Programmable Controllers: Theory and Implementation

More documents

Recommendations

Info

Introduction to PLC Programming and Implementation—from relay logic to PLC logicL1StartPB1StopPB2CR1L2CR1CR1TempTS3CR2PL1ReadyLevelFS4CR2 CR3SOL1OpenPL2LevelFS5CR2SOL2OpenCR3PL3CR1TempTS3H3HeatingorHFigure 7. Electromechanical relay circuit.Assume that the PLC used has a modularity of 8 points per module.Each rack has 8 module slots, and the master rack is number 0. Inputsand outputs can have any address as long as the correct module isused. The PLC determines whether an input or output module isconnected in a slot. The number system is octal, and internals start ataddress 1000 8 .SOLUTION(a) Figure 8 shows the circled real input and output connections. Notethat temperature switch TS3 is circled twice even though it is only onedevice. In the address assignment, only one of them is referenced, andonly one of them is wired to an input module.(b) Table 4 illustrates the assignment of inputs and outputs. It assignsall inputs and all outputs, leaving spare I/O locations for future use.Industrial Text & Video Company www.industrialtext.com 1-800-752-839812
Introduction to PLC Programming and Implementation—from relay logic to PLC logicL1StartPB1StopPB2CR1L2CR1CR1TempTS3CR2PL1ReadyLevelFS4CR2 CR3SOL1OpenPL2LevelFS5CR2SOL2OpenCR2PL3CR1TempTS3H3HeatingorHFigure 8. Identification of real I/O (circled).ModuleTypeRackI/O AddressGroupTerminalTable 4. I/O address assignment.DescriptionInput0 0 0 Start PB10 0 1 Stop PB20 0 2 Temp TS30 0 3 Level FS40 0 4 Level FS50 0 5 —0 0 6 —0 0 7 —Spare0 1 0 Not used• • •• • •• • •0 1 7Output0 2 0 PL1 Ready0 2 1 SOL1 Open0 2 2 PL20 2 3 SOL2 Open0 2 4 PL30 2 5 H3 Heating0 2 6 —0 2 7 —Industrial Text & Video Company www.industrialtext.com 1-800-752-839813
Page 2 and 3: A Special Note ToOur CustomersHere
Page 4 and 5: Programmable Controllers: Workbook/
Page 6 and 7: Introduction to PLC Programming and
Page 66 and 67:
Introduction to PLC Programming and
Page 68 and 69:
ntroduction to PLC Programming and
Page 70 and 71:
Page 72 and 73:
Page 74 and 75:
Page 76:
show all

Programmable Controllers: Theory and Implementation

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?