Daelim B-Bone 125cc service manual.pdf - Mojo

More documents

Recommendations

Info

REAR WHEEL/SUSPENSION/REAR SWING ARM TROUBLESHOOTING Wobble or vibration in motorcycle ● Bent wheel tire ● Faulty tire ● Axle not tightened properly ● Insufficient air in tire ● Wheel out of balance Soft suspension ● Weak springs ● Rear damper improperly adjusted, oil leakage Hard suspension ● Rear damper improperly adjusted ● Bent shock absorber rod Suspension noise ● Loose fasteners ● Worn shock 14-2
REAR WHEEL/SUSPENSION/REAR SWING ARM REAR WHEEL REMOVAL ● Support the motorcycle on the main stand. ● Remove the muffler. MUFFLER ● Remove the rear brake caliper assembly with brake hose from the rear swing arm. ● Loosen the rear axle nut. ● Remove the rear swing arm. REAR SWING ARM ● Remove the rear wheel inside collar. REAR WHEEL INSIDE COLLAR REAR WHEEL ● Remove the rear wheel. REAR BRAKE DISK 14-3
Page 3:
How to use this manual This manual
Page 6 and 7:
SERVICE INFORMATION 1,910mm 750mm 1
Page 8 and 9:
SERVICE INFORMATION 1-4
Page 10 and 11:
Page 12 and 13:
Page 14 and 15:
SERVICE INFORMATION GENERAL SAFETY
Page 16 and 17:
SERVICE INFORMATION 13. Check the s
Page 18 and 19:
SERVICE INFORMATION CAUTION WHEN WI
Page 20 and 21:
SERVICE INFORMATION •Insert the c
Page 22 and 23:
MEMO
Page 24 and 25:
INSPECTIONS/ADJUSTMENTS 2-2
Page 26 and 27:
INSPECTIONS/ADJUSTMENTS FUEL PUMP F
Page 28 and 29:
INSPECTIONS/ADJUSTMENTS TIMINCT HOl
Page 30 and 31:
INSPECTIONS/ADJUSTMENTS MASTER CYLI
Page 32 and 33:
INSPECTIONS/ADJUSTMENTS TIRE PRESSU
Page 34 and 35:
MEMO
Page 36 and 37:
EXTERNAL PARTS MAINTENANCE PROCEDUR
Page 38 and 39:
EXTERNAL PARTS SPEEDOMETER ●Remov
Page 40 and 41:
EXTERNAL PARTS SPECIAL SCREW REAR U
Page 42 and 43:
EXTERNAL PARTS ●Remove the inner
Page 44 and 45:
MEMO
Page 46 and 47:
LUBRICATION SYSTEM Inclusion of wat
Page 48 and 49:
LUBRICATION SYSTEM FLANGE BOLTS OIL
Page 50 and 51:
LUBRICATION SYSTEM INNER ROTOR OUTE
Page 52 and 53:
LUBRICATION SYSTEM RADIATOR OIL CHE
Page 54 and 55:
EMS(Engine Management System) 1. CA
Page 56 and 57:
EMS(Engine Management System) 3. TE
Page 58 and 59:
EMS(Engine Management System) FAIL-
Page 60 and 61:
EMS(Engine Management System) HOW T
Page 62 and 63:
EMS(Engine Management System) HOW T
Page 64 and 65:
EMS(Engine Management System) CENTE
Page 66 and 67:
EMS(Engine Management System) DISAS
Page 68 and 69:
EMS(Engine Management System) INJEC
Page 70 and 71:
EMS(Engine Management System) MAPAT
Page 72 and 73:
EMS(Engine Management System) Check
Page 74 and 75:
EMS(Engine Management System) 10. T
Page 76 and 77:
EMS(Engine Management System) Check
Page 78 and 79:
EMS(Engine Management System) 1)CHE
Page 80 and 81:
EMS(Engine Management System) ISA I
Page 82 and 83:
EMS(Engine Management System) CHECK
Page 84 and 85:
EMS(Engine Management System) 1) CH
Page 86 and 87:
EMS(Engine Management System) 14.CH
Page 88 and 89:
EMS(Engine Management System) ● C
Page 90 and 91:
EMS(Engine Management System) 4) Ch
Page 92 and 93:
EMS(Engine Management System) FUEL
Page 94 and 95:
EMS(Engine Management System) 17.HO
Page 96 and 97:
Page 98 and 99:
Page 100 and 101:
MEMO
Page 102 and 103:
