Peterbilt Medium Duty Trucks Operator's Manual after 1-07

More documents

Recommendations

Info

Brake System • During wheel balancing, dyno testing, or any time the ignition is on with part of the ABS disconnected, a failure code will be recorded. Consult with your Peterbilt Dealer or Authorized Service Center for information on clearing the failure code. If, due to operating conditions, a brake application causes either wheel on the same axle to begin skidding, wheel speed sensors immediately signal the anti-lock controller in the modulator assembly. The controller responds instantly by signaling the solenoids in the modulator which activate the air valves, reducing application pressure as needed to prevent the wheels from locking up. If this over-riding correction is effective, application pressure is allowed to build up to the original input. Any malfunction of the anti-lock system on one or more axles will cause the system to fail-safe, and the panel-mounted amber warning light will come on, indicating both a malfunction, and automatic shut-down of the system. If the foundation brake system is intact, the service brakes will continue to function normally, but without benefit of the anti-lock feature. Preventive Maintenance NOTE: If one wheel on any driven axle continues to slip or spin for approximately 4 seconds, this will cause the anti-lock controller for that axle to go into the fail-safe mode, and the warning light will give a shutdown signal. •In this case, the anti-lock system can be turned back on, and the warning light extinguished, by turning the key switch OFF and ON, after the vehicle has been brought to a full stop. When the key switch is turned back on, the warning light will illuminate and remain on for 3 to 5 seconds. This is a built-in function test of the warning light. WARNING! Do not attempt to recycle the antilock system by turning the keyswitch OFF and ON until the vehicle has been brought to a full stop and the parking brakes set. Failure to do so could adversely affect steering and braking control, and may result in loss of vehicle control and an injury accident. – 158 – Y53-6008 Medium Duty (R10/06)
Preventive Maintenance Brake System WARNING! Do not operate the vehicle in the event of a malfunction in any air or hydraulic circuit. Such a malfunction may prevent the brake system from operating properly, and could result in an injury accident. The vehicle should not be operated until the system is repaired and both braking circuits, including all pneumatic, hydraulic, and mechanical components are working properly. Medium Duty (R10/06) Y53-6008 – 159 –
Page 1 and 2:
O PERAT O R’S M ANUAL Medium Duty
Page 3 and 4:
Introduction INTRODUCTION How to Us
Page 5 and 6:
Introduction Vehicle Safety Make su
Page 7 and 8:
Introduction Medium Duty Body Build
Page 9 and 10:
Operating Instructions Start-Up OPE
Page 11 and 12:
Operating Instructions NOTE: Any al
Page 13 and 14:
Operating Instructions After loweri
Page 15 and 16:
Operating Instructions GAWR: is the
Page 17 and 18:
Operating Instructions 1. Lights—
Page 19 and 20:
Operating Instructions Start-Up 5 6
Page 21 and 22:
Operating Instructions Instruments
Page 23 and 24:
Page 25 and 26:
Operating Instructions Coolant (Wat
Page 27 and 28:
Page 29 and 30:
Operating Instructions WARNING! If
Page 31 and 32:
Operating Instructions Voltmeter (o
Page 33 and 34:
Page 35 and 36:
Operating Instructions WARNING! Do
Page 37 and 38:
Operating Instructions (2) Trailer
Page 39 and 40:
Page 41 and 42:
Operating Instructions aware of a r
Page 43 and 44:
Operating Instructions Defogging CA
Page 45 and 46:
Operating Instructions Radio ACCESS
Page 47 and 48:
Operating Instructions Introduction
Page 49 and 50:
Operating Instructions Seats • Be
Page 51 and 52:
Page 53 and 54:
Operating Instructions Tether Adjus
Page 55 and 56:
Operating Instructions Seats If any
Page 57 and 58:
Operating Instructions Emergency Fl
Page 59 and 60:
Operating Instructions Power Mirror
Page 61 and 62:
Operating Instructions Starting Pro
Page 63 and 64:
Operating Instructions Starting Pro
Page 65 and 66:
Operating Instructions After the en
Page 67 and 68:
Page 69 and 70:
Operating Instructions OPERATING TH
