Volume 2 - Atomic Energy Regulatory Board

More documents

Recommendations

Info

B. TECHNICAL DESCRIPTION OF THE INTEGRATED FACILITY FOR RADIATION TECHNOLOGY (IFRT) 1. Brief description of the facility 2. Design details : Design philosophy, defence-in-depth concept, redundancy. independence and diversity in the design, built-in-safety features provided in the design. 3. Site of installation of IFRT: Geotechnical and geological information, Field investigations, water table, weather, soil profile, laboratory investigations, allowable bearing pressure/safe bearing capacity, chemical analyses of water and soil, site lay out, documentary evidence of the ownership of the site, <strong>Regulatory</strong> Consent issued by AERB for site approval - Structural details - type and depth of foundation and precautions against flooding - Seismic considerations and IS Tec. doc. 1893 (curent revision) proposed to be followed for construction - Buildings and residential complexes, occupancy, etc. within 30m radius of the facility location; give layout and height of the adjacent tallest building in the vicinity of 100m. - Access roads to the facility : road strength and width to carry transport flasks containing radioation sources (culvert/ bridge, if any, on the way - specify) - Any additional information 4. Biological shield of hot cell - Sketch giving details of shielding wall surrounding the hot cell and its thickness, openings, voids, reinforcements, embedment etc. in the biological shield. - Sketch of low bay area design details - Shield material, density, quality assurance during construction - Maximum and minimum shield thickness, roof thickness 211
- Dose rate profiles anticipated at various locations: (maximum and minimum values). Indicate them on a sketch of the facility - control room, roof, access doors, openings and where personnel are expected to be stationed for work or otherwise. - Maximum dose rate anticipated at various locations : (Indicate also in a sketch) - Shielding thickness of lead glass window and its light transmission efficiency 5. Different systems of the high bay area and safety systems/interlocks 5.1 Hot cell - Design details of hot cell with drawing providing all dimensions - Details of SS lining inside wall of Hot cell and roof. Source cask handling crane Master slave manipulator (MSM) - Technical specification of components of EOT cranes to be installed for source cask handling - Details of mechanical arrangement (include drawing) of source handling cranes. - No. and locations of the cranes - Load carrying capacity of the crane, prevention of accidental fall of source cask from crane, Dimensions of wire used in crane. - Safety provisions for operational controls and interlocking mechanism. - Technical details of master-slave manipulator (MSM) - Operating procedures of MSM - Lifting capacity of MSM - Installation and testing procedures 5.2 Water pool - Detailed sketch or drawing of water pool for source storage showing dimensions, water proofing, lining details, penetrations, piping, 212
Page 1 and 2:
GUIDE NO. AERB/RF/SG/G-3 (Vol. 2 of
Page 3 and 4:
4. Performance of Safety System/Int
Page 5 and 6:
APPENDIX-3D-I & II (Refer section 3
Page 7 and 8:
APPENDIX-3D-III (Refer section 3.7.
Page 9 and 10:
APPENDIX-3E (Refer section 3.2.2.5
Page 11 and 12:
APPENDIX-3F (Refer sections 3.2.2.3
Page 13 and 14:
1.6 Non-conformance Control and Cor
Page 15 and 16:
and that of product specifications.
Page 17 and 18:
4. Hazard Assessment (a) (b) (c) (d
Page 19 and 20:
(h) 4. Safety Analysis (a) (b) (c)
Page 21 and 22:
