Volume 2 - Atomic Energy Regulatory Board

More documents

Recommendations

Info

APPENDIX-1 (Refer section 2.2) INDUSTRIAL SAFETY In the department of atomic energy (DAE) units AERB is responsible for enforcement of the Factories Act, 1948 and the Atomic Energy (Factories) Rules, 1996. Competent persons and safety officers are required to be appointed to carry out duties as mentioned in the above statutes. For fire safety both manpower and fire fighting equipment are required to be provided as per AERB safety standard for ‘Fire Protection Systems of Nuclear Facilities’ [AERB/ NF/SS/FPS (Rev. 1)]. All fire fighting equipment should be inspected and tested periodically as stipulated in the standard. Pressure vessels and vacuum systems should be periodically inspected and tested as specified in the Atomic Energy (Factories) Rules, 1996 and should carry necessary certification from a competent person. Handling and storage of gas cylinders should be as per gas cylinder rules. All hoists, lifts and lifting tackles should be subjected to periodic inspection and testing and should be certified by a competent person. All moving machinery should be provided with protective guard. Periodic calibration of monitoring instruments and preventive maintenance of all the machinery and equipment should be done. Noise in the work areas should be monitored and appropriate remedial measures/ personal protective equipment (PPE) should be used. Appropriate lighting should be provided in the working areas and illumination should be measured. For noise and illumination, requirement as specified in the Atomic Energy (Factories) Rules, 1996 should be adhered to. First aid provision should be available in the facility along with appropriate staff trained in first aid. Pre-employment medical examination and periodic medical examination should be carried out and the periodicity should be as specified in the Atomic Energy (Factories) Rules, 1996. Pipelines should be colour coded as per Indian standard: 2379-1963 and Indian Standard: 5-1978. Electrical conduit panels should be colour coded as per Indian Standard: 375-1951 and Indian Standard: 5-1978. All construction should conform to National Building Code of bureau of indian standards (BIS) and relevant AERB documents. All ladders should be maintained as per the requirements mentioned in the Atomic Energy (Factories) Rules, 1996. Material safety data sheet should be available for all hazardous chemicals handling and necessary personal protective equipment conforming to relevant Indian Standards should be provided to the workers exposed to hazards. Hand tools and portable power 87
tools should conform to the relevant BIS standards and should be used as per the requirements specified in the Atomic Energy (Factories) Rules, 1996. Work environment and the neighbourhood should be monitored for physical, chemical and biological agents and see that the limits specified by the Acts and Competent Authority are not exceeded at any time. 88
Page 1 and 2:
GUIDE NO. AERB/RF/SG/G-3 (Vol. 2 of
Page 3 and 4:
4. Performance of Safety System/Int
Page 5 and 6:
APPENDIX-3D-I & II (Refer section 3
Page 7 and 8:
APPENDIX-3D-III (Refer section 3.7.
Page 9 and 10:
APPENDIX-3E (Refer section 3.2.2.5
Page 11 and 12:
APPENDIX-3F (Refer sections 3.2.2.3
Page 13 and 14:
1.6 Non-conformance Control and Cor
Page 15 and 16:
and that of product specifications.
Page 17 and 18:
4. Hazard Assessment (a) (b) (c) (d
Page 19 and 20:
(h) 4. Safety Analysis (a) (b) (c)
Page 21 and 22:
APPENDIX-4C (Refer section 3.3.4) F
Page 23 and 24:
APPENDIX-4F (Refer section 3.3.2 to
Page 25 and 26:
established which includes the arra
Page 27 and 28:
conditions adverse to quality, such
Page 29 and 30:
B.3.2 (d) report (ATR), and radiati
Page 31 and 32:
for review and disposition of non-c
Page 33 and 34:
Leakage radiation and other paramet
Page 35 and 36:
- Dose rate profiles anticipated at
Page 37 and 38:
other action to be taken (e.g. Ozon
Page 39 and 40:
APPENDIX-5D (Refer section 3.4.1.4)
Page 41 and 42:
(c) (d) (e) (f) (g) (h) (i) (j) Fac
Page 43 and 44:
(b) Structural design: Seismic and
Page 45 and 46:
20. Pre-operational radiation surve
Page 47 and 48:
APPENDIX-5E (Refer section 3.4.1.4)
Page 49 and 50:
APPENDIX-5F (Refer section 3.4.1.3,
Page 51 and 52:
A.3.2 A.3.3 control of documents sh
Page 53 and 54:
A.7. for review and disposition of
Page 55 and 56:
B.3.2 (b) (c) (d) Document release
Page 57 and 58:
Page 59 and 60:
(c) (d) (iii) (iv) (v) (vi) (vii) (
Page 61 and 62:
APPENDIX-6B (Refer section 3.4.3.3)
Page 63 and 64: - Dose rate profiles anticipated at
Page 65 and 66: - Prevention of accidental fall of
Page 67 and 68: - Type of detectors used and their
Page 69 and 70: APPENDIX-6D (Refer section 3.4.3.4)
Page 71 and 72: - Dose rate profiles anticipated at
Page 73 and 74: - Prevention of accidental fall of
Page 75 and 76: - Type of detectors used and their
Page 77 and 78: Provisions including adequate finan
Page 79 and 80: Price Order for this guide should b
Page 81 and 82: such as industrial safety and envir
Page 83 and 84: Betatron An electron accelerator in
Page 85 and 86: Manufacture, possess, store, use, t
Page 87 and 88: adioactive substances and has an ac
Page 89 and 90: Treatment Simulation Methods by whi
Page 91 and 92: CONTENTS FOREWORD .................
Page 93 and 94: 3.3.8 Lead Time for Submission/Avai
Page 95 and 96: 3.8.3 Construction ................
Page 97 and 98: 3.15.2 Procurement and Registration
Page 99 and 100: FUNCTIONAL PERFORMANCE OF SAFETY SY
Page 101 and 102: APPENDIX-5E (Refer section 3.4.1.4)
Page 103 and 104: GAMMA RADIATION PROCESSING FACILITY
Page 105 and 106: FACILITY FOR RADIATION TECHNOLOGY (
Page 107 and 108: ANNEXURE-33b APPLICATION FOR PROCUR
Page 109 and 110: BIOMEDICAL RESEARCH STUDIES ON HUMA
Page 111 and 112: ANNEXURE-59 APPLICATION FOR NO (3.1
Page 113: VOLUME - 2
Page 117 and 118: (c) (d) (ii) (iii) (iv) (v) (vi) (v
Page 119 and 120: APPENDIX-2B (Refer section 3.2.1.3)
Page 121 and 122: - Overhead water storage tank detai
Page 123 and 124: - Ozone concentration (maximum) ant
Page 125 and 126: APPPENDIX-2C (Refer section 3.2.1.4
Page 127 and 128: 1. SAFETY SYSTEMS/INTERLOCKS (CONTD
Page 129 and 130: 2. AREA/ZONE MONITORS S. No. 1. 2.
Page 131 and 132: 3. EMERGENCY WATER LEVEL SENSOR (CO
Page 133 and 134: 5 (i) SEARCH OPERATION - 1 (Hydraul
Page 135 and 136: S. No. 1. 2. 3. 4. 5. 6. Audio / Co
Page 137 and 138: the design, statement declaring com
Page 139 and 140: - Gravity/accidental fall of rack i
Page 141 and 142: 5. Design Basis Accident Analysis A
Page 143 and 144: h. Quantity of activity : —— PB
Page 145 and 146: APPENDIX-2E (Refer section 3.2.1.4)
Page 147 and 148: F. EMERGENCY PLANNING AND PROCEDURE
Page 149 and 150: (g) (h) 1.2 Organisation The need t
Page 151 and 152: (i) (ii) (iii) 1.3 Interfaces Ensur
Page 153 and 154: (iii) (iv) (v) (vi) All constructio
Page 155 and 156: Standards to which the accelerator
Page 157 and 158: (b) Accelerator facility (c ) Elect
Page 159 and 160: 15. Details of Disposal Procedures
