twin-path® slings in action - Hanes Supply, Inc

More documents

Recommendations

Info

YOUR SLING AND RIGGING SPECIALISTalloy chain slingsThe life & strength of Alloy chain slings depends on proper inspection,maintenance and use. For additional info, refer toANSI B30.9 & OSHA 1920.184.CAREChain requires careful storage & regular maintenance.• Store chains on an A frame in a clean, dry place.• To avoid corrosion, oil chaines before prolonged storage.• Do not heat Alloy chain; this will alter its thermal treatment• Do not plate or change surface finish of chain. ContactHanes for special requirements.USETo protect both operators and materials, observe these precautionswhen using chain slings:• Before use, inspect chain and attachments following theinstructions under "Inspection" below.• Do not exceed working load limit. Any of the factors listedhere can reduce the load the chain will hold:• Acceleration in rate of load to application –can produce dangerous overloading.• Variation in the angle of the load to the sling – as theangle decreases, the working load of the sling willincrease.• Twisting, knotting or kinking – subjects links to unusualloading, decreasing the working load of the sling.• Use for purposes other than those for which slings areintended – can reduce the working load of the sling.• Free chain of all twists, knots and kinks.• Center load in hook(s); hook latches must not support load.• Avoid sudden jerks when lifting and lowering.• Balance all loads; avoid tipping of loads.• Use pads around sharp corners.• Do not drop load on chains.• Match the size & working load limit of attachments suchas hooks or rings to the size & WLL of the chain.• For overhead lifting, use only alloy chain and attachments(grade 80 or 100).INSPECTIONIt is important both to inspect chain slings regularly and tokeep a record of all chain inspections. Follow this guide forsuch an inspection system.• Before inspecting, clean chains with a non-acid/noncausicsolvent so that marks, nicks, wear and otherdefects are visible.• Inspect each link for these conditions:• Twists or bends.• Nicks or gouges.• Excessive wear at bearing points.• Stretch.CARE, USE AND INSPECTION• Distorted or damaged master links, coupling links orattachments, especially spread in throat opening ofhooks.• Mark plainly with paint each link or attachmentshowing any of the conditions listed here to indicaterejection; remove from service until properly repaired.WEAR ALLOWANCES OF ALLOY CHAINMeasure cross section at link ends to determine wear. Ifchain is worn to less than the minimum allowable thickness,remove from service.Maximum Minimum ThicknessAllowable Wear Allowable atMM Inches (inches) Link Ends (inches)*5.5 7/32 2/64 (.031)– – – 12/64 (.189)7.0 9/32 2/64 (.031) 16/64 (.239)10.0 3/8 3/64 (.047) 21/64 (.342)13.0 1/2 4/64 (.062) 28/64 (.443)16.0 5/8 5/64 (.078) 35/64 (.546)20.0 3/4 6/64 (.094) 42/64 (.687)22.0 7/8 8/64 (.125) 48/64 (.750)26.0 1 9/64 (.140) 53/64 (.887)32.0 1-1/4 10/64 (.156) 70/64 (1.09)USE OF CHAIN UNDER HEAT CONDITIONSWhen the chain itself is heated to temperatures shown here,working load limits should be reduced as indicated.Reduction in PermanentTemperature Working Load Limit 1 Reduction Inof Chain While Heated Working Load Limit 2500°F 25% 5%600°F 30% 15%700°F 40% 20%800°F 50% 25%900°F 60% 30%1000°F 70% 35%1While chain is at temperature shown in first column.2When chain is used at room temperature after havingbeen heated to temperatures shown in first column.CERTIFICATE OF TEST AND IDENTIFICATIONThe identification tag found on the master coupling link ofeach chain sling contains this information:• Grade• Size• Reach• Type• Working load limit (at a specific angle of lift)• Serial numberHEADQUARTERS: 55 James E. Casey Drive • Buffalo, NY 14206 PHONE: 716.826.2636 FAX: 716.826.4412 www.hanessupply.com44
