Cranfield University

More documents

Recommendations

Info

Laboratory Studies Into Undercarriage Systems 3.4 Interactions of Carriage System, Load, and Speed on Soil Displacement This Section contains interesting cross references between unlinked data originating from the evaluation of the influence of speed and the evaluation of the rear tyres on soil displacement. Figure 46 shows that a track at 12 t causes similar soil displacement as an implement tyre carrying about 1/3 of the load. Moreover, the soil displacement is reduced to zero at 500 mm depth for the track. This pronounces the overall ability of the TerraTrac to spread high payloads uniformly while causing a minimum amount of compaction. The TerraTrac car- ries 2.67 times the load of the implement tyres and causes the same soil displacement. This is very similar with the comparison the the T12-700 and 23-11 in Section 3.2.2 whereby the tracked undercarriage system carrying 33 t causes similar soil displacement as an 11 t wheeled combination. Depth (mm) 0 100 200 300 400 500 600 700 Displacement (mm) -10 0 10 20 30 40 50 60 70 Track 12t 500-85/4.5/1.4 600/4.5/1.4 700/4.5/1.0 Figure 46: Soil displacement vs. depth for implement tyres and the track at 12 t Figure 47 shows that three passes of a 900/5/0.5 tyre have the same impact on soil displacement as one pass at a much slower speed emphasizing the effect of speed on soil displacement. This again pronounces the potential damage to headlands where slow speeds are common. In this critical range from 0.29 m/s to 0.85 m/s a decrease of speed to approximately 1/3 increases soil displacement; consequently the increase in soil density results in the same amount as three passes of the same tyre at the higher speed. Fortunately for most of the field, speeds do not become as small. As Section 3.1.2 showed, for higher Ph.D. Thesis Dirk Ansorge (2007) LSD speeds the accompanying decrease is not as pronounced anymore. 58
Laboratory Studies Into Undercarriage Systems Depth (mm) 0 100 200 300 400 500 600 Displacement (mm) -10 0 10 20 30 40 50 60 One Pass at 0.29 m/s Three Passes at 0.85 m/s Figure 47: Soil displacement vs. depth for 900/5/0.5 at 0.29 m/s and after three passes at 0.85 m/s. 3.5 Conclusions on Soil Bin Laboratory Study � Experiments in the soil bin laboratory can be replicated when the same soil condi- tions and experimental setup is used. � The influence of speed on soil displacement could clearly be shown whereby the speed studied (0.85 m/s) resulted in a soil displacement approximately 20 % greater than typical harvest speeds (1.52 m/s). However, as this was the same for all such Ph.D. Thesis Dirk Ansorge (2007) LSD treatments it did not influence the conclusions drawn. � The benefit of tracks with respect to soil displacement, penetrometer resistance, and rut depth from Ansorge (2005, a) is maintained after the additional passage of the rear axle. � Tracked machinery caused significantly less soil displacement, rut depth and a strong decline in penetrometer resistance with depth compared to wheeled machines. � The size of the rear tyre was more crucial after a passage of a wheel on the front axle than after the passage of a track. � A tyre combination representing a combine harvester at 11 t on medium tyre size caused similar soil displacement compared to a tracked machine at 33 t. A dual and a hypothetical three axle machine caused similar soil displacement compared to a tracked machine. A tandem front axle machine causes intermediate soil displacement between tracked and wheeled machines. A machine on 4 equal sized tyres 59
Page 1 and 2:
Cranfield University School of Appl
Page 3 and 4:
Abstract Ancillary experiments show
Page 5 and 6:
Table of Contents TABLE OF CONTENTS
Page 7 and 8:
Table of Contents 4.1.3 Analysis of
Page 9 and 10:
Table of Contents 11.1.1.1 Comparis
Page 11 and 12:
List of Figures and Tables Figure 3
Page 13 and 14:
List of Figures and Tables Figure 1
Page 15 and 16:
Nomenclature NOMENCLATURE Abbreviat
Page 17 and 18:
Introduction 1 INTRODUCTION 1.1 Bac
Page 19 and 20:
Introduction � Ansorge, D. and Go
Page 21 and 22:
Introduction 1.2 Aim To elucidate t
Page 23 and 24: Introduction a) the soil compaction
Page 25 and 26: Experimental Methods 2.1.1.1 Test F
Page 27 and 28: Experimental Methods had been mount
Page 29 and 30: Experimental Methods track; the loa
Page 31 and 32: Experimental Methods 800/10.5/2.5 t
Page 33 and 34: Experimental Methods term. In the m
Page 35 and 36: Experimental Methods Soil Surface F
Page 37 and 38: Experimental Methods Depth (cm) 0 1
Page 39 and 40: Experimental Methods ence surface c
Page 41 and 42: Experimental Methods chine derives
Page 43 and 44: Experimental Methods depth. The dat
