Untitled - Sciencemadness Dot Org

More documents

Recommendations

Info

PBX 9011 1. GENERAL PROPERTIES 1.1 Chemical and Physical Description. PBX 9011 is composed of HMX bonded with Estane 5703. The molding powder is off-white to light brown. 1.2 Common Use. PBX 9011 is a high-performance explosive that is used in a variety of special applications in nuclear ordnance. 1.3 Toxicity.’ Estane 5703 is not toxic. The suggested maximum concentration of HMX in air is 1.5 mg/ma. 2. MANUFACTURE AND PROCUREMENT 2.1 Manufacture. PBX-9011 molding powder is prepared by the water slurry process. An Estane lacquer is prepared in a water-immiscible solvent. This is added to a water slurry containing a bimodal distribution of HMX crystals. During solvent removal by distillation, the plastic uniformly coats and agglomerates the HMX crystals in the water phase. The process variables must be controlled closely to produce satisfactory agglomerates, composition, and bulk density. 72
PBX 9011 2.2 Procurement. PBX 9011 is purchased from the US Army Armament Readiness Command under LASL material specification 13Y-101030 Rev. B, dated January 9,1967. 2.3 Shipping.2 PBX-9011 molding powder is shipped as a Class A explosive. 2.4 Storage.a PBX 9011 is stored in Compatibility Group D, Storage Class 1.1. 3. CHEMICAL PROPERTIES 3.1 Composition. 3.2 Molecular Weight. Constituent HMX Estane 5703 Weight Volume Percent Percent 90 10 84.9 15.1 Constituent Structure Molecular Weight HMX 296.17 0 0 0 Estane HO-(CH2)4-0 [~-O-(CH2)q-O]n--d;-(-$~-~-~-C- m 100.0 H 73
Page 2 and 3:
LOS ALAMOS SERIES ON DYNAMIC MATERI
Page 4 and 5:
University of California Press Berk
Page 6 and 7:
PART II. EXPLOSIVES PROPERTIES BY P
Page 8 and 9:
treats pure explosives first, alpha
Page 10 and 11:
EXPLOSIVES PROPERTIES BY EXPLOSIVE
Page 12 and 13:
BARATOL 2.3 Shipping.2 Baratol is s
Page 14 and 15:
BARATOL 6 5.4 Thermal Conductivity.
Page 16 and 17:
BARATOL 6.2 Detonation Pressure. We
Page 18 and 19:
BARATOL REFERENCES . . 1. N. I. Sax
Page 20 and 21:
COMP B slowly. Heating and stirring
Page 22 and 23:
COMP B 14 3.3 Solubility.‘The sol
Page 24 and 25:
COMP B 16 5.3 Heat Capacity. Heat C
Page 26 and 27:
COMP B 18 6.2 Detonation Pressure.
Page 28 and 29:
COMP B 7.3 Shock Hugoniots.12J8 Com
Page 30 and 31: COMP B 9. MECHANICAL PROPERTIES 22
Page 32 and 33: CYCLOTOL 1. GENERAL PROPERTIES 1.1
Page 34 and 35: CYCLOTOL 26 3.2 Molecular Weight. C
Page 36 and 37: CYCLOTOL 4.3 Infrared Spectrum. See
Page 38 and 39: CYCLOTOL where D = detonation veloc
Page 40 and 41: CYCLOTOL 8.3 Skid Test Results. Den
Page 42 and 43: DATB 1. GENERAL PROPERTIES 1.1 Chem
Page 44 and 45: DATB 4. PHYSICAL PROPERTIES 4.1 Cry
Page 46 and 47: DATB 5.4 Thermal Conductivity, Cond
Page 48 and 49: DATB 7.3 Shock Hugoniot.9 Density k
Page 50 and 51: HMX* 1. GENERAL PROPERTIES 1.1 Chem
Page 52 and 53: HMX 3.2 Molecular Weight. 296.17 3.