FUEL SYSTEM TROUBLESHOOTING The veh
Page 104 and 105:
FUEL SYSTEM THROTTLE CABLE LOCK NUT
Page 106 and 107:
FUEL SYSTEM ● Remove the main jet
Page 108 and 109:
FUEL SYSTEM COMPRESS STRAIGHT ! NOT
Page 110 and 111:
FUEL SYSTEM When idling, check to
Page 112 and 113:
FUEL SYSTEM ● Check the gaskets.
Page 114 and 115:
ENGINE REMOVAL/INSTALLATION DRAIN P
Page 116 and 117:
LH. CRANKCASE COVER/CONTINUOUSLY VA
Page 118 and 119:
LH.CRANK CASE COVER/CONTINUOUSLY VA
Page 120 and 121:
Page 122 and 123:
Page 124 and 125:
Page 126 and 127:
Page 128 and 129:
Page 130 and 131:
A.C GENERATOR / STARTER CLUTCH STAR
Page 132 and 133:
A.C GENERATOR / STARTER CLUTCH SAI
Page 134 and 135:
Page 136 and 137:
A.C GENERATOR / STARTER CLUTCH REDU
Page 138 and 139:
Page 140 and 141:
CYLINDER HEAD / VALVES FLANGE NUT I
Page 142 and 143: CYLINDER HEAD / VALVES TOOLS VALVE
Page 144 and 145: CYLINDER HEAD / VALVES ● Remove t
Page 146 and 147: CYLINDER HEAD / VALVES ● Remove t
Page 148 and 149: CYLINDER HEAD / VALVES VALVE GUIDE
Page 150 and 151: CYLINDER HEAD / VALVES ● Using a
Page 152 and 153: CYLINDER HEAD / VALVES ● Tap the
Page 154 and 155: CYLINDER HEAD / VALVES CAM SHAFT
Page 156 and 157: CYLINDER / PISTON CYLINDER TOP RING
Page 158 and 159: CYLINDER / PISTON CYLINDER CYLINDER
Page 160 and 161: CYLINDER / PISTON 11-4
Page 162 and 163: CYLINDER / PISTON CYLINDER GASKET P
Page 164 and 165: TRANSMISSION/CRANKSHAFT/CRANK CASE
Page 176 and 177: FRONT WHEEL/FRONT FORK/STEERING STE
Page 178 and 179: FRONT WHEEL/FRONT FORK/STEERING TRO
Page 180 and 181: FRONT WHEEL/FRONT FORK/STEERING STE
Page 182 and 183: FRONT WHEEL/FRONT FORK/STEERING SPE
Page 184 and 185: FRONT WHEEL/FRONT FORK/STEERING ●
Page 186 and 187: FRONT WHEEL/FRONT FORK/STEERING FRO
Page 188 and 189: FRONT WHEEL/FRONT FORK/STEERING FOR
Page 190 and 191: REAR WHEEL/SUSPENSION/REAR SWING AR
Page 198 and 199: MEMO
Page 200 and 201: BRAKE SYSTEM 15-0
Page 202 and 203: BRAKE SYSTEM TROUBLESHOOTING Brake
Page 204 and 205: BRAKE SYSTEM BREEDER VALVE BREEDER
Page 206 and 207: BRAKE SYSTEM RR. CALIPER LOCK PLATE
Page 208 and 209: BRAKE SYSTEM LH CALIPER BODY HANGER
Page 210 and 211: BRAKE SYSTEM CALIPER COMP RH.SIM(DC
Page 212 and 213: BRAKE SYSTEM PISTON INSPECTION ●
Page 214 and 215: CHARGING SYSTEM 15A 16-0
Page 216 and 217: CHARGING SYSTEM TROUBLESHOOTING No
Page 218 and 219: CHARGING SYSTEM AMPERE METER BATTER
Page 220 and 221: IGNITION SYSTEM IGNITION SYSYTEM SI
Page 222 and 223: IGNITION SYSTEM TROUBLESHOOTING No
Page 224 and 225: IGNITION SYSTEM IGNITION COIL INSPE
Page 226 and 227: STARTER SYSTEM STARTER SYSTEM CABLE
Page 228 and 229: STARTER SYSTEM TROUBLESHOOTING Star
Page 230 and 231: STARTER SYSTEM BRUSH ● Remove the
Page 232 and 233: STARTER SYSTEM STARTER MAGNETIC SWI
Page 234 and 235: MEMO
Page 236 and 237: LIGHTS/SWITCHES/HORN HEAD LIGHT HEA
Page 238 and 239: LIGHTS/SWITCHES/HORN MAIN SWITCH MA
Page 240 and 241: LIGHTS/SWITCHES/HORN FUEL TANK FUEL
Page 242 and 243:
MEMO
Page 244 and 245:
20-2. WIRING DIAGRAM (EURO-3) WIRIN
Page 246:
SM57-0902-01E
show all

Daelim B-Bone 125cc service manual.pdf - Mojo

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?