Daelim B-Bone 125cc service manual.pdf - Mojo

More documents

Recommendations

Info

EMS(Engine Management System) INJECTOR CAP INJECTOR 8. INJECTOR REMOVE ● Turn off the ignition key. ● Disconnect the injector coupler. △! CAUTION ● Before disassemble, the key is off. ● Loosen the injector cap bolt. FLANGE BOLT INJECTOR ● Disconnect the injector. ! NOTICE ●Be sure to check the engine is cooling because a little gasoline remains, It could be still hot. ●Be sure to inject the gasoline, after remove the coupler from the ignition coil. It could be damaged for the fire, sparked on the spark plug. ASSEMBLY ● Assemble is the reverse order of removal. 5-16
EMS(Engine Management System) CHECKING METHODS BY FAULT CODES Checking of the Injector circuit The fault code is displayed by MIL Checking Circuit ECU 40 : INJECTOR control 39 : FUEL PUMP control INJECTOR FUEL PUMP RELAY Coupler terminal is based on wire harness. Checking Procedure 1) Turn off the ignition key. 2) Check to see if the injector coupler has come loose or the wire is peeling off. If there is no problem, measured the resistance of injector. 3)Disassemble the injector coupler and measure the resistance between injector terminals. The resistance of injector : 14.5±0.7[ ], 20 Remarks : measuring unit for resistance : resistance ‘ R ‘ [ ] 4)If there is no problem, check the continuity between each terminal and ground. The resistance between each terminal and ground : ∞[ ] If resistance value is not normal, replace injector with the new one. 5)If the resistance is normal, turns on the ignition key - If the fuel pump operated for 3 seconds, the power supply relay of injector is normal. 6) Measure between the voltage of coupler. Measuring terminal : BLACK/RED electric wire ~ ground Measuring voltage : battery voltage – 1.0[V]over Remarks : Measuring unit of voltage : voltage [V] 7) If the measured voltage is normal, Check the ‘Blue/Yellow’ electric wire to see if they have been broken or have short-circuited or if the wire-harness coupler and the ECU coupler are a bad contact (ECU terminal No. 40) If there is no problem in the electric wires, ECU is broken Replace the ECU with new one, it rechecks 8) If the measured voltage is not normal, Check the Black/Red electric wire to see if they have been broken or have short-circuited. Check the fuel pump relay. 9) After fault repaired, to erase the memorized fault code in the ECU is refer to how to remove the fault code(5-10). 5-17
Page 3:
How to use this manual This manual
Page 6 and 7:
SERVICE INFORMATION 1,910mm 750mm 1
Page 8 and 9:
SERVICE INFORMATION 1-4
Page 10 and 11:
Page 12 and 13:
Page 14 and 15:
SERVICE INFORMATION GENERAL SAFETY
Page 16 and 17:
SERVICE INFORMATION 13. Check the s
Page 18 and 19: SERVICE INFORMATION CAUTION WHEN WI
Page 20 and 21: SERVICE INFORMATION •Insert the c
Page 22 and 23: MEMO
Page 24 and 25: INSPECTIONS/ADJUSTMENTS 2-2
Page 26 and 27: INSPECTIONS/ADJUSTMENTS FUEL PUMP F
Page 28 and 29: INSPECTIONS/ADJUSTMENTS TIMINCT HOl
Page 30 and 31: INSPECTIONS/ADJUSTMENTS MASTER CYLI
Page 32 and 33: INSPECTIONS/ADJUSTMENTS TIRE PRESSU
Page 36 and 37: EXTERNAL PARTS MAINTENANCE PROCEDUR
Page 38 and 39: EXTERNAL PARTS SPEEDOMETER ●Remov
Page 40 and 41: EXTERNAL PARTS SPECIAL SCREW REAR U
Page 42 and 43: EXTERNAL PARTS ●Remove the inner
Page 46 and 47: LUBRICATION SYSTEM Inclusion of wat
Page 48 and 49: LUBRICATION SYSTEM FLANGE BOLTS OIL
Page 50 and 51: LUBRICATION SYSTEM INNER ROTOR OUTE
Page 52 and 53: LUBRICATION SYSTEM RADIATOR OIL CHE
Page 54 and 55: EMS(Engine Management System) 1. CA
Page 56 and 57: EMS(Engine Management System) 3. TE
Page 58 and 59: EMS(Engine Management System) FAIL-
Page 60 and 61: EMS(Engine Management System) HOW T
Page 62 and 63: EMS(Engine Management System) HOW T
Page 64 and 65: EMS(Engine Management System) CENTE
Page 66 and 67: EMS(Engine Management System) DISAS
Page 70 and 71: EMS(Engine Management System) MAPAT
