You also want an ePaper? Increase the reach of your titles
YUMPU automatically turns print PDFs into web optimized ePapers that Google loves.
OPERATION, LUBRICATION, MAINTENANCE AND TUNE-UP 6 1<br />
Transmission Oil Level Check<br />
screw it in. Pull out the dipstick and read the oil level on<br />
the dipstick.<br />
Check the transmission oil level on a weekly basis.<br />
1. With the boat at rest in the water and the engine off, un- 2. Add oil, if necessary, through the dipstick hole so the<br />
screw the dipstick (Figure 39, typical). Wipe it with a oil level reaches the full mark on the dipstick. Use the oil<br />
clean rag or paper towel. Reinsert the dipstick, but do not recommended in the preceding section.<br />
Daily<br />
Weekly<br />
Every 50 hours<br />
Every 100 hours<br />
Every 250 hours<br />
Every 300 hours<br />
Every 500 hours<br />
Every 1500 hours<br />
Every 2000 hours<br />
Annually<br />
Table I MAINTENANCE SCHEDULE<br />
Check fuel level<br />
Check engine oil level<br />
Check battery<br />
Check air filter<br />
Check transmission oil level<br />
Check drive belt tension<br />
Check electrical wiring<br />
Clean fuel filter<br />
Change engine oil<br />
Drain fuel tank<br />
Replace air filter element<br />
Replace fuel filter element<br />
Change transmission oil<br />
Replace engine oil filter<br />
Adjust engine valves<br />
Inspect thermostat<br />
Inspect seawater pump<br />
Replace thermostat<br />
Replace freshwater (closed system) antifreeze<br />
Ambient Temperature<br />
Below 50" F (1 0" C)<br />
50" - 68" F (lo - 20" C)<br />
6s. - 95O F (20" - 35" C)<br />
Above 95" F (35" C)<br />
Table 2 ENGINE OIL VISCOSITY<br />
Oil viscosity<br />
1 OW, 20W or 20120W<br />
20 or 20120W<br />
30 or 40<br />
50<br />
Model<br />
- -<br />
Table 3 ENGINE OIL CRANKCASE CAPACITY<br />
Oil capacity<br />
lGM, lGM10 1.4 qt. (1.3 L)<br />
2GM, 2GM20 2.1 qt. (2.0 L)<br />
3GM, 3GM30 2.8 qt. (2.6 L)<br />
3HM, 3HM35 5.7 qt. (5.4 L)