Operation and Maintenance Manual for

More documents

Recommendations

Info

LC Manual 11/02 Rev. 3 APPENDIX water system. The process is not absolute and therefore most reverse osmosis membranes are defined by their rejection characteristics. SOLUTE - Material (salts) dissolved by solvent (water). TOTAL DISSOLVED SOLIDS - Total dissolved inorganic salts present in the permeator stream 7-2 USFilter
APPENDIX LC Manual 11/02 Rev. 3 7.2 REPLACEMENT/SPARE PARTS LIST – LC MODEL (VROLC0XXX) PART NUMBER DESCRIPTION FCR0N0905 CARTRIDGE FILTER 5 MICRON 9-3/4” 09/02027-01 CARTRIDGE FILTER HOUSING, 10” W/ MNT BRACKET B10012698 CARTRIDGE BOWL ZHA151021 CARTRIDGE O-RING 15/03939-01 PRESSURE GAUGE 0-100 PSI BTM MNT 15/03939-03 PRESSURE GAUGE 0-300 PSI PNL MNT 15/03939-06 PRESSURE GAUGE 0-300 PSI BTM MNT 49/S0201-120 PVC PUMP DISTRIBUTION BLOCK 04/03932-01 PUMP 240GPH BRASS 1/2FPT ROSTW2540 RO MEMBRANE 06/30707-02 PRESSURE VESSEL 2.5X40 PVC, 225 PSI P92828 ENDCAP 1-PORT (HYDROCOMPONENTS PRT# 2500.2-1) P92829 ENDCAP 2-PORT (HYDROCOMPONENTS PRT# 2500.2-2) P92830 U-PIN (HYDROCOMPONENTS PRT# 2500.2-4) P92831 O-RING 2.5” OD (HYDROCOMPONENTS PRT# 200-330) P92832 O-RING 3/4“ ID (HYDROCOMPONENTS PRT# 200-210) 22/03976-01 LOW PRESSURE SWITCH 22/03976-02 HIGH PRESSURE SWITCH 03/03931-03 STARTER (60HZ) 03/30565-03 STARTER (50HZ) 03/30049-01 OVERLOAD RELAY FOR STARTER (60HZ) 03/30558-01 OVERLOAD RELAY FOR STARTER (50HZ) 05/03904-12 SOLENOID VALVE BRASS 3/4FPT 24V 05/03904-06 SOLENOID VALVE BRASS 3/8FPT 24V (60HZ) 05/31953-06 SOLENOID VALVE BRASS 3/8FPT 24V (50HZ) 18/03951-01 CONDUCTIVITY SENSOR 3/4 MPT 06/31020-20 BRINE SEAL P91141 SAMPLE VALVE 05/03891-04 NEEDLE VALVE BRASS ¼ FPT 05/12961-01 CHECK VALVE, 1/2 NPT PVC 05/03892-04 CHECK VALVE 1/4 MPT 10/64045-06 NYLON TUBING 3/8 OD 10/64045-08 NYLON TUBING 1/2 OD 15/02472-01 PRESSURE REGULATOR 3/4 FPT 21/03995-02 FLOWMETER 0.5-5 GPM 21/03995-01 FLOWMETER 0.2-2 GPM 26/10715-01 LEVELING PAD 03/03929-01 MC10 CONTROLLER (Without MODEM ASSEMBLY) USFilter 7-3
Page 1 and 2: USFilter 10 Technology Drive Lowell
Page 3 and 4: This manual discloses information i
Page 5 and 6: TABLE OF CONTENTS SECTION DESCRIPTI
Page 7 and 8: LC Manual 11/02 Rev. 3 INTRODUCTION
Page 9 and 10: LC Manual 11/02 Rev. 3 INTRODUCTION
Page 11 and 12: LC Manual 11/02 Rev. 3 SYSTEM INSTA
Page 13 and 14: LC Manual 11/02 Rev. 3 SYSTEM INSTA
Page 15 and 16: LC Manual 11/02 Rev. 3 OPERATING IN
Page 21 and 22: SYSTEM MAINTENANCE LC Manual 11/02
Page 31 and 32: TROUBLESHOOTING LC Manual 11/02 Rev
Page 33 and 34: LC Manual 11/02 Rev. 3 WARRANTY 6.1
Page 35: APPENDIX LC Manual 11/02 Rev. 3 7.1
Page 39 and 40: APPENDIX LC Manual 11/02 Rev. 3 7.3
Page 41 and 42: APPENDIX LC Manual 11/02 Rev. 3 RO
Page 43 and 44: APPENDIX LC Manual 11/02 Rev. 3 7.5
Page 45 and 46: Product Description/Equipment Speci
Page 47 and 48: Process Water Systems General Speci
Page 49 and 50: Process Water Systems Low feed pres
Page 51 and 52: Process Water Systems Skid Cleaning
Page 53 and 54: Series 1, 2 & 3 Pumps Page 1 of 2 [
Page 55 and 56: Product Information FILMTEC Membran
Page 57 and 58: USFilter USFilter USFilter USFilter
Page 59 and 60: Conventions and Symbols ii Special
Page 61 and 62: Table of Contents iv MC10 Overview
Page 63 and 64: Specifications The MC10 incorporate
Page 65 and 66: ! The MC10 may be configured to use
Page 67 and 68: Installation 2 Environmental The MC
Page 69 and 70: I/O The wiring diagram for the inpu
Page 71 and 72: Operation 3 Controls The MC10 is ho
Page 73 and 74: Sequence The normal startup and shu
Page 75 and 76: 7 Perm Divert TD Sec 8 High Temp SP
Page 77 and 78: Time Delays Time delays and deadban
Page 79 and 80: Important Please note: • Temperat
Page 81 and 82: Troubleshooting 5 The MC10 Reverse
Page 83 and 84: Type of Problem Possible Cause or S

Operation and Maintenance Manual for

Create successful ePaper yourself

Delete template?

Save as template?