APPENDIX-4C (Refer section 3.3.4) F
Page 23 and 24:
APPENDIX-4F (Refer section 3.3.2 to
Page 25 and 26:
established which includes the arra
Page 27 and 28:
conditions adverse to quality, such
Page 29 and 30:
B.3.2 (d) report (ATR), and radiati
Page 31 and 32:
for review and disposition of non-c
Page 33 and 34:
Leakage radiation and other paramet
Page 35 and 36:
- Dose rate profiles anticipated at
Page 37 and 38:
other action to be taken (e.g. Ozon
Page 39 and 40:
APPENDIX-5D (Refer section 3.4.1.4)
Page 41 and 42:
(c) (d) (e) (f) (g) (h) (i) (j) Fac
Page 43 and 44:
(b) Structural design: Seismic and
Page 45 and 46:
20. Pre-operational radiation surve
Page 47 and 48:
APPENDIX-5E (Refer section 3.4.1.4)
Page 49 and 50:
APPENDIX-5F (Refer section 3.4.1.3,
Page 51 and 52:
A.3.2 A.3.3 control of documents sh
Page 53 and 54:
A.7. for review and disposition of
Page 55 and 56:
B.3.2 (b) (c) (d) Document release
Page 57 and 58:
for review and disposition of non-c
Page 59 and 60:
(c) (d) (iii) (iv) (v) (vi) (vii) (
Page 61 and 62:
APPENDIX-6B (Refer section 3.4.3.3)
Page 63 and 64:
Page 65 and 66:
- Prevention of accidental fall of
Page 67 and 68:
- Type of detectors used and their
Page 69 and 70:
APPENDIX-6D (Refer section 3.4.3.4)
Page 71 and 72:
Page 73 and 74:
- Prevention of accidental fall of
Page 75 and 76:
- Type of detectors used and their
Page 77 and 78:
Provisions including adequate finan
Page 79 and 80:
Price Order for this guide should b
Page 81 and 82:
such as industrial safety and envir
Page 83 and 84:
Betatron An electron accelerator in
Page 85 and 86:
Manufacture, possess, store, use, t
Page 87 and 88:
adioactive substances and has an ac
Page 89 and 90:
Treatment Simulation Methods by whi
Page 91 and 92:
CONTENTS FOREWORD .................
Page 93 and 94:
3.3.8 Lead Time for Submission/Avai
Page 95 and 96:
3.8.3 Construction ................
Page 97 and 98:
3.15.2 Procurement and Registration
Page 99 and 100:
FUNCTIONAL PERFORMANCE OF SAFETY SY
Page 101 and 102:
Page 103 and 104:
GAMMA RADIATION PROCESSING FACILITY
Page 105 and 106:
FACILITY FOR RADIATION TECHNOLOGY (
Page 107 and 108:
ANNEXURE-33b APPLICATION FOR PROCUR
Page 109 and 110:
BIOMEDICAL RESEARCH STUDIES ON HUMA
Page 111 and 112:
ANNEXURE-59 APPLICATION FOR NO (3.1
Page 113 and 114:
VOLUME - 2
Page 115 and 116:
tools should conform to the relevan
Page 117 and 118:
(c) (d) (ii) (iii) (iv) (v) (vi) (v
Page 119 and 120:
APPENDIX-2B (Refer section 3.2.1.3)
Page 121 and 122:
- Overhead water storage tank detai
Page 123 and 124:
- Ozone concentration (maximum) ant
Page 125 and 126:
APPPENDIX-2C (Refer section 3.2.1.4
Page 127 and 128:
1. SAFETY SYSTEMS/INTERLOCKS (CONTD
Page 129 and 130:
2. AREA/ZONE MONITORS S. No. 1. 2.
Page 131 and 132:
3. EMERGENCY WATER LEVEL SENSOR (CO
Page 133 and 134:
5 (i) SEARCH OPERATION - 1 (Hydraul
Page 135 and 136:
S. No. 1. 2. 3. 4. 5. 6. Audio / Co
Page 137 and 138:
the design, statement declaring com
Page 139 and 140:
- Gravity/accidental fall of rack i
Page 141 and 142:
5. Design Basis Accident Analysis A
Page 143 and 144:
h. Quantity of activity : —— PB
Page 145 and 146:
Page 147 and 148:
F. EMERGENCY PLANNING AND PROCEDURE
Page 149 and 150:
(g) (h) 1.2 Organisation The need t
Page 151 and 152:
(i) (ii) (iii) 1.3 Interfaces Ensur
Page 153 and 154:
(iii) (iv) (v) (vi) All constructio
Page 155 and 156:
Standards to which the accelerator
Page 157 and 158:
(b) Accelerator facility (c ) Elect
Page 159 and 160:
15. Details of Disposal Procedures
Page 161 and 162:
Details of beam energy and current
Page 163 and 164:
(h) Laboratory, workshops, stores e