Page 54 and 55: HMX 5. THERMAL PROPERTIES 46 5.1 Ph
Page 56 and 57: HMX 6. DETONATION PROPERTIES 6.1 De
Page 58 and 59: HMX 7.3 Shock Hugoniots.” Density
Page 60 and 61: NITROGUANIDINE 1. GENERAL PROPERTIE
Page 62 and 63: NQ 54 4.2 Density.’ Crystal Metho
Page 64 and 65: NQ 56 5.6 Heats of Combustion and F
Page 66 and 67: NQ 6.2 Detonation Pressure. There a
Page 68 and 69: NQ 8. SENSITIVITY 8.1 Drop Weight I
Page 70 and 71: OCTOL These are shipped to an ordna
Page 72 and 73: 64 OCTOL 3.3 Solubility.6 The solub
Page 74 and 75: OCTOL 5. THERMAL PROPERTIES 66 5.1
Page 76 and 77: OCTOL 68 6.4 Plate Dent Test Result
Page 78 and 79: OCTOL 8.3 Skid Test Results. Weight
Page 82 and 83: PBX 9011 3.3 Solubility. The solubi
Page 84 and 85: PBX 9011 76 5.5 Coefficient of Ther
Page 86 and 87: PBX 9011 78 6.3 Cylinder Test Resul
Page 88 and 89: PBX 9011 7.5 Detonation Failure Thi
Page 90 and 91: PBX 9011 82 9.3 Compressive Strengt
Page 92 and 93: PBX9404 1. GENERAL PROPERTIES 1.1 C
Page 94 and 95: PBX 9404 86 3.2 Molecular Weight. C
Page 96 and 97: PBX 9404 88 4.3 Infrared Spectrum.
Page 98 and 99: PBX 9404 > 1 1 o- r 0 I I I, / PYRO
Page 100 and 101: PBX 9404 7. SHOCK INITIATION PROPER
Page 102 and 103: PBX 9404 7.5 Detonation Failure Thi
Page 104 and 105: PBX 9404 8.5 Spark Sensitivity. Ele
Page 106 and 107: PBX 9404 REFERENCE‘S 1. Committee
Page 108 and 109: PBX 9407 2.3 Shipping.2 PBX-9407 mo
Page 110 and 111: PBX 9407 4.3 Infrared Spectrum. See
Page 112 and 113: PBX 9407 6. DETONATION PROPERTIES I
Page 114 and 115: PBX 9407 106 7.2 Wedge Test Results
Page 116 and 117: PBX 9407 9.3 Compressive Strength a
Page 118 and 119: PBX 9501 2.3 Shipping.* PBX-9501mol
Page 120 and 121: PBX 9501 5. THERMAL PROPERTIES 112
Page 122 and 123: PBX 9501 6. DETONATION PROPERTIES 6
Page 124 and 125: PBX 9501 7.3 Shock Hugoniot. Densit
Page 126 and 127: PBX 9501 9. MECHANICAL PROPERTIES*
Page 128 and 129: PBX9502 1. GENERAL PROPERTIES 1.1 C
Page 130 and 131:
PBX 9502 3.3 Solubility. The solubi
Page 132 and 133:
PBX 9502 124 5.3 Heat Capacity. 5.4
Page 134 and 135:
PBX 9502 6.3 Cylinder Test Results.
Page 136 and 137:
PBX 9502 9. MECHANICAL PROPERTIES 1
Page 138 and 139:
PENTAERYTHRITOLTETRANITRATE (PETN)
Page 140 and 141:
PETN 3.2 Molecular Weight. 316.15 3
Page 142 and 143:
PETN 4.4 Refractive Indices.s Omega
Page 144 and 145:
PETN 5.7 Thermal Decomposition Kine
Page 146 and 147:
PETN 138 7.2 Wedge Test Results. De
Page 148 and 149:
, PETN 5. US Army Materiel Command,
Page 150 and 151:
RDX developed into a continuous hig
Page 152 and 153:
RDX 4. PHYSICAL PROPERTIES 4.1 Crys
Page 154 and 155:
RDX 146 5.2 Vapor Pressure.8 Temper
Page 156 and 157:
RDX 6. DETONATION PROPERTIES 148 6.
