Operator's Manual - Ditch Witch

More documents

Recommendations

Info

JT5 Operator’s <strong>Manual</strong> Transport - 71 Tow Tow Under normal conditions, drilling unit should not be towed. If unit breaks down and towing is necessary: • Attach chains to indicated tow points facing towing vehicle. • Disengage track hydraulics. • Tow for short distances at less than 1 mph (1.6 km/h). • Use maximum towing force of 1.5 times unit weight. To disengage track hydraulics: 1. Loosen locknut (2). 2. Turn screw (1) on each counterbalance valve clockwise until it stops. IMPORTANT: Be sure to count number of turns. 3. Repeat on other track. To engage track hydraulics: 1. Turn screw (1) on counterbalance valve exactly the same number of turns counterclockwise. 2. Tighten locknut (2). 3. Repeat on other track. CMW
Transport - 72 JT5 Operator’s <strong>Manual</strong> Tow Incorrect procedures could result in death, injury, or property damage. Learn to use equipment correctly. Do not use tiedown points (D-rings) for towing or lifting. Loop chain through tow points on left and right side of unit (shown) and pull straight forward. CMW
Page 1 and 2:
JT5 Operator’s Manual CMW ® Issu
Page 3 and 4:
Overview - 2 Serial Number Location
Page 5 and 6:
Overview - 4 Unit Components JT5 Op
Page 7 and 8:
Overview - 6 JT5 Operator’s Manua
Page 9 and 10:
Foreword - 8 JT5 Operator’s Manua
Page 11 and 12:
Contents - 10 JT520 Operator’s Ma
Page 13 and 14:
Safety - 12 Guidelines JT2720 Mach
Page 15 and 16:
Safety - 14 Safety Alerts JT2720 Ma
Page 17 and 18:
Safety - 16 JT2720 Mach 1/All Terra
Page 19 and 20:
Safety - 18 If an Electric Line is
Page 21 and 22: Safety - 20 If a Fiber Optic Cable
Page 23 and 24: Controls - 22 Set-up Console JT5 Op
Page 25 and 26: Controls - 24 Anchor Console JT5 Op
Page 27 and 28: Controls - 26 Operator’s Station
Page 29 and 30: Controls - 28 JT5 Operator’s Manu
Page 33 and 34: Controls - 32 Engine Compartment JT
Page 35 and 36: Controls - 34 ESID JT5 Operator’s
Page 41 and 42: Controls - 40 Controls JT5 Operator
Page 45 and 46: Operation Overview - 44 Planning JT
Page 47 and 48: Operation Overview - 46 Leaving Job
Page 49 and 50: Prepare - 48 JT5 Operator’s Manua
Page 51 and 52: Prepare - 50 Inspect Site JT5 Opera
Page 53 and 54: Prepare - 52 Classify Jobsite JT5 O
Page 55 and 56: Prepare - 54 JT5 Operator’s Manua
Page 57 and 58: Prepare - 56 Recommended Bend Limit
Page 59 and 60: Prepare - 58 Entry Pitch JT5 Operat
Page 61 and 62: Prepare - 60 Prepare Jobsite JT5 Op
Page 63 and 64: Prepare - 62 Prepare Equipment JT5
Page 65 and 66: Drive - 64 Start Unit JT5 Operator
Page 67 and 68: Drive - 66 JT5 Operator’s Manual
Page 69 and 70: Transport - 68 Lift JT5 Operator’
Page 71: Transport - 70 Unload JT5 Operator
Page 75 and 76: Conduct a Bore - 74 JT5 Operator’
Page 77 and 78: Conduct a Bore - 76 Prime Drilling
Page 79 and 80: Conduct a Bore - 78 Clamp Pipe JT5
Page 81 and 82: Conduct a Bore - 80 Attach Transiti
Page 83 and 84: Conduct a Bore - 82 Add Pipe JT5 Op
Page 87 and 88: Conduct a Bore - 86 Assemble Backre
Page 89 and 90: Conduct a Bore - 88 Remove Pipe JT5
Page 93 and 94: Systems and Equipment - 92 JT5 Oper
Page 95 and 96: Systems and Equipment - 94 Drive An
Page 97 and 98: Systems and Equipment - 96 Assemble
Page 99 and 100: Systems and Equipment - 98 Troubles
Page 101 and 102: Systems and Equipment - 100 JT5 Ope
Page 103 and 104: Systems and Equipment - 102 Drillin
Page 107 and 108: Systems and Equipment - 106 Funnel
Page 111 and 112: Systems and Equipment - 110 Downhol
Page 113 and 114: Systems and Equipment - 112 Backrea
Page 123 and 124:
Complete the Job - 122 Antifreeze D
Page 125 and 126:
Complete the Job - 124 Rinse Equipm
Page 127 and 128:
Complete the Job - 126 JT5 Operator
Page 129 and 130:
Service - 128 Service Precautions J
Page 131 and 132:
Service - 130 Recommended Lubricant
Page 133 and 134:
Service - 132 Startup/10 Hour JT5 O
Page 135 and 136:
Service - 134 JT5 Operator’s Manu
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
Page 145 and 146:
Service - 144 750 Hour JT5 Operator
Page 147 and 148:
Service - 146 2000 Hour JT5 Operato
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Specifications - 152 JT5 Operator
Page 155 and 156:
Specifications - 154 JT5 Operator
Page 157:
Warranty - 156 JT5 Operator’s Man
Page 161:
Service Record - 160 JT5 Operator
show all

Operator's Manual - Ditch Witch

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?