h16tp(x - AJ Maskin AS

Repair manual10.1.1 -General operationANOMALY PROBABLE CAUSE SOLUTIONThe motor does not start, thestarter is activatedThe motor does not start, thestarter is not activatedThe motor starts, then stopsafter 5s.The motor does not startfrom the platform station butdoes start from the turntablestationThe motor does not startfrom the turntable station butdoes start from the platformstationNo motor acceleration regardlessof the movement controlledfrom the platformNo motor acceleration byactivating the acceleratorswitch SA2 on the turntablecontrol stationNo movement available (fromturntable or platform station)• Diesel tank empty• Fuse FU1 defective• Diesel supply circuit defective• Wiring defective• Module U1 defective• Stop motor solenoid YA1 defective• Emergency stop locked• Generator defective• Batteries defective• Fuses FU1, FU4 or FU8 defective• Wiring defective• Switch SB3 or SB4 defective• Relay KA2 defective• Diesel tank empty• Diesel supply circuit defective• Fuse FU6 defective• Defective connection of switch SB4• Switch SB4 defective• Wiring harness defective• Switch SB3 defective• Wiring harness defective• Electronic module U1 defective• Wiring harness defective• Fuse FU3 defective• Relay KT2 defective• Electronic module U1 defective• Wiring harness defective• Accelerator switch SA2 defective• Motor accelerator coil YA2 defective• Insufficient hydraulic oil• Fuse FU7 or FU4 or FU10 defective• Wiring harness defective• Electrovalve YV1 defective• Incorrect "Load sensing" pressure setting• Motor-pump coupling defective• Hydraulic pump defective• Pressure limiter defective• Distribution block input module defective• Pump regulation unit incorrectly set or defective• Hydraulic pump defective• Electronic module U1 defective• Relay KMG defective• Printed circuit defective• Key switch SA1 defectiveFiche DP015Fiche DP016Fiche DP041Fiche DP019Fiche DP020Fiche DP021Fiche DP022Fiche DP02368