Peterbilt Medium Duty Trucks Operator's Manual after 1-07

More documents

Recommendations

Info

Noise and Emission Control Piping • Check exhaust piping for rust, corrosion, or damage. Replace deteriorated piping before holes appear. If piping is perforated at any point, temporary patching or lagging is acceptable until you can have permanent repairs made. On turbocharged engines, check joints at flanges and mounting brackets for tightness. Mufflers NOTE: Use only an exact replacement muffler in exhaust systems. Certain mufflers contain integral catalytic converters essential for compliance with EPA emission standards. Using a noncompliant muffler as a replacement could violate these standards and also void the emission system’s warranty. • Check muffler, clamps, and mounting brackets. Tighten if necessary. Inspect muffler for signs of rust or corrosion. • Check internal baffling. You can do this by listening for rattling sounds while tapping the muffler with a rubber mallet or revving the engine up and down through its normal operating range. Exhaust Tail Pipe Preventive Maintenance • Check the mounting. Tighten as necessary. The miter cut at the tip of the pipe must be facing the rear of the vehicle. Do not modify the end of the pipe in any way. Engine Fan and Shroud WARNING! Do not work on the fan with the engine running. The engine fan can engage at any time without warning. Anyone near the fan when it turns on could be seriously injured. Before turning on the ignition, be sure that no one is near the fan. • Check all fasteners for tightness. Check for stress cracks in the shroud. Make sure the shroud is adjusted so that it does not touch the fan blades. • Check to verify that the fan is disengaged (not turning) with the engine running at normal operating temperatures (from cold to the point that the fan engages). • Check fan blade mounting bolts. Inspect fan blades to be sure they are not cracked or bent. If problems exist, refer to the Cooling System section in the Medium Duty Maintenance Manual for detailed maintenance instructions. – 222 – Y53-6008 Medium Duty (R10/06)
Preventive Maintenance Transmission and Driveline • Substituting a different main transmission or drive line components, other than design-specified units, may result in increased vehicle noise emission. Maintenance Log Noise and Emission Control To ensure your Medium Duty's noise control requirements are maintained, record maintenance checks. Use the following log sheet (see Table 13) and retain copies of documents regarding maintenance services performed and parts replaced on the vehicle. Table 13 Maintenance Log Date of Service Mileage Service Performed Service Center Name and Address Medium Duty (R10/06) Y53-6008 – 223 –
Page 1 and 2:
O PERAT O R’S M ANUAL Medium Duty
Page 3 and 4:
Introduction INTRODUCTION How to Us
Page 5 and 6:
Introduction Vehicle Safety Make su
Page 7 and 8:
Introduction Medium Duty Body Build
Page 9 and 10:
Operating Instructions Start-Up OPE
Page 11 and 12:
Operating Instructions NOTE: Any al
Page 13 and 14:
Operating Instructions After loweri
Page 15 and 16:
Operating Instructions GAWR: is the
Page 17 and 18:
Operating Instructions 1. Lights—
Page 19 and 20:
Operating Instructions Start-Up 5 6
Page 21 and 22:
Operating Instructions Instruments
Page 23 and 24:
Page 25 and 26:
Operating Instructions Coolant (Wat
Page 27 and 28:
Page 29 and 30:
Operating Instructions WARNING! If
Page 31 and 32:
Operating Instructions Voltmeter (o
Page 33 and 34:
Page 35 and 36:
Operating Instructions WARNING! Do
Page 37 and 38:
Operating Instructions (2) Trailer
Page 39 and 40:
Page 41 and 42:
Operating Instructions aware of a r
Page 43 and 44:
Operating Instructions Defogging CA
Page 45 and 46:
Operating Instructions Radio ACCESS
Page 47 and 48:
Operating Instructions Introduction
Page 49 and 50:
Operating Instructions Seats • Be
Page 51 and 52:
Page 53 and 54:
Operating Instructions Tether Adjus
Page 55 and 56:
Operating Instructions Seats If any
Page 57 and 58:
Operating Instructions Emergency Fl
Page 59 and 60:
Operating Instructions Power Mirror
Page 61 and 62:
Operating Instructions Starting Pro
Page 63 and 64:
Operating Instructions Starting Pro
Page 65 and 66:
Operating Instructions After the en
Page 67 and 68:
Page 69 and 70:
Operating Instructions OPERATING TH
Page 71 and 72:
Operating Instructions If you have
Page 73 and 74:
Operating Instructions Release Bear
Page 75 and 76:
Operating Instructions Brake Operat
Page 77 and 78:
Operating Instructions (2) Trailer
Page 79 and 80:
Operating Instructions Using the Br
Page 81 and 82:
Operating Instructions Front Brakes
Page 83 and 84:
Operating Instructions To prevent d
Page 85 and 86:
Operating Instructions • If a tra
Page 87 and 88:
Operating Instructions On tractors
Page 89 and 90:
Operating Instructions Compressed A
Page 91 and 92:
Operating Instructions ders which a
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Operating Instructions OPERATING TH
Page 99 and 100:
Operating Instructions going down s
Page 101 and 102:
Operating Instructions countershaft
Page 103 and 104:
Operating Instructions Driving Tips
Page 105 and 106:
Operating Instructions Driving Tips
Page 107 and 108:
Operating Instructions Driving with
Page 109 and 110:
Operating Instructions Fifth Wheel
Page 111 and 112:
Operating Instructions Vehicle Reco
Page 113 and 114:
Operating Instructions Vehicle Reco
Page 115 and 116:
Operating Instructions Introduction
Page 117 and 118:
Page 119 and 120:
Preventive Maintenance • When wor
Page 121 and 122:
Preventive Maintenance MAINTENANCE
Page 123 and 124:
Preventive Maintenance Maintenance
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Preventive Maintenance Lubrication
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Preventive Maintenance ENGINE MAINT
Page 143 and 144:
Preventive Maintenance NOTE: To exp
Page 145 and 146:
Preventive Maintenance To Check the
Page 147 and 148:
Preventive Maintenance Engine Cooli
Page 149 and 150:
Preventive Maintenance 8. Idle the
Page 151 and 152:
Preventive Maintenance BRAKE SYSTEM
Page 153 and 154:
Preventive Maintenance • Do not u
Page 155 and 156:
Preventive Maintenance Constant man
Page 157 and 158:
Preventive Maintenance Make sure th
Page 159 and 160:
Preventive Maintenance Visually ins
Page 161 and 162:
Preventive Maintenance Brake System
Page 163 and 164:
Preventive Maintenance Scheduled Ma
Page 165 and 166:
Preventive Maintenance CAUTION: Do
Page 167 and 168:
Preventive Maintenance head. Also,
Page 169 and 170:
Preventive Maintenance High Frequen
Page 171 and 172:
Preventive Maintenance Introduction
Page 173 and 174: Preventive Maintenance Tire Inflati
Page 175 and 176: Preventive Maintenance Wheel Mounti
Page 177 and 178: Preventive Maintenance Tires and Wh
Page 179 and 180: Preventive Maintenance Tires and Wh
Page 181 and 182: Preventive Maintenance Wheel and Ti
Page 183 and 184: Preventive Maintenance CAUTION: Dur
Page 185 and 186: Preventive Maintenance All the elec
Page 187 and 188: Preventive Maintenance Overcharge:
Page 189 and 190: Preventive Maintenance before proce
Page 191 and 192: Preventive Maintenance • When fas
Page 193 and 194: Preventive Maintenance Electrical a
Page 195 and 196: Preventive Maintenance Cleaning, Pr
Page 197 and 198: Preventive Maintenance At least eve
Page 199 and 200: Preventive Maintenance • Remove s
Page 201 and 202: Preventive Maintenance Cab Maintena
Page 203 and 204: Preventive Maintenance Cab Maintena
Page 205 and 206: Preventive Maintenance Transmission
Page 207 and 208: Preventive Maintenance Automatic Tr
Page 209 and 210: Preventive Maintenance Steering and
Page 211 and 212: Preventive Maintenance Front Axle a
Page 213 and 214: Preventive Maintenance Torque CAUTI
Page 215 and 216: Preventive Maintenance It is import
Page 217 and 218: Preventive Maintenance Rear Axle an
Page 219 and 220: Preventive Maintenance Grade 8 Caps
Page 221 and 222: Preventive Maintenance Fifth Wheel
Page 223: Preventive Maintenance Engine • R
Page 227 and 228: Preventive Maintenance Noise and Em
Page 229 and 230: Preventive Maintenance Vehicle Iden
Page 231 and 232: Preventive Maintenance Consumer Inf
Page 233 and 234: Preventive Maintenance Federal Safe
Page 235 and 236: Index fan drive 222 operating the c
Page 237 and 238: Lubrication 150, 210 axle 209 brake
Page 239 and 240: Turbocharger 114, 166 Turn signal/h
Page 241: 1 7 13 18 44 56 57 113 221 222 227
show all

Peterbilt Medium Duty Trucks Operator's Manual after 1-07

Create successful ePaper yourself

Delete template?

Save as template?