alloy chain sling specificationsYOUR SLING AND RIGGING SPECIALISTREACHSINGLECHAINSLINGSTYPE SOGGRAB HOOKTYPE SOGCLEVLOCKGRAB HOOKTYPE SOSCLEVLOCKSLING HOOKTYPE SOFFOUNDRYHOOKTYPE SOSSLINGHOOKTYPE SOLLATCHLOKHOOKREACHDOUBLECHAINSLINGSSINGLEBASKETTYPE DOSCLEVLOKSLING HOOKTYPE DOGCLEVLOKGRAB HOOKTYPE DOFFOUNDRYHOOKTYPE DOSTYPE DOGGRAB HOOKREACHTRIPLE& QUADCHAINSLINGSTYPE TOS TYPE OOS DOUBLE BASKETREACHSINGLE ADJUSTABLELOOP - STYLE ADOUBLE ADJUSTABLELOOP - STYLE ASINGLEADJUSTABLE LOOPCHAIN SLINGDOUBLEADJUSTABLE LOOPCHAIN SLINGHEADQUARTERS: 55 James E. Casey Drive • Buffalo, NY 14206 PHONE: 716.826.2636 FAX: 716.826.4412 www.hanessupply.com45
Page 2 and 3: This Rigger’s Handbook is dedicat
Page 4 and 5: YOUR SLING AND RIGGING SPECIALISTHo
Page 6 and 7: YOUR SLING AND RIGGING SPECIALISTIn
Page 8 and 9: YOUR SLING AND RIGGING SPECIALISTtw
Page 10 and 11: single-Path & twin-Path ® High Per
Page 18 and 19: YOUR SLING AND RIGGING SPECIALISTco
Page 20 and 21: YOUR SLING AND RIGGING SPECIALISTfl
Page 26 and 27: YOUR SLING AND RIGGING SPECIALISTtr
Page 28 and 29: YOUR SLING AND RIGGING SPECIALISTGa
Page 30 and 31: Gator-Max tM Wire Rope slingsYOUR S
Page 32 and 33: YOUR SLING AND RIGGING SPECIALISTGa
Page 34 and 35: YOUR SLING AND RIGGING SPECIALISTHa
Page 36 and 37: YOUR SLING AND RIGGING SPECIALISTca
Page 38 and 39: YOUR SLING AND RIGGING SPECIALISTGr
Page 40 and 41: YOUR SLING AND RIGGING SPECIALIST3
Page 42 and 43: YOUR SLING AND RIGGING SPECIALISTWi
Page 44 and 45: YOUR SLING AND RIGGING SPECIALISTch
Page 48 and 49: REACHchain slings - single types s&
Page 50 and 51: YOUR SLING AND RIGGING SPECIALISTch
Page 54 and 55: YOUR SLING AND RIGGING SPECIALISTBA
Page 56 and 57: nylon slingsYOUR SLING AND RIGGING
Page 58 and 59: YOUR SLING AND RIGGING SPECIALISTsy
Page 60 and 61: YOUR SLING AND RIGGING SPECIALISTsy
Page 62 and 63: YOUR SLING AND RIGGING SPECIALISTPo
Page 64 and 65: YOUR SLING AND RIGGING SPECIALISTlo
Page 66 and 67: YOUR SLING AND RIGGING SPECIALISTtr
Page 68 and 69: Hand chain HoistsYOUR SLING AND RIG
Page 70 and 71: YOUR SLING AND RIGGING SPECIALISTPo
Page 72 and 73: cordage InformationYOUR SLING AND R
Page 76 and 77: YOUR SLING AND RIGGING SPECIALISTso
Page 82 and 83: YOUR SLING AND RIGGING SPECIALISTMs
Page 84 and 85: YOUR SLING AND RIGGING SPECIALISTHi
Page 86 and 87: YOUR SLING AND RIGGING SPECIALISTli
Page 90 and 91: YOUR SLING AND RIGGING SPECIALISTfo
Page 92 and 93: YOUR SLING AND RIGGING SPECIALISTal
Page 94 and 95: YOUR SLING AND RIGGING SPECIALISTsl
Page 96 and 97:
sling saver synthetic sling HooksYO
Page 98 and 99:
YOUR SLING AND RIGGING SPECIALISTsl
Page 100 and 101:
YOUR SLING AND RIGGING SPECIALISTHo
Page 102 and 103:
YOUR SLING AND RIGGING SPECIALISTsl
Page 104 and 105:
swivel HooksYOUR SLING AND RIGGING
Page 106 and 107:
YOUR SLING AND RIGGING SPECIALISTcr
Page 108 and 109:
YOUR SLING AND RIGGING SPECIALISTGo
Page 110 and 111:
YOUR SLING AND RIGGING SPECIALISTWe
Page 112 and 113:
Page 114 and 115:
YOUR SLING AND RIGGING SPECIALISTJa
Page 116 and 117:
YOUR SLING AND RIGGING SPECIALISTJa
Page 118 and 119:
YOUR SLING AND RIGGING SPECIALISTth
Page 120 and 121:
YOUR SLING AND RIGGING SPECIALISTcl
Page 122 and 123:
YOUR SLING AND RIGGING SPECIALISTcl
Page 124 and 125:
YOUR SLING AND RIGGING SPECIALISTsw
Page 126 and 127:
YOUR SLING AND RIGGING SPECIALISTey
Page 128 and 129:
YOUR SLING AND RIGGING SPECIALISTey
Page 130 and 131:
Page 132 and 133:
YOUR SLING AND RIGGING SPECIALISTli
Page 134 and 135:
YOUR SLING AND RIGGING SPECIALISTli
Page 136 and 137:
swivelsYOUR SLING AND RIGGING SPECI
Page 138 and 139:
YOUR SLING AND RIGGING SPECIALISTWi
Page 140 and 141:
General Purpose Wire RopeYOUR SLING
Page 142 and 143:
Page 144 and 145:
YOUR SLING AND RIGGING SPECIALISTAB
Page 146 and 147:
Page 148 and 149:
Page 150 and 151:
Page 152 and 153:
YOUR SLING AND RIGGING SPECIALISTba
Page 154 and 155:
YOUR SLING AND RIGGING SPECIALISTGe
Page 156 and 157:
General InformationYOUR SLING AND R
Page 158 and 159:
YOUR SLING AND RIGGING SPECIALISTGe
Page 160 and 161:
YOUR SLING AND RIGGING SPECIALISTLi
Page 162 and 163:
YOUR SLING AND RIGGING SPECIALISTUs
show all

twin-path® slings in action - Hanes Supply, Inc

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?