Peterbilt Medium Duty Trucks Operator's Manual after 1-07

More documents

Recommendations

Info

Cab Maintenance 4. Check buckle and latch for proper operation and to determine if latch plate is worn, deformed, or damaged. 5. Inspect the retractor web storage device, which is mounted on the floor of the vehicle, for damage. The retractor is the heart of the occupant restraint system and can often be damaged if abused, even unintentionally. Check operation to ensure that it is not locked up and that it spools out and retracts webbing properly. WARNING! Failure to adjust tether belts properly can cause excessive movement of the seat in an accident. This could lead to greater injuries for you. Tether belts should be adjusted so that they are taut when the seat is in its most upward and forward position. 6. If tethers are used, be sure they are properly attached to the seat and, if adjustable, that they are adjusted in accordance with installation instructions. Tethers must also be inspected for web wear and proper tightness of mounting hardware. 7. Mounting hardware should be evaluated for corrosion, and for tightness of bolts and nuts. 8. Check web in areas exposed to ultraviolet rays from the sun. If the color of the web in these areas is gray to light Preventive Maintenance brown, the physical strength of the web may have deteriorated due to exposure to the sun's ultraviolet rays. Replace the system. Once the need for replacement of the seat belt has been determined, be certain it is only replaced with an authorized PACCAR Parts replacement seat belt. If the inspection indicates that any part of the seat belt system requires replacement, the entire system must be replaced. An installation guide is attached to every replacement belt. Utilize the proper guide for your type of seat, and follow the instructions very closely. It is vitally important that all components be reinstalled in the same position as the original components that were removed and that the fasteners be torqued to specification. This will maintain the design integrity of the mounting points for the seat belt assembly. Contact your Authorized Peterbilt Dealer if you have any questions concerning seat belt replacement. Windshield Wiper/Washer Check wiper blades annually or every 60,000 miles (96,000 km). Anco 18-inch (450mm) wiper blades are recommended. See “Windshield Wipers/Washer” on page 32 for more information. – 200 – Y53-6008 Medium Duty (R10/06)
Preventive Maintenance Cab Maintenance Washer Reservoir CAUTION: Do not use antifreeze or engine coolant in the windshield washer reservoir—damage to seals and other components will result. RESERVOIR Weekly: check reservoir water level, located in the engine compartment under the coolant expansion tank. If necessary, fill to the proper level. 02604 Windshield Washer Reservoir Medium Duty (R10/06) Y53-6008 – 201 –
Page 1 and 2:
O PERAT O R’S M ANUAL Medium Duty
Page 3 and 4:
Introduction INTRODUCTION How to Us
Page 5 and 6:
Introduction Vehicle Safety Make su
Page 7 and 8:
Introduction Medium Duty Body Build
Page 9 and 10:
Operating Instructions Start-Up OPE
Page 11 and 12:
Operating Instructions NOTE: Any al
Page 13 and 14:
Operating Instructions After loweri
Page 15 and 16:
Operating Instructions GAWR: is the
Page 17 and 18:
Operating Instructions 1. Lights—
Page 19 and 20:
Operating Instructions Start-Up 5 6
Page 21 and 22:
Operating Instructions Instruments
Page 23 and 24:
Page 25 and 26:
Operating Instructions Coolant (Wat
Page 27 and 28:
Page 29 and 30:
Operating Instructions WARNING! If
Page 31 and 32:
Operating Instructions Voltmeter (o
Page 33 and 34:
Page 35 and 36:
Operating Instructions WARNING! Do
Page 37 and 38:
Operating Instructions (2) Trailer
Page 39 and 40:
Page 41 and 42:
Operating Instructions aware of a r
Page 43 and 44:
Operating Instructions Defogging CA
Page 45 and 46:
Operating Instructions Radio ACCESS
Page 47 and 48:
Operating Instructions Introduction
Page 49 and 50:
Operating Instructions Seats • Be
Page 51 and 52:
Page 53 and 54:
Operating Instructions Tether Adjus
Page 55 and 56:
Operating Instructions Seats If any
Page 57 and 58:
Operating Instructions Emergency Fl
Page 59 and 60:
Operating Instructions Power Mirror
Page 61 and 62:
Operating Instructions Starting Pro
Page 63 and 64:
Operating Instructions Starting Pro