Page 72 and 73: EMS(Engine Management System) Check
Page 74 and 75: EMS(Engine Management System) 10. T
Page 76 and 77: EMS(Engine Management System) Check
Page 78 and 79: EMS(Engine Management System) 1)CHE
Page 80 and 81: EMS(Engine Management System) ISA I
Page 82 and 83: EMS(Engine Management System) CHECK
Page 84 and 85: EMS(Engine Management System) 1) CH
Page 86 and 87: EMS(Engine Management System) 14.CH
Page 88 and 89: EMS(Engine Management System) ● C
Page 90 and 91: EMS(Engine Management System) 4) Ch
Page 92 and 93: EMS(Engine Management System) FUEL
Page 94 and 95: EMS(Engine Management System) 17.HO
Page 102 and 103: FUEL SYSTEM TROUBLESHOOTING The veh
Page 104 and 105: FUEL SYSTEM THROTTLE CABLE LOCK NUT
Page 106 and 107: FUEL SYSTEM ● Remove the main jet
Page 108 and 109: FUEL SYSTEM COMPRESS STRAIGHT ! NOT
Page 110 and 111: FUEL SYSTEM When idling, check to
Page 112 and 113: FUEL SYSTEM ● Check the gaskets.
Page 114 and 115: ENGINE REMOVAL/INSTALLATION DRAIN P
Page 116 and 117: LH. CRANKCASE COVER/CONTINUOUSLY VA
Page 118 and 119:
LH.CRANK CASE COVER/CONTINUOUSLY VA
Page 120 and 121:
Page 122 and 123:
Page 124 and 125:
Page 126 and 127:
Page 128 and 129:
Page 130 and 131:
A.C GENERATOR / STARTER CLUTCH STAR
Page 132 and 133:
A.C GENERATOR / STARTER CLUTCH SAI
Page 134 and 135:
Page 136 and 137:
A.C GENERATOR / STARTER CLUTCH REDU
Page 138 and 139:
Page 140 and 141:
CYLINDER HEAD / VALVES FLANGE NUT I
Page 142 and 143:
CYLINDER HEAD / VALVES TOOLS VALVE
Page 144 and 145:
CYLINDER HEAD / VALVES ● Remove t
Page 146 and 147:
CYLINDER HEAD / VALVES ● Remove t
Page 148 and 149:
CYLINDER HEAD / VALVES VALVE GUIDE
Page 150 and 151:
CYLINDER HEAD / VALVES ● Using a
Page 152 and 153:
CYLINDER HEAD / VALVES ● Tap the
Page 154 and 155:
CYLINDER HEAD / VALVES CAM SHAFT
Page 156 and 157:
CYLINDER / PISTON CYLINDER TOP RING
Page 158 and 159:
CYLINDER / PISTON CYLINDER CYLINDER
Page 160 and 161:
CYLINDER / PISTON 11-4
Page 162 and 163:
CYLINDER / PISTON CYLINDER GASKET P
Page 164 and 165:
TRANSMISSION/CRANKSHAFT/CRANK CASE
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Page 176 and 177:
FRONT WHEEL/FRONT FORK/STEERING STE
Page 178 and 179:
FRONT WHEEL/FRONT FORK/STEERING TRO
Page 180 and 181:
FRONT WHEEL/FRONT FORK/STEERING STE
Page 182 and 183:
FRONT WHEEL/FRONT FORK/STEERING SPE
Page 184 and 185:
FRONT WHEEL/FRONT FORK/STEERING ●
Page 186 and 187:
FRONT WHEEL/FRONT FORK/STEERING FRO
Page 188 and 189:
FRONT WHEEL/FRONT FORK/STEERING FOR
Page 190 and 191:
REAR WHEEL/SUSPENSION/REAR SWING AR
Page 192 and 193:
Page 194 and 195:
Page 196 and 197:
Page 198 and 199:
MEMO
Page 200 and 201:
BRAKE SYSTEM 15-0
Page 202 and 203:
BRAKE SYSTEM TROUBLESHOOTING Brake
Page 204 and 205:
BRAKE SYSTEM BREEDER VALVE BREEDER
Page 206 and 207:
BRAKE SYSTEM RR. CALIPER LOCK PLATE
Page 208 and 209:
BRAKE SYSTEM LH CALIPER BODY HANGER
Page 210 and 211:
BRAKE SYSTEM CALIPER COMP RH.SIM(DC
Page 212 and 213:
BRAKE SYSTEM PISTON INSPECTION ●
Page 214 and 215:
CHARGING SYSTEM 15A 16-0
Page 216 and 217:
CHARGING SYSTEM TROUBLESHOOTING No
Page 218 and 219:
CHARGING SYSTEM AMPERE METER BATTER
Page 220 and 221:
IGNITION SYSTEM IGNITION SYSYTEM SI
Page 222 and 223:
IGNITION SYSTEM TROUBLESHOOTING No
Page 224 and 225:
IGNITION SYSTEM IGNITION COIL INSPE
Page 226 and 227:
STARTER SYSTEM STARTER SYSTEM CABLE
Page 228 and 229:
STARTER SYSTEM TROUBLESHOOTING Star
Page 230 and 231:
STARTER SYSTEM BRUSH ● Remove the
Page 232 and 233:
STARTER SYSTEM STARTER MAGNETIC SWI
Page 234 and 235:
MEMO
Page 236 and 237:
LIGHTS/SWITCHES/HORN HEAD LIGHT HEA
Page 238 and 239:
LIGHTS/SWITCHES/HORN MAIN SWITCH MA
Page 240 and 241:
LIGHTS/SWITCHES/HORN FUEL TANK FUEL
Page 242 and 243:
MEMO
Page 244 and 245:
20-2. WIRING DIAGRAM (EURO-3) WIRIN
Page 246:
SM57-0902-01E
show all

Daelim B-Bone 125cc service manual.pdf - Mojo

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?