Page 45 and 46: Experimental Methods with water and
Page 47 and 48: Experimental Methods 2.4 Statistica
Page 49 and 50: Laboratory Studies Into Undercarria
Page 73: Laboratory Studies Into Undercarria
Page 77 and 78: Field Study With Full Size Combine
Page 99 and 100: Alleviation of Soil Compaction Howe
Page 101 and 102: Alleviation of Soil Compaction not
Page 103 and 104: Alleviation of Soil Compaction in a
Page 105 and 106: Alleviation of Soil Compaction diff
Page 107 and 108: Soil Compaction Models sibilities t
Page 109 and 110: Soil Compaction Models depends on t
Page 111 and 112: Soil Compaction Models Wroth (1968)
Page 113 and 114: Soil Compaction Models however, the
Page 115 and 116: Soil Compaction Models level. Criti
Page 117 and 118: Soil Compaction Models Utilizing Ke
Page 119 and 120: Soil Compaction Models average of m
Page 121 and 122: Soil Compaction Models Depth (mm) -
Page 123 and 124: Soil Compaction Models ture content
Page 125 and 126:
Soil Compaction Models with four ot
Page 127 and 128:
Soil Compaction Models Predicted In
Page 129 and 130:
Soil Compaction Models Depth (mm) -
Page 131 and 132:
Soil Compaction Models and 13.7 % b
Page 133 and 134:
Soil Compaction Models Rel. Density
Page 135 and 136:
Soil Compaction Models VCL paramete
Page 137 and 138:
Soil Compaction Models The approach
Page 139 and 140:
Soil Compaction Models surface stay
Page 141 and 142:
Soil Compaction Models This result
Page 143 and 144:
Soil Compaction Models 6.6.1.3 Wate
Page 145 and 146:
Soil Compaction Models σσ 1 (kPA)
Page 147 and 148:
Soil Compaction Models pressure to
Page 149 and 150:
Soil Compaction Models The response
Page 151 and 152:
Soil Compaction Models On medium so
Page 153 and 154:
Soil Compaction Models SOILFLEX tak
Page 155 and 156:
Ancillary Experiments 7 ANCILLARY E
Page 157 and 158:
Ancillary Experiments Average conta
Page 159 and 160:
Ancillary Experiments In order to c
Page 161 and 162:
Ancillary Experiments contrary, the
Page 163 and 164:
Ancillary Experiments Figure 102: S
Page 165 and 166:
Ancillary Experiments track and the
Page 167 and 168:
Ancillary Experiments even when hav
Page 169 and 170:
Ancillary Experiments 7.3.2 Influen
Page 171 and 172:
Ancillary Experiments The results f
Page 173 and 174:
Ancillary Experiments Figure 117: S
Page 175 and 176:
Ancillary Experiments Contact Press
Page 177 and 178:
Ancillary Experiments Figure 123: F
Page 179 and 180:
Ancillary Experiments Sinkage (mm)
Page 181 and 182:
Ancillary Experiments model which o
Page 183 and 184:
Ancillary Experiments 7.3.5 The Inf
Page 185 and 186:
Ancillary Experiments 7.3.7 Discuss
Page 187 and 188:
Ancillary Experiments Terzaghi (194
Page 189 and 190:
Ancillary Experiments contact area.
Page 191 and 192:
Ancillary Experiments soil forward
Page 193 and 194:
Conclusions � The longitudinal so
Page 195 and 196:
Bibliography 10 BIBLIOGRAPHY Aboaba
Page 197 and 198:
Bibliography Defossez, P., Richard,
Page 199 and 200:
Bibliography Gregory, A.S.; Whalley
Page 201 and 202:
Bibliography Lamande, M., Schjonnin
Page 203 and 204:
Bibliography Seig, D., 1985. Soil C
Page 205 and 206:
Appendix 11 APPENDIX Ph.D. Thesis D
Page 207 and 208:
Appendix Figure 32: VCL sample at t
Page 209 and 210:
Appendix comparison at the deepest
Page 211 and 212:
Appendix Estimated Pressure (kPa) 2
Page 213 and 214:
Appendix 11.1.1.2.1 SOCOMO One of t
Page 215 and 216:
Appendix by Seig (1985) who showed
Page 217 and 218:
Appendix Soil water content 15 % an
Page 219 and 220:
Appendix Adapting critical state so
Page 221 and 222:
Appendix density is obtained by add
Page 223 and 224:
Appendix Table 5: Values of constan
Page 225 and 226:
Appendix choice of a concentration
Page 227 and 228:
Appendix 11.1.3.1 Dense/Hard and Lo
Page 229 and 230:
Appendix 11.1.3.2 Stratified Soil C
Page 231 and 232:
Appendix To summarize the ability t
Page 233 and 234:
Appendix In the following the predi
Page 235 and 236:
Appendix concentration factor of 4,
Page 237 and 238:
Appendix 11.1.5.1 Confining Pressur
Page 239 and 240:
Appendix Figure 24. The VCL created
Page 241 and 242:
Appendix Rel. Density 2 1,9 1,8 1,7
Page 243 and 244:
Appendix relation of � 1 to � 2
Page 245 and 246:
Appendix Rel. Density 2 1,9 1,8 1,7
Page 247 and 248:
Appendix Rel. Density 1,7 1,68 1,66
Page 249 and 250:
Appendix Depth (mm) 0,0 100,0 200,0
Page 251 and 252:
Appendix Figure 42: Plate in cookin
Page 253 and 254:
Appendix � z � � �� k c p
Page 255 and 256:
Appendix Table 8: n and k depending
Page 257 and 258:
Appendix to the plate sinkage equat
Page 259 and 260:
Appendix with a slight deviation fr
Page 261:
Appendix Table 12: DBD values for a
show all

Cranfield University

Create successful ePaper yourself

Delete template?

Save as template?