Page 65 and 66:
Operating Instructions After the en
Page 67 and 68:
Page 69 and 70:
Operating Instructions OPERATING TH
Page 71 and 72:
Operating Instructions If you have
Page 73 and 74:
Operating Instructions Release Bear
Page 75 and 76:
Operating Instructions Brake Operat
Page 77 and 78:
Operating Instructions (2) Trailer
Page 79 and 80:
Operating Instructions Using the Br
Page 81 and 82:
Operating Instructions Front Brakes
Page 83 and 84:
Operating Instructions To prevent d
Page 85 and 86:
Operating Instructions • If a tra
Page 87 and 88:
Operating Instructions On tractors
Page 89 and 90:
Operating Instructions Compressed A
Page 91 and 92:
Operating Instructions ders which a
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Operating Instructions OPERATING TH
Page 99 and 100:
Operating Instructions going down s
Page 101 and 102:
Operating Instructions countershaft
Page 103 and 104:
Operating Instructions Driving Tips
Page 105 and 106:
Operating Instructions Driving Tips
Page 107 and 108:
Operating Instructions Driving with
Page 109 and 110:
Operating Instructions Fifth Wheel
Page 111 and 112:
Operating Instructions Vehicle Reco
Page 113 and 114:
Operating Instructions Vehicle Reco
Page 115 and 116:
Operating Instructions Introduction
Page 117 and 118:
Page 119 and 120:
Preventive Maintenance • When wor
Page 121 and 122:
Preventive Maintenance MAINTENANCE
Page 123 and 124:
Preventive Maintenance Maintenance
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Preventive Maintenance Lubrication
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Preventive Maintenance ENGINE MAINT
Page 143 and 144:
Preventive Maintenance NOTE: To exp
Page 145 and 146:
Preventive Maintenance To Check the
Page 147 and 148:
Preventive Maintenance Engine Cooli
Page 149 and 150:
Preventive Maintenance 8. Idle the
Page 151 and 152: Preventive Maintenance BRAKE SYSTEM
Page 153 and 154: Preventive Maintenance • Do not u
Page 155 and 156: Preventive Maintenance Constant man
Page 157 and 158: Preventive Maintenance Make sure th
Page 159 and 160: Preventive Maintenance Visually ins
Page 161 and 162: Preventive Maintenance Brake System
Page 163 and 164: Preventive Maintenance Scheduled Ma
Page 165 and 166: Preventive Maintenance CAUTION: Do
Page 167 and 168: Preventive Maintenance head. Also,
Page 169 and 170: Preventive Maintenance High Frequen
Page 171 and 172: Preventive Maintenance Introduction
Page 173 and 174: Preventive Maintenance Tire Inflati
Page 175 and 176: Preventive Maintenance Wheel Mounti
Page 177 and 178: Preventive Maintenance Tires and Wh
Page 179 and 180: Preventive Maintenance Tires and Wh
Page 181 and 182: Preventive Maintenance Wheel and Ti
Page 183 and 184: Preventive Maintenance CAUTION: Dur
Page 185 and 186: Preventive Maintenance All the elec
Page 187 and 188: Preventive Maintenance Overcharge:
Page 189 and 190: Preventive Maintenance before proce
Page 191 and 192: Preventive Maintenance • When fas
Page 193 and 194: Preventive Maintenance Electrical a
Page 195 and 196: Preventive Maintenance Cleaning, Pr
Page 197 and 198: Preventive Maintenance At least eve
Page 199 and 200: Preventive Maintenance • Remove s
Page 201: Preventive Maintenance Cab Maintena
Page 205 and 206: Preventive Maintenance Transmission
Page 207 and 208: Preventive Maintenance Automatic Tr
Page 209 and 210: Preventive Maintenance Steering and
Page 211 and 212: Preventive Maintenance Front Axle a
Page 213 and 214: Preventive Maintenance Torque CAUTI
Page 215 and 216: Preventive Maintenance It is import
Page 217 and 218: Preventive Maintenance Rear Axle an
Page 219 and 220: Preventive Maintenance Grade 8 Caps
Page 221 and 222: Preventive Maintenance Fifth Wheel
Page 223 and 224: Preventive Maintenance Engine • R
Page 225 and 226: Preventive Maintenance Transmission
Page 227 and 228: Preventive Maintenance Noise and Em
Page 229 and 230: Preventive Maintenance Vehicle Iden
Page 231 and 232: Preventive Maintenance Consumer Inf
Page 233 and 234: Preventive Maintenance Federal Safe
Page 235 and 236: Index fan drive 222 operating the c
Page 237 and 238: Lubrication 150, 210 axle 209 brake
Page 239 and 240: Turbocharger 114, 166 Turn signal/h
Page 241: 1 7 13 18 44 56 57 113 221 222 227
show all

Peterbilt Medium Duty Trucks Operator's Manual after 1-07

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?