Volume 2 - Atomic Energy Regulatory Board

More documents

Recommendations

Info

B. TECHNICAL DESCRIPTION OF THE INTEGRATED FACILITY FOR RADIATION TECHNOLOGY (IFRT) 1. Brief Description of the Facility 2. Design details : Design philosophy, defence-in-depth concept, redundancy. independence and diversity in the design, built-in-safety features provided in the design. 3. Site of Installation of IFRT : Geotechnical and geological information, Field investigations, water table, weather, soil profile, laboratory investigations, allowable bearing pressure/safe bearing capacity, chemical analyses of water and soil, site lay out, documentary evidence of the ownership of the site, <strong>Regulatory</strong> Consent issued by AERB for site approval - Structural details - type and depth of foundation and precautions against flooding - Seismic considerations and IS Tec. doc. proposed to be followed for construction - Buildings and residential complexes, occupancy, etc. within 30m radius of the facility location; give layout and height of the adjacent tallest building in the vicinity of 100 m. - Access roads to the facility : road strength and width to carry transport flasks containing radioation sources (culvert/bridge, if any, on the way - specify) - Any additional information 4. Biological Shield - Sketch giving details of shielding wall surrounding the hot cell and its thickness, openings, voids, reinforcements, embedment etc. in the biological shield. - Sketch of low bay area design details - Shield material, density, quality assurance during construction - Maximum and minimum shield thickness, roof thickness 203
- Dose rate profiles anticipated at various locations: (maximum and minimum values). Indicate them on a sketch of the facility - control room, roof, access doors, openings and where personnel are expected to be stationed for work or otherwise. - Maximum dose rate anticipated at various locations : (Indicate also in a sketch) - Shielding thickness of lead glass window and its light transmission efficiency 5. Different Systems of the High Bay Area and Safety Systems/Interlocks 5.1 Hot cell - Design details of Hot Cell with drawing providing all dimensions - Details of SS lining inside wall of Hot cell and roof. Source cask handling crane Master slave manipulator (MSM) - Technical specification of components of EOT cranes to be installed for source cask handling - Details of mechanical arrangement (include drawing) of source handling cranes. - No. and locations of the cranes - Load carrying capacity of the crane, prevention of source cask from crane, Dimensions of wire used in crane. - Safety provisions for operational controls and interlocking mechanism. - Technical details of master-slave manipulator (MSM) - Operating procedures of MSM - Lifting capacity of MSM - Installation and testing procedures 5.2 Water pool - Detailed sketch or drawing of water pool for source storage showing dimensions, water proofing, lining details, penetrations, piping, 204
Page 1 and 2:
GUIDE NO. AERB/RF/SG/G-3 (Vol. 2 of
Page 3 and 4:
4. Performance of Safety System/Int
Page 5 and 6:
APPENDIX-3D-I & II (Refer section 3
Page 7 and 8:
APPENDIX-3D-III (Refer section 3.7.
Page 9 and 10:
APPENDIX-3E (Refer section 3.2.2.5
Page 11 and 12: APPENDIX-3F (Refer sections 3.2.2.3
Page 13 and 14: 1.6 Non-conformance Control and Cor
Page 15 and 16: and that of product specifications.
Page 17 and 18: 4. Hazard Assessment (a) (b) (c) (d
Page 19 and 20: (h) 4. Safety Analysis (a) (b) (c)
Page 21 and 22: APPENDIX-4C (Refer section 3.3.4) F
Page 23 and 24: APPENDIX-4F (Refer section 3.3.2 to
