Operation and Maintenance Manual for

More documents

Recommendations

Info

WARRANTY LC Manual 11/02 Rev. 3 Products or components manufactured by companies other than USFilter or its affiliates (“Non-USFilter Products”) are covered by the Warranty, if any, extended by the Product manufacturer. USFilter hereby assigns to the purchaser any such warranty: however, USF EXPRESSLY DISCLAIMS ANY WARRANTY, WHETHER EXPRESSED OR IMPLIED THAT THE NON-USF PRODUCTS ARE MERCHANTABLE OR FIT FOR A PARTICULAR PURPOSE. 6-2 USFilter
APPENDIX LC Manual 11/02 Rev. 3 7.1 GLOSSARY OF TERMS 7.0 APPENDIX The terms commonly used in reverse osmosis are defined below: ANION - Negatively charged ion, such as CO3 -- , SO4 -- , HCO3 -- , Cl - , NO3 - , etc. CATION - Positively charged ion, such as Ca ++ , Mg ++ , Fe ++ , Na + , K + , etc. CONCENTRATE (REJECT) - Concentrated portion of the feed remaining outside the membrane which is discarded. CONDUCTIVITY - A measure of salt concentration due to the ability of dissolved solids (ions) to conduct electricity, usually expressed as micromhos/cm. FEED - The feedwater pumped into a permeator under high-pressure. OSMOSIS - Osmosis is the diffusion of a solvent (such as pure water) from a dilute saline solution into a more concentrated saline solution through a semipermeable membrane separating the two solutions. OSMOTIC HEAD - Osmotic head (pressure) is the change in head resulting from water transport through the semipermeable membrane separating two saline solutions of different concentrations. PASSAGE - Ratio of permeate to feed concentration of a particular dissolved material, expressed in percent. PERMEATE (PRODUCT) - The purified portion of the feed passing through the membrane. RECOVERY - Percent of feedwater converted into permeate. REVERSE OSMOSIS (RO) - The process by which incoming fluid (feed) is forced under highpressure through a reverse osmosis membrane. A portion of the fluid with concentrated ionic materials (concentrate) remains upstream of the membrane and is discarded (unless it is of interest in a particular application). The highly purified portion (permeate) which passed through the membrane would then be collected for use (as in a water purification application). REVERSE OSMOSIS (RO) MEMBRANE - An RO membrane is a semipermeable membrane generally in sheet or hollow fiber form which rejects not only dissolved materials, but also organics, submicron size colloidal materials and bacteria which may contaminate a high purity USFilter 7-1
Page 1 and 2: USFilter 10 Technology Drive Lowell
Page 3 and 4: This manual discloses information i
Page 5 and 6: TABLE OF CONTENTS SECTION DESCRIPTI
Page 7 and 8: LC Manual 11/02 Rev. 3 INTRODUCTION
Page 9 and 10: LC Manual 11/02 Rev. 3 INTRODUCTION
Page 11 and 12: LC Manual 11/02 Rev. 3 SYSTEM INSTA
Page 13 and 14: LC Manual 11/02 Rev. 3 SYSTEM INSTA
Page 15 and 16: LC Manual 11/02 Rev. 3 OPERATING IN
Page 21 and 22: SYSTEM MAINTENANCE LC Manual 11/02
Page 31 and 32: TROUBLESHOOTING LC Manual 11/02 Rev
Page 33: LC Manual 11/02 Rev. 3 WARRANTY 6.1
Page 37 and 38: APPENDIX LC Manual 11/02 Rev. 3 7.2
Page 41 and 42: APPENDIX LC Manual 11/02 Rev. 3 RO
Page 45 and 46: Product Description/Equipment Speci
Page 47 and 48: Process Water Systems General Speci
Page 49 and 50: Process Water Systems Low feed pres
Page 51 and 52: Process Water Systems Skid Cleaning
Page 53 and 54: Series 1, 2 & 3 Pumps Page 1 of 2 [
Page 55 and 56: Product Information FILMTEC Membran
Page 57 and 58: USFilter USFilter USFilter USFilter
Page 59 and 60: Conventions and Symbols ii Special
Page 61 and 62: Table of Contents iv MC10 Overview
Page 63 and 64: Specifications The MC10 incorporate
Page 65 and 66: ! The MC10 may be configured to use
Page 67 and 68: Installation 2 Environmental The MC
Page 69 and 70: I/O The wiring diagram for the inpu
Page 71 and 72: Operation 3 Controls The MC10 is ho
Page 73 and 74: Sequence The normal startup and shu
Page 75 and 76: 7 Perm Divert TD Sec 8 High Temp SP
Page 77 and 78: Time Delays Time delays and deadban
Page 79 and 80: Important Please note: • Temperat
Page 81 and 82: Troubleshooting 5 The MC10 Reverse
Page 83 and 84: Type of Problem Possible Cause or S

Operation and Maintenance Manual for

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?