OS-C501

Recommendations

Info

Offshore Standard DNV-OS-C501, November 2013 App.H Example for representative data – Unidirectional carbon tapes made of TPW tape with “5631” fibres – Page 244 Table H-1 Properties to define the material (Continued) A B C D Requirements to group measurements from different laminates Constituent materials: Tenax STS 5631 Tenax HTS 5631 Tenax HTS 5631 Tenax UTS 5631 1600tex 800tex 1600tex 800tex f24000 t0 f12000 t0 f24000 t0 f12000 t0 Processing method Autoclave cured Autoclave cured Autoclave cured Autoclave cured Processing temperature 140°C for 60 180°C for 20 180°C for 20 minutes 180°C for 20 minutes minutes minutes Processing pressure 4.0 bar 5.0 bar 5.0 bar 5.0 bar Process atmosphere (e.g. 0.99 bar 0.99 bar 0.99 bar 0.99 bar vacuum) Post curing (temperature none None none none and time) Control of fibre orientation --- --- --- --- Fibre volume fraction 58-60% 54.5-57.8% 54.5-57.8% 54.6-60% Void content 1.88 - 2.06% 0.79% 0.69% 1.3% Conditioning parameters: See sections for properties: H.3 Quasi static properties in air (QSA) H.3.1 Test environment H.3.1.1 The test environment is described according to Sec.4 [8.5.2]. H.3.1.2 The following properties are listed according to Sec.4 [2.2]. Characteristic values are calculated according to Sec.4 [2.4]. H.3.1.3 Data are based on a set of 6 measurements for each property, backed up by more than 50 measurements from production control. Table H-2 Conditioning parameters Temperature 23 °C Water content of the laminate (wet, dry) Dry Chemical environment Air Loading rate 1-2 mm / minute * number of specimens Reported individually for all properties * Rates varied slightly between test methods. Shear data were obtained from ±45 laminates tested at 2 mm/minute and sometimes at faster rates of about 6 mm/min after 2% strain. DET NORSKE VERITAS AS
Offshore Standard DNV-OS-C501, November 2013 App.H Example for representative data – Unidirectional carbon tapes made of TPW tape with “5631” fibres – Page 245 H.3.2 Fibre dominated ply properties Table H-3 Fibre dominated ply Properties A B C D Parameter (Unit) E 1 (UD ply) [GPa] ε ∧ 1t ε ∧ 1c 1t σ ∧ σ ∧ 1c N/mm 2 (MPa) H.3.3 Matrix dominated ply properties H.3.3.1 There are no representative data. H.3.4 Through thickness ply properties H.3.4.1 There are no representative data. H.4 Long term properties H.4.1 General Tenax STS 5631 1600tex f24000 t0 Tenax HTS 5631 800tex f12000 t0 Tenax HTS 5631 1600tex f24000 t0 Tenax UTS 5631 800tex f12000 t0 H.4.1.1 There are no representative long term data for service in air or water. Explanation Mean COV 145.2 (118.2) 2.21% (5.68%) 140.9 (114.2) 1.50% (3.53%) 143.4 (124.9) 1.81% (5.48%) 142.9 (120.8) 1.32% (2.69%) Modulus of elasticity in main fibre direction, in tension and (compression) Charact.value Same as mean Same as mean Same as mean Same as mean Mean 0.0167 0.0168 0.0170 0.0184 Tensioning strain at break in COV 2.58% 0.75% 2.35% 2.09% the main fibre direction. Characteristic value calculated Charact.value 0.0160 0.0160 0.0161 0.0178 from strength data. * for calculations Mean 0.0079 0.0084 0.0074 0.0099 Compressive strain at break in COV 9.77% 15.3% 9.21% 20.64% the main fibre direction. Characteristic value calculated Charact.value 0.0069 0.0061 0.0055 0.0064 from strength data. * for calculations Mean 2449 2394 2475 2652 Tension stress at break in the COV 2.64% 2.78% 3.33% 1.95% main fibre direction Charact.value 2320 2261 2310 2549 Mean 897 923 888 1145 Compressive stress at break in COV 4.52% 12.44% 11.34% 19.11% the main fibre direction Charact.value 816 693 687 776 N/mm 2 (MPa) * Characteristic strains to failure were calculated from the characteristic strength data allowing easy linear analysis. A higher strain to failure may be used if nonlinear effects are taken into account in the analysis, i.e., drop of Young's modulus. DET NORSKE VERITAS AS
Page 1 and 2:
OFFSHORE STANDARD DNV-OS-C501 Compo
Page 3 and 4:
Offshore Standard DNV-OS-C501, Nove
Page 5 and 6:
Page 7 and 8:
Page 9 and 10:
Page 11 and 12:
Page 13 and 14:
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
Page 59 and 60:
Page 61 and 62:
Page 63 and 64:
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
Page 79 and 80:
Page 81 and 82:
Page 83 and 84:
Page 85 and 86:
Page 87 and 88:
Page 89 and 90:
Page 91 and 92:
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
Page 107 and 108:
Page 109 and 110:
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
Page 189 and 190:
Page 191 and 192:
Page 193 and 194: Offshore Standard DNV-OS-C501, Nove
Page 243: Offshore Standard DNV-OS-C501, Nove
show all

OS-C501

Create successful ePaper yourself

Delete template?

Save as template?