79: Maintenance (Continued)3. Remove th
Page 80 and 81: Maintenance (Continued)134236A370D4
Page 82 and 83: Maintenance (Continued)253B168A4961
Page 84 and 85: Maintenance (Continued)2. Loosen th
Page 86 and 87: Maintenance (Continued)Surface insp
Page 88 and 89: Maintenance (Continued)444Figure 24
Page 90 and 91: Maintenance (Continued)Bearing fits
Page 92 and 93: Maintenance (Continued)168361A12238
Page 94 and 95: Maintenance (Continued)372T 113A 40
Page 96 and 97: Maintenance (Continued)a) Coat the
Page 98 and 99: Maintenance (Continued)13411. Prepa
Page 100 and 101: Maintenance (Continued)4. Check the
Page 102 and 103: Maintenance (Continued)333AINPRO la
Page 104 and 105: Maintenance (Continued)Seal the sha
Page 106 and 107: Maintenance (Continued)c) Install t
Page 108 and 109: Maintenance (Continued)126412A101In
Page 110 and 111: Maintenance (Continued).030101For m
Page 112 and 113: Maintenance (Continued)100351418100
Page 114 and 115: Maintenance (Continued)Table 18: Ma
Page 116 and 117: Maintenance (Continued)Table 22: Lu
Page 118 and 119: TroubleshootingTroubleshootingOpera
Page 122 and 123: Parts Listings and Cross-Sectional
Page 132: Other Relevant Documentation or Man
show all

Installation Operation and Maintenance Manual

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?