Page 158 and 159:
RDX 7.3 Shock Hugoniot.” 8. SENSI
Page 160 and 161:
TATB 1. GENERAL PROPERTIES 1.1 Chem
Page 162 and 163:
TATB TATB solubility in sulfuric ac
Page 164 and 165:
TATB 5.2 Vapor Pressure.6 A least s
Page 166 and 167:
TATB I / / I I I I I I I ! \ I 1 \
Page 168 and 169:
TATB 7.3 Shock Hugoniots.“+ A num
Page 170 and 171:
TATB REFERENCES 1. T. M Benziger an
Page 172 and 173:
TETRYL acetone. In the second proce
Page 174 and 175:
TETRYL 2.5 100 80 60 % T 40 20 0 :;
Page 176 and 177:
TETRYL 6. DETONATION PROPERTIES 6.1
Page 178 and 179:
TETRYL 7.5 Detonation Failure Thick
Page 180 and 181:
TNT 1. GENERAL PROPERTIES 1.1 Chemi
Page 182 and 183:
TNT 4. PHYSICAL PROPERTIES 4.1 Crys
Page 184 and 185:
TNT 4.3 Infrared Spectrum. See Fig.
Page 186 and 187:
TNT 178 5.5 Coefficient of Thermal
Page 188 and 189:
TNT The charge preparation method a
Page 190 and 191:
TNT 182 6.4 Plate Dent Test Results
Page 192 and 193:
TNT 7.3 Shock Hugoniots.2aJ4 Densit
Page 194 and 195:
TNT 9.3 Compressive Strength and Mo
Page 196 and 197:
XTX8003 1. GENERAL PROPERTIES 1.1 C
Page 198 and 199:
XTX 8003 3.3 Solubility.6 The solub
Page 200 and 201:
XTX 8003 5.7 Thermal Decomposition
Page 202 and 203:
XTX 8003 8. SENSITIVITY 8.1 Drop We
Page 204 and 205:
XTX8004 1. GENERAL PROPERTIES 1.1 C
Page 206 and 207:
XTX 8004 3.3 Solubility. The solubi
Page 208 and 209:
XTX 8004 6. DETONATION PROPERTIES 6
Page 210 and 211:
PART II EXPLOSIVES PROPERTIES BY IP
Page 212 and 213:
Explosive Alex/20 Alex/30 Amatex/20
Page 214 and 215:
Explosive PBX 9007 PBX 9010 PBX 901
Page 216 and 217:
Explosive Constituents X-0234-60 X-
Page 218 and 219:
Alex/20 Alex/30 Amatexl20 Amatexl30
Page 220 and 221:
NQ octo1 PAT0 Explosive PBX 9007 PB
Page 222 and 223:
X-0234-60 X-0234-70 X-0234-80 X-028
Page 224 and 225:
THERMAL PROPERTIES 2. THERMAL PROPE
Page 226 and 227:
THERMAL PROPERTIES k2 = kl - (4, -
Page 228 and 229:
Explosive PETN RDX TNT Table 2.03 C
Page 230 and 231:
THERMAL PROPERTIES AEE = standard i
Page 232 and 233:
THERMAL PROPERTIES Fig. 2.02. Pyrol
Page 234 and 235:
,’ THERMAL PROPERTIES L Y !s :: B
Page 236 and 237:
THERMAL PROPERTIES 228 Composition
Page 238 and 239:
THERMAL PROPERTIES B Y !3 E E “I
Page 240 and 241:
THERMAL PROPERTIES This assembly is
Page 242 and 243:
DETONATION PROPERTIES 3. DETONATION
Page 244 and 245:
DETONATION PROPERTIES 236 Table 3.0
Page 246 and 247:
Shot No. c-4394 E-4672 E-4067 E-406
Page 248 and 249:
DETONATION PROPERTIES Table 3.06 CY
