36e Operator's Manual 2013.pdf - Marlow-Hunter, LLC

Fig. 2.1Hunter e36 • Documents and FormsDEALER: _____________________________ ENGINE:_________________________________MAKE:_______________________________ OWNER: ________________________________PORT ENGINE NO: ____________________ STBD. ENGINE NO: _______________________BOATNAME:__________________________REGISTRYRNO:_________________________ ___OPERATION___________INITIALS________OPERATION____________INITIALS_________BEFORE LAUNCHINGBEFORE STARTINGTENGINES1. Hull Side Clean and Gelcoat23. All engine wiring in good order & tight2. Bright work clean and finish24. Throttle control and cable travel3. Decks cleaned and gelcoat25. Clutch control and cable travel4. Interior Finish26. Crankcase oil level at FULL mark5. Upholstery clean and carpet in place27. Reverse gear oil level at FULL mark6. Bilge cleaned.7. Bottom clean and paint28. No fuel leaks in fuel lines, at fittings, at8. Both shafts turn freelyfuel filter, fuel pump9. Engines and Generator intakes installed29. No engine water or oil leaks10. All hull fittings sealed11. All drain plugs tight, (hull, engines, generator, muffler) 30. Oil pressure and exhaust water flow12. Sacrificial Anodes installed1031. Idling speed set at 700-800 RPMand is in proper adjustmentWITH BOATIN WATER13. Hose test for cabin and window leaks14. No water leaks at thru hull fittingwith seacocks15. No water leaks at shaft or rudder16. With all switches off- no spark whenbattery cable touched to post17. All electrical equipment operatingincluding: horn( ); running light( );bilge pump( )18. Toiletoperates19. Water (pressure) system operates20. Galley stove operates21. With fuel tanks full, no fuel leaks atfill pipes, overflow vent, or atany fuel line connections22. With coupling disconnected, engine andshaft alignmentINSPECTION DATE:_______________________DEALERS SIGNATURE: _______________________________________________________OWNERS SIGNATURE:Pre-delivery Service RecordWATER TEST BOAT33. Engine performance34. Instruments are registering properly35. Top RPM wide open throttle for oneminute after warm-up36. Boat performanceFINAL CHECK:37. All accessory equipment operating38. Carpets and drapes installed and clean39. All loose equipment on boatready for new owner.___________________________________________________________COMMENTS:____________________________ _________________________________________________________________________________________________________________________2.10