Page 165 and 166:
(i) (ii) (iii) (iv) (v) (vi) During
Page 167 and 168:
4. Documentation Detail Design Deta
Page 169 and 170:
8. Normal and Emergency Operation P
Page 171 and 172:
4. Performance of Safety System/Int
Page 173 and 174:
APPENDIX-3D-I & II (Refer section 3
Page 175 and 176:
APPENDIX-3D-III (Refer section 3.7.
Page 177 and 178:
APPENDIX-3E (Refer section 3.2.2.5
Page 179 and 180:
APPENDIX-3F (Refer sections 3.2.2.3
Page 181 and 182:
1.6 Non-conformance Control and Cor
Page 183 and 184:
and that of product specifications.
Page 185 and 186:
4. Hazard Assessment (a) (b) (c) (d
Page 187 and 188: (h) 4. Safety Analysis (a) (b) (c)
Page 189 and 190: APPENDIX-4C (Refer section 3.3.4) F
Page 191 and 192: APPENDIX-4F (Refer section 3.3.2 to
Page 193 and 194: established which includes the arra
Page 195 and 196: conditions adverse to quality, such
Page 197 and 198: B.3.2 (d) report (ATR), and radiati
Page 199 and 200: for review and disposition of non-c
Page 201 and 202: Leakage radiation and other paramet
Page 203 and 204: - Dose rate profiles anticipated at
Page 205 and 206: other action to be taken (e.g. Ozon
Page 207 and 208: APPENDIX-5D (Refer section 3.4.1.4)
Page 209 and 210: (c) (d) (e) (f) (g) (h) (i) (j) Fac
Page 211 and 212: (b) Structural design: Seismic and
Page 213 and 214: 20. Pre-operational radiation surve
Page 215 and 216: APPENDIX-5E (Refer section 3.4.1.4)
Page 217 and 218: APPENDIX-5F (Refer section 3.4.1.3,
Page 219 and 220: A.3.2 A.3.3 control of documents sh
Page 221 and 222: A.7. for review and disposition of
Page 223 and 224: B.3.2 (b) (c) (d) Document release
Page 225 and 226: for review and disposition of non-c
Page 227 and 228: (c) (d) (iii) (iv) (v) (vi) (vii) (
Page 229 and 230: APPENDIX-6B (Refer section 3.4.3.3)
Page 231 and 232: - Dose rate profiles anticipated at
Page 233 and 234: - Prevention of accidental fall of
Page 235 and 236: - Type of detectors used and their
Page 237: APPENDIX-6D (Refer section 3.4.3.4)
Page 241 and 242: - Prevention of accidental fall of
Page 243 and 244: - Type of detectors used and their
Page 245 and 246: Provisions including adequate finan
Page 247 and 248: (b) Contamination monitoring - On l
Page 249 and 250: 1.3 Organisation The responsible or
Page 251 and 252: (ii) (iii) 1.4 Interfaces Ensuring
Page 253 and 254: 1.6 Accident statistics should be m
Page 255 and 256: adiation zone monitors and radiatio
Page 257 and 258: (APPENDIX 8C-I, 8C-II, 8C-III AND 8
Page 259 and 260: 2. Pre-patient/post-patient collima
Page 261 and 262: APPENDIX-8C-I (Refer section 3.6.3)
Page 263 and 264: C.3 Measurement of Timer Linearity
Page 265 and 266: Tolerance : ± 20% of the quoted va
Page 267 and 268: (a) Shift in the edges of the radia
Page 269 and 270: 6. LINEARITY OF TIMER Operating par
Page 271 and 272: (c) (d) Recommended performance sta
Page 273 and 274: TABLE 3 : HVT AS A FUNCTION OF FILT
Page 275 and 276: 2.5 Locking facility of the compres
Page 277 and 278: 6. ACCELERATING VOLTAGE Result : Se
Page 279 and 280: Result : Coefficient of linearity f
Page 281 and 282: APPENDIX-8E (Refer section 3.6.3 )
Page 283 and 284: (THIS IS THE ONLY APPENDIX FOR INDU
Page 285 and 286: APPENDIX-10 (Refer section 3.18.1)
Page 287 and 288: APPENDIX-10 (CONTD.) (Refer section
Page 289 and 290:
Containing Radioactive Substances
Page 291 and 292:
LIST OF PARTICIPANTS DRAFT DOCUMENT
Page 293 and 294:
ADVISORY COMMITTEE ON PREPARATION O
Page 295 and 296:
PROVISIONAL LIST OF CODES, GUIDES A
show all

Volume 2 - Atomic Energy Regulatory Board

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?