Page 25 and 26: established which includes the arra
Page 27 and 28: conditions adverse to quality, such
Page 29 and 30: B.3.2 (d) report (ATR), and radiati
Page 31 and 32: for review and disposition of non-c
Page 33 and 34: Leakage radiation and other paramet
Page 35 and 36: - Dose rate profiles anticipated at
Page 37 and 38: other action to be taken (e.g. Ozon
Page 39 and 40: APPENDIX-5D (Refer section 3.4.1.4)
Page 41 and 42: (c) (d) (e) (f) (g) (h) (i) (j) Fac
Page 43 and 44: (b) Structural design: Seismic and
Page 45 and 46: 20. Pre-operational radiation surve
Page 47 and 48: APPENDIX-5E (Refer section 3.4.1.4)
Page 49 and 50: APPENDIX-5F (Refer section 3.4.1.3,
Page 51 and 52: A.3.2 A.3.3 control of documents sh
Page 53 and 54: A.7. for review and disposition of
Page 55 and 56: B.3.2 (b) (c) (d) Document release
Page 57 and 58: for review and disposition of non-c
Page 59 and 60: (c) (d) (iii) (iv) (v) (vi) (vii) (
Page 61: APPENDIX-6B (Refer section 3.4.3.3)
Page 65 and 66: - Prevention of accidental fall of
Page 67 and 68: - Type of detectors used and their
Page 69 and 70: APPENDIX-6D (Refer section 3.4.3.4)
Page 71 and 72: - Dose rate profiles anticipated at
Page 73 and 74: - Prevention of accidental fall of
Page 75 and 76: - Type of detectors used and their
Page 77 and 78: Provisions including adequate finan
Page 79 and 80: Price Order for this guide should b
Page 81 and 82: such as industrial safety and envir
Page 83 and 84: Betatron An electron accelerator in
Page 85 and 86: Manufacture, possess, store, use, t
Page 87 and 88: adioactive substances and has an ac
Page 89 and 90: Treatment Simulation Methods by whi
Page 91 and 92: CONTENTS FOREWORD .................
Page 93 and 94: 3.3.8 Lead Time for Submission/Avai
Page 95 and 96: 3.8.3 Construction ................
Page 97 and 98: 3.15.2 Procurement and Registration
Page 99 and 100: FUNCTIONAL PERFORMANCE OF SAFETY SY
Page 101 and 102: APPENDIX-5E (Refer section 3.4.1.4)
Page 103 and 104: GAMMA RADIATION PROCESSING FACILITY
Page 105 and 106: FACILITY FOR RADIATION TECHNOLOGY (
Page 107 and 108: ANNEXURE-33b APPLICATION FOR PROCUR
Page 109 and 110: BIOMEDICAL RESEARCH STUDIES ON HUMA
Page 111 and 112: ANNEXURE-59 APPLICATION FOR NO (3.1
Page 113 and 114:
VOLUME - 2
Page 115 and 116:
tools should conform to the relevan
Page 117 and 118:
(c) (d) (ii) (iii) (iv) (v) (vi) (v
Page 119 and 120:
APPENDIX-2B (Refer section 3.2.1.3)
Page 121 and 122:
- Overhead water storage tank detai
Page 123 and 124:
- Ozone concentration (maximum) ant
Page 125 and 126:
APPPENDIX-2C (Refer section 3.2.1.4
Page 127 and 128:
1. SAFETY SYSTEMS/INTERLOCKS (CONTD
Page 129 and 130:
2. AREA/ZONE MONITORS S. No. 1. 2.
Page 131 and 132:
3. EMERGENCY WATER LEVEL SENSOR (CO
Page 133 and 134:
5 (i) SEARCH OPERATION - 1 (Hydraul
Page 135 and 136:
S. No. 1. 2. 3. 4. 5. 6. Audio / Co
Page 137 and 138:
the design, statement declaring com
Page 139 and 140:
- Gravity/accidental fall of rack i
Page 141 and 142:
5. Design Basis Accident Analysis A
Page 143 and 144:
h. Quantity of activity : —— PB
Page 145 and 146:
APPENDIX-2E (Refer section 3.2.1.4)
Page 147 and 148:
F. EMERGENCY PLANNING AND PROCEDURE
Page 149 and 150:
(g) (h) 1.2 Organisation The need t
Page 151 and 152:
(i) (ii) (iii) 1.3 Interfaces Ensur
Page 153 and 154:
(iii) (iv) (v) (vi) All constructio
Page 155 and 156:
Standards to which the accelerator
Page 157 and 158:
(b) Accelerator facility (c ) Elect
Page 159 and 160:
15. Details of Disposal Procedures
Page 161 and 162:
Details of beam energy and current
Page 163 and 164:
(h) Laboratory, workshops, stores e
Page 165 and 166:
(i) (ii) (iii) (iv) (v) (vi) During
Page 167 and 168:
4. Documentation Detail Design Deta
Page 169 and 170:
8. Normal and Emergency Operation P
Page 171 and 172:
4. Performance of Safety System/Int
Page 173 and 174:
APPENDIX-3D-I & II (Refer section 3
Page 175 and 176:
APPENDIX-3D-III (Refer section 3.7.
Page 177 and 178:
APPENDIX-3E (Refer section 3.2.2.5
Page 179 and 180:
APPENDIX-3F (Refer sections 3.2.2.3
Page 181 and 182:
1.6 Non-conformance Control and Cor
Page 183 and 184:
and that of product specifications.
Page 185 and 186:
4. Hazard Assessment (a) (b) (c) (d
Page 187 and 188:
(h) 4. Safety Analysis (a) (b) (c)
Page 189 and 190:
APPENDIX-4C (Refer section 3.3.4) F
Page 191 and 192:
APPENDIX-4F (Refer section 3.3.2 to
Page 193 and 194:
established which includes the arra
Page 195 and 196:
conditions adverse to quality, such
Page 197 and 198:
B.3.2 (d) report (ATR), and radiati
Page 199 and 200:
for review and disposition of non-c
Page 201 and 202:
Leakage radiation and other paramet
Page 203 and 204:
- Dose rate profiles anticipated at
Page 205 and 206:
other action to be taken (e.g. Ozon
Page 207 and 208:
APPENDIX-5D (Refer section 3.4.1.4)
Page 209 and 210:
(c) (d) (e) (f) (g) (h) (i) (j) Fac
Page 211 and 212:
(b) Structural design: Seismic and
Page 213 and 214:
20. Pre-operational radiation surve
Page 215 and 216:
APPENDIX-5E (Refer section 3.4.1.4)
Page 217 and 218:
APPENDIX-5F (Refer section 3.4.1.3,
Page 219 and 220:
A.3.2 A.3.3 control of documents sh
Page 221 and 222:
A.7. for review and disposition of
Page 223 and 224:
B.3.2 (b) (c) (d) Document release
Page 225 and 226:
for review and disposition of non-c
Page 227 and 228:
(c) (d) (iii) (iv) (v) (vi) (vii) (
Page 229 and 230:
APPENDIX-6B (Refer section 3.4.3.3)
Page 231 and 232:
Page 233 and 234:
- Prevention of accidental fall of
Page 235 and 236:
- Type of detectors used and their
Page 237 and 238:
APPENDIX-6D (Refer section 3.4.3.4)
Page 239 and 240:
Page 241 and 242:
- Prevention of accidental fall of
Page 243 and 244:
- Type of detectors used and their
Page 245 and 246:
Provisions including adequate finan
Page 247 and 248:
(b) Contamination monitoring - On l
Page 249 and 250:
1.3 Organisation The responsible or
Page 251 and 252:
(ii) (iii) 1.4 Interfaces Ensuring
Page 253 and 254:
1.6 Accident statistics should be m
Page 255 and 256:
adiation zone monitors and radiatio
Page 257 and 258:
(APPENDIX 8C-I, 8C-II, 8C-III AND 8
Page 259 and 260:
2. Pre-patient/post-patient collima
Page 261 and 262:
APPENDIX-8C-I (Refer section 3.6.3)
Page 263 and 264:
C.3 Measurement of Timer Linearity
Page 265 and 266:
Tolerance : ± 20% of the quoted va
Page 267 and 268:
(a) Shift in the edges of the radia
Page 269 and 270:
6. LINEARITY OF TIMER Operating par
Page 271 and 272:
(c) (d) Recommended performance sta
Page 273 and 274:
TABLE 3 : HVT AS A FUNCTION OF FILT
Page 275 and 276:
2.5 Locking facility of the compres
Page 277 and 278:
6. ACCELERATING VOLTAGE Result : Se
Page 279 and 280:
Result : Coefficient of linearity f
Page 281 and 282:
APPENDIX-8E (Refer section 3.6.3 )
Page 283 and 284:
(THIS IS THE ONLY APPENDIX FOR INDU
Page 285 and 286:
APPENDIX-10 (Refer section 3.18.1)
Page 287 and 288:
APPENDIX-10 (CONTD.) (Refer section
Page 289 and 290:
Containing Radioactive Substances
Page 291 and 292:
LIST OF PARTICIPANTS DRAFT DOCUMENT
Page 293 and 294:
ADVISORY COMMITTEE ON PREPARATION O
Page 295 and 296:
PROVISIONAL LIST OF CODES, GUIDES A
show all

Volume 2 - Atomic Energy Regulatory Board

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?