Daelim B-Bone 125cc service manual.pdf - Mojo

More documents

Recommendations

Info

EMS(Engine Management System) 4) Check if crank signal A,B wires is breaks or not. Remove the ECU, connect wire harness for inspection to wire harness of vehicle. Check the wiring of crank signal A - Measure terminal : No. 30 pin of wire harness for inspection - Red wire of coupler of CKP. - Measuring resistance : 0 ~ 1[] Red CKP_B CKP_A 1 2 Check the wiring of crank signal B - Measure terminal : No. 22 pin of wire harness for inspection - Blue wire of coupler of CKP. - Measuring resistance : 0 ~ 1[] CKP_B CKP_A 1 2 Blue 5) After fault repaired, to erase the memorized fault code in the ECU is refer to how to remove the fault code(5-10) 5-38
EMS(Engine Management System) FUEL FILLER CAP 16. FUEL PUMP REMOVE ● Fuel pump is located inside the fuel tank. ● Remove the fuel filler cap. ● Remove the floor panel. △! CAUTION ● Make sure that the key is off before assembly. ● Remove the fuel hose. ● Remove the fuel pump coupler. FUEL TUBE FUEL PUMP COUPLER FUEL PUMP SETTING PLACE ● Loosen the 4 fuel pump setting place screws. SCREW ● Remove the fuel pump. 5-39
Page 3:
How to use this manual This manual
Page 6 and 7:
SERVICE INFORMATION 1,910mm 750mm 1
Page 8 and 9:
SERVICE INFORMATION 1-4
Page 10 and 11:
Page 12 and 13:
Page 14 and 15:
SERVICE INFORMATION GENERAL SAFETY
Page 16 and 17:
SERVICE INFORMATION 13. Check the s
Page 18 and 19:
SERVICE INFORMATION CAUTION WHEN WI
Page 20 and 21:
SERVICE INFORMATION •Insert the c
Page 22 and 23:
MEMO
Page 24 and 25:
INSPECTIONS/ADJUSTMENTS 2-2
Page 26 and 27:
INSPECTIONS/ADJUSTMENTS FUEL PUMP F
Page 28 and 29:
INSPECTIONS/ADJUSTMENTS TIMINCT HOl
Page 30 and 31:
INSPECTIONS/ADJUSTMENTS MASTER CYLI
Page 32 and 33:
INSPECTIONS/ADJUSTMENTS TIRE PRESSU
Page 34 and 35:
MEMO
Page 36 and 37:
EXTERNAL PARTS MAINTENANCE PROCEDUR
Page 38 and 39:
EXTERNAL PARTS SPEEDOMETER ●Remov
Page 40 and 41: EXTERNAL PARTS SPECIAL SCREW REAR U
Page 42 and 43: EXTERNAL PARTS ●Remove the inner
Page 44 and 45: MEMO
Page 46 and 47: LUBRICATION SYSTEM Inclusion of wat
Page 48 and 49: LUBRICATION SYSTEM FLANGE BOLTS OIL
Page 50 and 51: LUBRICATION SYSTEM INNER ROTOR OUTE
Page 52 and 53: LUBRICATION SYSTEM RADIATOR OIL CHE
Page 54 and 55: EMS(Engine Management System) 1. CA
Page 56 and 57: EMS(Engine Management System) 3. TE
Page 58 and 59: EMS(Engine Management System) FAIL-
Page 60 and 61: EMS(Engine Management System) HOW T
Page 62 and 63: EMS(Engine Management System) HOW T
Page 64 and 65: EMS(Engine Management System) CENTE
Page 66 and 67: EMS(Engine Management System) DISAS
Page 68 and 69: EMS(Engine Management System) INJEC
Page 70 and 71: EMS(Engine Management System) MAPAT
Page 72 and 73: EMS(Engine Management System) Check
Page 74 and 75: EMS(Engine Management System) 10. T
Page 76 and 77: EMS(Engine Management System) Check
Page 78 and 79: EMS(Engine Management System) 1)CHE
Page 80 and 81: EMS(Engine Management System) ISA I
Page 82 and 83: EMS(Engine Management System) CHECK
Page 84 and 85: EMS(Engine Management System) 1) CH
Page 86 and 87: EMS(Engine Management System) 14.CH
Page 88 and 89: EMS(Engine Management System) ● C
Page 92 and 93: EMS(Engine Management System) FUEL