Page 250 and 251:
Table 3.08 OCTOL DETONATION VELOCIT
Page 252 and 253:
Rate Stick Shot ’ Diameter No. (m
Page 254 and 255:
DETONATION PROPERTIES 246 Table 3.1
Page 256 and 257:
Shot No. C-4436 E-3621 - Rate Stick
Page 258 and 259:
Table 3.15 GENERAL CYLINDER TEST SH
Page 260 and 261:
DETONATION PROPERTIES 252 Expansion
Page 262 and 263:
Expansion Radius (mm) Table 3.19 X-
Page 264 and 265:
N VI UY Table 3.21 X-0285 WALL VELO
Page 266 and 267:
DETONATION PROPERTIES Table 3.25 X-
Page 268 and 269:
Explosive Table 3.26 DETONATION (C-
Page 270 and 271:
DETONATION PROPERTIES Analysis Line
Page 272 and 273:
DETONATION PROPERTIES Explosive Tab
Page 274 and 275:
Page 276 and 277:
Page 278 and 279:
Page 280 and 281:
Page 282 and 283:
Page 284 and 285:
Page 286 and 287:
Page 288 and 289:
DETONATION PROPERTIES 3.4 Plate Den
Page 290 and 291:
Exnlosive Table 3.46 (continued) De
Page 292 and 293:
Explosive PBX 9501 x-0007 86 HMX/14
Page 294 and 295:
85 RDX/lS Kel-F Explosive 88 RDXI12
Page 296 and 297:
DETONATION PROPERTIES Table 3.47 LE
Page 298 and 299:
DETONATION PROPERTIES Table 3.48 DE
Page 300 and 301:
SHOCK INITIATION PROPERTIES PETN Ba
Page 302 and 303:
SHOCK INITIATION PROPERTIES Fig. 4.
Page 304 and 305:
SHOCK INITIATION PROPERTIES each sh
Page 306 and 307:
SHOCK INITIATION’PROPERTIES Table
Page 308 and 309:
SHOCK INITIATION PROPERTIES 300 i;
Page 310 and 311:
w R Table 4.04 NITROMETHANE Composi
Page 312 and 313:
SHOCK INITIATION PROPERTIES 304 Tab
Page 314 and 315:
SHOCK INITIATION PROPERTIES 306 / D
Page 316 and 317:
SHOCK INITIATION PROPERTIES 308 2 0
Page 318 and 319:
Table 4.06 (continued) Coordinates
Page 320 and 321:
SHOCK INITIATION PROPERTIES 312 I-
Page 322 and 323:
Page 324 and 325:
SHOCK INITIATION PROPERTIES 316 05
Page 326 and 327:
Table 4.07 PETN (SINGLE CRYSTAL) Co
Page 328 and 329:
Table 4.08 (continued) Shot Number
Page 330 and 331:
Page 332 and 333:
SHOCK INITIATION PROPERTIES 324 2 u
Page 334 and 335:
Page 336 and 337:
SHOCK INITIATION PROPERTIES Table 4
Page 338 and 339:
Page 340 and 341:
Page 342 and 343:
SHOCK INITIATION PROPERTIES 334 2T
Page 344 and 345:
Page 346 and 347:
Page 348 and 349:
Initial Shock Parameters Table 4.12
Page 350 and 351:
SHOCK INITIATION PROPERTIES 342 Ini
Page 352 and 353:
Page 354 and 355:
3 *a i 8 3 x j > f m e c u,, = (2.3
Page 356 and 357:
SHOCK INITIATION PROPERTIES 348 Dis
Page 358 and 359:
w ul 0 Composition 95 wt% DATB, 5 w
Page 360 and 361:
SHOCK INITIATION PROPERTIES 5.5- 5.