Page 71 and 72:
Operating Instructions If you have
Page 73 and 74:
Operating Instructions Release Bear
Page 75 and 76:
Operating Instructions Brake Operat
Page 77 and 78:
Operating Instructions (2) Trailer
Page 79 and 80:
Operating Instructions Using the Br
Page 81 and 82:
Operating Instructions Front Brakes
Page 83 and 84:
Operating Instructions To prevent d
Page 85 and 86:
Operating Instructions • If a tra
Page 87 and 88:
Operating Instructions On tractors
Page 89 and 90:
Operating Instructions Compressed A
Page 91 and 92:
Operating Instructions ders which a
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Operating Instructions OPERATING TH
Page 99 and 100:
Operating Instructions going down s
Page 101 and 102:
Operating Instructions countershaft
Page 103 and 104:
Operating Instructions Driving Tips
Page 105 and 106:
Operating Instructions Driving Tips
Page 107 and 108:
Operating Instructions Driving with
Page 109 and 110: Operating Instructions Fifth Wheel
Page 111 and 112: Operating Instructions Vehicle Reco
Page 113 and 114: Operating Instructions Vehicle Reco
Page 115 and 116: Operating Instructions Introduction
Page 117 and 118: Operating Instructions WARNING! Do
Page 119 and 120: Preventive Maintenance • When wor
Page 121 and 122: Preventive Maintenance MAINTENANCE
Page 123 and 124: Preventive Maintenance Maintenance
Page 135 and 136: Preventive Maintenance Lubrication
Page 141 and 142: Preventive Maintenance ENGINE MAINT
Page 143 and 144: Preventive Maintenance NOTE: To exp
Page 145 and 146: Preventive Maintenance To Check the
Page 147 and 148: Preventive Maintenance Engine Cooli
Page 149 and 150: Preventive Maintenance 8. Idle the
Page 151 and 152: Preventive Maintenance BRAKE SYSTEM
Page 153 and 154: Preventive Maintenance • Do not u
Page 155 and 156: Preventive Maintenance Constant man
Page 157 and 158: Preventive Maintenance Make sure th
Page 159: Preventive Maintenance Visually ins
Page 163 and 164: Preventive Maintenance Scheduled Ma
Page 165 and 166: Preventive Maintenance CAUTION: Do
Page 167 and 168: Preventive Maintenance head. Also,
Page 169 and 170: Preventive Maintenance High Frequen
Page 171 and 172: Preventive Maintenance Introduction
Page 173 and 174: Preventive Maintenance Tire Inflati
Page 175 and 176: Preventive Maintenance Wheel Mounti
Page 177 and 178: Preventive Maintenance Tires and Wh
Page 179 and 180: Preventive Maintenance Tires and Wh
Page 181 and 182: Preventive Maintenance Wheel and Ti
Page 183 and 184: Preventive Maintenance CAUTION: Dur
Page 185 and 186: Preventive Maintenance All the elec
Page 187 and 188: Preventive Maintenance Overcharge:
Page 189 and 190: Preventive Maintenance before proce
Page 191 and 192: Preventive Maintenance • When fas
Page 193 and 194: Preventive Maintenance Electrical a
Page 195 and 196: Preventive Maintenance Cleaning, Pr
Page 197 and 198: Preventive Maintenance At least eve
Page 199 and 200: Preventive Maintenance • Remove s
Page 201 and 202: Preventive Maintenance Cab Maintena
Page 203 and 204: Preventive Maintenance Cab Maintena
Page 205 and 206: Preventive Maintenance Transmission
Page 207 and 208: Preventive Maintenance Automatic Tr
Page 209 and 210: Preventive Maintenance Steering and
Page 211 and 212:
Preventive Maintenance Front Axle a
Page 213 and 214:
Preventive Maintenance Torque CAUTI
Page 215 and 216:
Preventive Maintenance It is import
Page 217 and 218:
Preventive Maintenance Rear Axle an
Page 219 and 220:
Preventive Maintenance Grade 8 Caps
Page 221 and 222:
Preventive Maintenance Fifth Wheel
Page 223 and 224:
Preventive Maintenance Engine • R
Page 225 and 226:
Preventive Maintenance Transmission
Page 227 and 228:
Preventive Maintenance Noise and Em
Page 229 and 230:
Preventive Maintenance Vehicle Iden
Page 231 and 232:
Preventive Maintenance Consumer Inf
Page 233 and 234:
Preventive Maintenance Federal Safe
Page 235 and 236:
Index fan drive 222 operating the c
Page 237 and 238:
Lubrication 150, 210 axle 209 brake
Page 239 and 240:
Turbocharger 114, 166 Turn signal/h
Page 241:
1 7 13 18 44 56 57 113 221 222 227
show all

Peterbilt Medium Duty Trucks Operator's Manual after 1-07

Create successful ePaper yourself

Delete template?

Save as template?