Page 161 and 162: Details of beam energy and current
Page 163 and 164: (h) Laboratory, workshops, stores e
Page 165 and 166:
(i) (ii) (iii) (iv) (v) (vi) During
Page 167 and 168:
4. Documentation Detail Design Deta
Page 169 and 170:
8. Normal and Emergency Operation P
Page 171 and 172:
4. Performance of Safety System/Int
Page 173 and 174:
APPENDIX-3D-I & II (Refer section 3
Page 175 and 176:
APPENDIX-3D-III (Refer section 3.7.
Page 177 and 178:
APPENDIX-3E (Refer section 3.2.2.5
Page 179 and 180:
APPENDIX-3F (Refer sections 3.2.2.3
Page 181 and 182:
1.6 Non-conformance Control and Cor
Page 183 and 184:
and that of product specifications.
Page 185 and 186:
4. Hazard Assessment (a) (b) (c) (d
Page 187 and 188:
(h) 4. Safety Analysis (a) (b) (c)
Page 189 and 190:
APPENDIX-4C (Refer section 3.3.4) F
Page 191 and 192:
APPENDIX-4F (Refer section 3.3.2 to
Page 193 and 194:
established which includes the arra
Page 195 and 196:
conditions adverse to quality, such
Page 197 and 198:
B.3.2 (d) report (ATR), and radiati
Page 199 and 200:
Page 201 and 202:
Leakage radiation and other paramet
Page 203 and 204:
Page 205 and 206:
other action to be taken (e.g. Ozon
Page 207 and 208:
Page 209 and 210:
(c) (d) (e) (f) (g) (h) (i) (j) Fac
Page 211 and 212:
(b) Structural design: Seismic and
Page 213 and 214:
20. Pre-operational radiation surve
Page 215 and 216:
APPENDIX-5E (Refer section 3.4.1.4)
Page 217 and 218:
APPENDIX-5F (Refer section 3.4.1.3,
Page 219 and 220:
A.3.2 A.3.3 control of documents sh
Page 221 and 222:
A.7. for review and disposition of
Page 223 and 224:
B.3.2 (b) (c) (d) Document release
Page 225 and 226:
Page 227 and 228:
(c) (d) (iii) (iv) (v) (vi) (vii) (
Page 229 and 230:
APPENDIX-6B (Refer section 3.4.3.3)
Page 231 and 232:
Page 233 and 234:
- Prevention of accidental fall of
Page 235 and 236:
- Type of detectors used and their
Page 237 and 238:
Page 239 and 240:
Page 241 and 242:
- Prevention of accidental fall of
Page 243 and 244:
- Type of detectors used and their
Page 245 and 246:
Provisions including adequate finan
Page 247 and 248:
(b) Contamination monitoring - On l
Page 249 and 250:
1.3 Organisation The responsible or
Page 251 and 252:
(ii) (iii) 1.4 Interfaces Ensuring
Page 253 and 254:
1.6 Accident statistics should be m
Page 255 and 256:
adiation zone monitors and radiatio
Page 257 and 258:
(APPENDIX 8C-I, 8C-II, 8C-III AND 8
Page 259 and 260:
2. Pre-patient/post-patient collima
Page 261 and 262:
APPENDIX-8C-I (Refer section 3.6.3)
Page 263 and 264:
C.3 Measurement of Timer Linearity
Page 265 and 266:
Tolerance : ± 20% of the quoted va
Page 267 and 268:
(a) Shift in the edges of the radia
Page 269 and 270:
6. LINEARITY OF TIMER Operating par
Page 271 and 272:
(c) (d) Recommended performance sta
Page 273 and 274:
TABLE 3 : HVT AS A FUNCTION OF FILT
Page 275 and 276:
2.5 Locking facility of the compres
Page 277 and 278:
6. ACCELERATING VOLTAGE Result : Se
Page 279 and 280:
Result : Coefficient of linearity f
Page 281 and 282:
APPENDIX-8E (Refer section 3.6.3 )
Page 283 and 284:
(THIS IS THE ONLY APPENDIX FOR INDU
Page 285 and 286:
APPENDIX-10 (Refer section 3.18.1)
Page 287 and 288:
APPENDIX-10 (CONTD.) (Refer section
Page 289 and 290:
Containing Radioactive Substances
Page 291 and 292:
LIST OF PARTICIPANTS DRAFT DOCUMENT
Page 293 and 294:
ADVISORY COMMITTEE ON PREPARATION O
Page 295 and 296:
PROVISIONAL LIST OF CODES, GUIDES A
show all

Volume 2 - Atomic Energy Regulatory Board

Create successful ePaper yourself

Delete template?

Save as template?