Page 94 and 95: EMS(Engine Management System) 17.HO
Page 100 and 101: MEMO
Page 102 and 103: FUEL SYSTEM TROUBLESHOOTING The veh
Page 104 and 105: FUEL SYSTEM THROTTLE CABLE LOCK NUT
Page 106 and 107: FUEL SYSTEM ● Remove the main jet
Page 108 and 109: FUEL SYSTEM COMPRESS STRAIGHT ! NOT
Page 110 and 111: FUEL SYSTEM When idling, check to
Page 112 and 113: FUEL SYSTEM ● Check the gaskets.
Page 114 and 115: ENGINE REMOVAL/INSTALLATION DRAIN P
Page 116 and 117: LH. CRANKCASE COVER/CONTINUOUSLY VA
Page 118 and 119: LH.CRANK CASE COVER/CONTINUOUSLY VA
Page 130 and 131: A.C GENERATOR / STARTER CLUTCH STAR
Page 132 and 133: A.C GENERATOR / STARTER CLUTCH SAI
Page 136 and 137: A.C GENERATOR / STARTER CLUTCH REDU
Page 140 and 141:
CYLINDER HEAD / VALVES FLANGE NUT I
Page 142 and 143:
CYLINDER HEAD / VALVES TOOLS VALVE
Page 144 and 145:
CYLINDER HEAD / VALVES ● Remove t
Page 146 and 147:
CYLINDER HEAD / VALVES ● Remove t
Page 148 and 149:
CYLINDER HEAD / VALVES VALVE GUIDE
Page 150 and 151:
CYLINDER HEAD / VALVES ● Using a
Page 152 and 153:
CYLINDER HEAD / VALVES ● Tap the
Page 154 and 155:
CYLINDER HEAD / VALVES CAM SHAFT
Page 156 and 157:
CYLINDER / PISTON CYLINDER TOP RING
Page 158 and 159:
CYLINDER / PISTON CYLINDER CYLINDER
Page 160 and 161:
CYLINDER / PISTON 11-4
Page 162 and 163:
CYLINDER / PISTON CYLINDER GASKET P
Page 164 and 165:
TRANSMISSION/CRANKSHAFT/CRANK CASE
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Page 176 and 177:
FRONT WHEEL/FRONT FORK/STEERING STE
Page 178 and 179:
FRONT WHEEL/FRONT FORK/STEERING TRO
Page 180 and 181:
FRONT WHEEL/FRONT FORK/STEERING STE
Page 182 and 183:
FRONT WHEEL/FRONT FORK/STEERING SPE
Page 184 and 185:
FRONT WHEEL/FRONT FORK/STEERING ●
Page 186 and 187:
FRONT WHEEL/FRONT FORK/STEERING FRO
Page 188 and 189:
FRONT WHEEL/FRONT FORK/STEERING FOR
Page 190 and 191:
REAR WHEEL/SUSPENSION/REAR SWING AR
Page 192 and 193:
Page 194 and 195:
Page 196 and 197:
Page 198 and 199:
MEMO
Page 200 and 201:
BRAKE SYSTEM 15-0
Page 202 and 203:
BRAKE SYSTEM TROUBLESHOOTING Brake
Page 204 and 205:
BRAKE SYSTEM BREEDER VALVE BREEDER
Page 206 and 207:
BRAKE SYSTEM RR. CALIPER LOCK PLATE
Page 208 and 209:
BRAKE SYSTEM LH CALIPER BODY HANGER
Page 210 and 211:
BRAKE SYSTEM CALIPER COMP RH.SIM(DC
Page 212 and 213:
BRAKE SYSTEM PISTON INSPECTION ●
Page 214 and 215:
CHARGING SYSTEM 15A 16-0
Page 216 and 217:
CHARGING SYSTEM TROUBLESHOOTING No
Page 218 and 219:
CHARGING SYSTEM AMPERE METER BATTER
Page 220 and 221:
IGNITION SYSTEM IGNITION SYSYTEM SI
Page 222 and 223:
IGNITION SYSTEM TROUBLESHOOTING No
Page 224 and 225:
IGNITION SYSTEM IGNITION COIL INSPE
Page 226 and 227:
STARTER SYSTEM STARTER SYSTEM CABLE
Page 228 and 229:
STARTER SYSTEM TROUBLESHOOTING Star
Page 230 and 231:
STARTER SYSTEM BRUSH ● Remove the
Page 232 and 233:
STARTER SYSTEM STARTER MAGNETIC SWI
Page 234 and 235:
MEMO
Page 236 and 237:
LIGHTS/SWITCHES/HORN HEAD LIGHT HEA
Page 238 and 239:
LIGHTS/SWITCHES/HORN MAIN SWITCH MA
Page 240 and 241:
LIGHTS/SWITCHES/HORN FUEL TANK FUEL
Page 242 and 243:
MEMO
Page 244 and 245:
20-2. WIRING DIAGRAM (EURO-3) WIRIN
Page 246:
SM57-0902-01E
show all

Daelim B-Bone 125cc service manual.pdf - Mojo

Create successful ePaper yourself

Delete template?

Save as template?