Page 362 and 363:
5 Table 4.17 (continued) Coordinate
Page 364 and 365:
Page 366 and 367:
SHOCK INITIATION PROPERTIES 40- 20
Page 368 and 369:
Shot E-3120 3.370 $0.022 E-3131 2.4
Page 370 and 371:
_. Shot Number E-771 E-781 B-4481 B
Page 372 and 373:
SHOCK INITIATION PROPERTIES 364 2 I
Page 374 and 375:
SHOCK INITIATION PROPERTIES 366 0.6
Page 376 and 377:
Page 378 and 379:
SHOCK INITIATION PROPERTIES Composi
Page 380 and 381:
Table 4.21 X-0219-50-14-10 Composit
Page 382 and 383:
Page 384 and 385:
Composition 95 wt% NQ, 5 wt% Estane
Page 386 and 387:
Shot Number (G?a) E-3245 16.2 5.904
Page 388 and 389:
SHOCK INITIATION PROPERTIES 380 c x
Page 390 and 391:
w R Table 4.24 (continued) Reduced
Page 392 and 393:
Table 4.25 XTX-8003 (EXTEX) Composi
Page 394 and 395:
SHOCK INITIATION PROPERTIES 386 a--
Page 396 and 397:
Table 4.27 PBX 9407 Compositon 94 w
Page 398 and 399:
SHOCK INITIATION PROPERTIES 390 3 g
Page 400 and 401:
Table 4.28 PBX 9405 Cotiposition 93
Page 402 and 403:
SHOCK INITIATION PROPERTIES 394 c 5
Page 404 and 405:
% OY Table 4.30 x-0250-40-19 Compos
Page 406 and 407:
SHOCK INITIATION PROPERTIES 398 Dis
Page 408 and 409:
Table 4.32 95 TATB/2.5 Kel-F 800/2.
Page 410 and 411:
Page 412 and 413:
Page 414 and 415:
Page 416 and 417:
Table 4.39 (continued) Coordinates
Page 418 and 419:
Page 420 and 421:
Page 422 and 423:
z Table 4.44 FKM CLASS VII PROPELLA
Page 424 and 425:
Page 426 and 427:
Page 428 and 429:
Theoretical Maximum Density >1.910
Page 430 and 431:
Page 432 and 433:
Page 434 and 435:
Ammonium picrate Raratol(76/24) mix
Page 436 and 437:
HMX-Based PBX 9011 PBX 9404 PBX-950
Page 438 and 439:
SHOCK INITIATION PROPERTIES 0.360 c
Page 440 and 441:
SHOCK INITIATION PROPERTIES 432 I I
Page 442 and 443:
SHOCK INITIATION PROPERTIES Fig. 4.
Page 444 and 445:
SHOCK INITIATION PROPERTIES Explosi
Page 446 and 447:
Page 448 and 449:
SHOCK INITIATION PROPERTIES TRANSIT
Page 450 and 451:
SHOCK INITIATION PROPERTIES 442 FOI
Page 452 and 453:
Page 454 and 455:
SENSITIVITY TESTS 5. SENSITIVITY TE
Page 456 and 457:
Ammonium nitrate Ammonium picrate B
Page 458 and 459:
-’ .-- _- ..- _ “. Cyclotol75/2
Page 460 and 461:
Explosive RDX-Based with Metal Fill
Page 462 and 463:
SENSITIVITY TESTS 5.2 Skid Test. Th
Page 464 and 465:
Explosive Comp A-3 1.638 45 PBX 901
Page 466 and 467:
SENSITIVITY TESTS 5.3 Large-Scale D
Page 468 and 469:
SENSITIVITY TESTS 5.4 Spark Sensiti
Page 470 and 471:
GLOSSARY ABH Amatex-20 ATNI BDNPA B
Page 472 and 473:
NP OFHC ONT P-16 P-22 P-40 P-80 P-1
Page 474 and 475:
AUTHOR IND Ablard, J. E. 141, 151 A
Page 476 and 477:
SUBJECT INDEX ABH 461 Alex/20 204,
Page 478 and 479:
pentaerythritol tetranitrate (PETN)
show all

Untitled - Sciencemadness Dot Org

Create successful ePaper yourself

Delete template?

Save as template?