bangladesh power development board tender document for ... - BPDB

More documents

Recommendations

Info

d. Cost of HFO = Tk 26.00 per Litere. Heat rate to be used for weighted average of 50%, 75% and 100 % loadunder Site ConditionSo H = H 100% x 0.8 + H 75% x 0.1 + H 50% x 0.1 KJ per Kwhf. Operation and Maintenance cost, O p = Tk 0.50 per kWh + Lub oil consumptioncost per kWhg. Discount rate on capital investment - 15%(iv)Example of Financial Analysis:(1) Po = Total Net generated output at low voltage side of step-up transformer atSite Condition in kWEP 0 = Annual generated energy at low voltage side of step-up transformer in Kwh= P 0 x 24 x 365 x 0.3 KwhH = Average weighted heat rate of generating unit(100%, 75% and 50% load at Site Condition) in KJ / kWH= H 100% x 0.8+ H 75% x 0.1 + H 50% x 0.1 KJ per KwhHc = Annual heat consumption= H x EP 0 in KJFuel Calorific Value (LHV) of HFO fc = 40,450 kJ/litAnnual fuel consumption =H c / f c , Liter = F aF AC = Annual fuel cost = Tk 26.00 × F aCa = Annual operating and maintenance cost = O p x EP 0(2) A= First cost including the cost of essential spares as described in the TenderDocuments, converted into Taka by applying the Exchange Rate as specified.(3) d = Discount rate= 15% per annum(4) D= Estimated weighted days for completion of the power plant= 450 days(5) C T = Capitalised cost of transformer loss= [(1+r) n –1] × t × e (P 0 +0.35 P FL )r (1+r) nwhere, C T = Capitalised cost of transformer loss in Bangladesh Takar = Discount rate, 15%n = Years of service life,15 yearst = Operating hours in a year, 8760 hourse = Cost of energy, Taka 2.38 per KwhP 0 = No load loss in KWP FL = Full load loss at ONAF condition in KWL.F. (Load Factor) = 0.3524
(vi) Am = First cost in Taka= A + C TThe evaluated total cost of the power plant, Te is calculated as shown in Table:1 below.Finally the evaluated cost of the power plant in Taka/kW will be found out bydividing Te by the net plant capacity, Po in kW at Site conditions. This is T. Thetenderer whose T value is the lowest will be adjudged the lowest tenderer.Table.1 :YearInTakaFirst CostIn TakaEnergyGeneratedIn TakaFuelCostIn TakaO&M Costper yearIn TakaDiscounted Totalcost per YearIn Taka1. AmEP 0 Fac Ca (Am+Fac+Ca)/(1+d)2. EP 0 Fac Ca (Fac+Ca)/(1+d) 23. EP 0 Fac Ca (Fac+Ca)/(1+d) 34. EP 0 Fac Ca (Fac+Ca)/(1+d) 45. EP 0 Fac Ca (Fac+Ca)/(1+d) 56. EP 0 Fac Ca (Fac+Ca)/(1+d) 67. EP 0 Fac Ca (Fac+Ca)/(1+d) 78. EP 0 Fac Ca (Fac+Ca)/(1+d) 89. EP 0 Fac Ca (Fac+Ca)/(1+d) 910. EP 0 Fac Ca (Fac+Ca)/(1+d) 1011. EP 0 Fac Ca (Fac+Ca)/(1+d) 1112. EP 0 Fac Ca (Fac+Ca)/(1+d) 1213. EP 0 Fac Ca (Fac+Ca)/(1+d) 1314. EP 0 Fac Ca (Fac+Ca)/(1+d) 1415.EP 0 Fac Ca (Fac+Ca)/(1+d) 15Total : Te =26.0 EXCHANGE RATEFor comparison of Proposals, the Board shall convert all the currencies exceptingBangladesh currency quoted by the Tenderers into Bangladesh Taka. Such25
Page 1 and 2: BANGLADESH POWER DEVELOPMENT BOARDT
Page 3 and 4: 14. Name and address ofthe Office f
Page 5 and 6: Bangladesh Power Development BoardC
Page 7 and 8: 32.01 Termination for Convenience -
Page 9 and 10: 27.1 Service Engineers After Warran
Page 11 and 12: Rejection of TendersThe Tender shal
Page 13 and 14: a) Volume 1 Chapter 1: Instruction
Page 15 and 16: to establish the Tenderer's minimum
Page 17 and 18: 10.0 INFORMATION TO BE SUPPLIED WIT
Page 19 and 20: xix)xx)xxi)A list of plant equipmen
Page 21 and 22: v) The Tenderer may submit cost sav
Page 23: Specifications of the equipment/mat
Page 27 and 28: the contract conditions. The Perfor
Page 29 and 30: (2) Any effort by a Tenderer to inf
Page 31 and 32: APPENDIX-2FORM OF TENDER(SPECIMEN)S
Page 33 and 34: Appendix-3Bill of Materials/Quantit
Page 35 and 36: Sl. No Item Name QtyA1.5COUPLINGFle
Page 37 and 38: Sl. No Item Name QtyA2.1.2hallPipin
Page 39 and 40: Sl. No Item Name Qtyengine hallLubr
Page 41 and 42: Sl. No Item Name QtyExhaust gas boi
Page 43 and 44: Sl. No Item Name QtyA4.1.8 Suspensi
Page 45 and 46: Sl. No Item Name Qty- UPS for unit
Page 47 and 48: Schedule-2Erection & CommissioningS
Page 49 and 50: Sl No Description QtyUtility block
Page 51 and 52: Sl No Description QtyEarthworks and
Page 53 and 54: Sl No Description Qty3F3GSITE WORKS
Page 55 and 56: Schedule-5Long Term Service Agreeme
Page 57 and 58: APPENDIX-4TIME SCHEDULEManufacture,
Page 59 and 60: Our liability under this guarantee
Page 61 and 62: eference made a part thereof. This
Page 63 and 64: Appendix-7COMPLAINTS AND APPEALSIn
Page 65 and 66: 1.0 CONTRACT DOCUMENTSCHAPTER II :
Page 67 and 68: xiv)xv)xvi)xvii)xviii)xix)xx)xxi)xx
Page 69 and 70: commissioning including all other w
Page 71 and 72: suitable access for equipment and m
Page 73 and 74: The Engineer's decision and the fil
Page 75 and 76:
shall not be again employed upon th
Page 77 and 78:
(b)(c)(d)The right of the Board to
Page 79 and 80:
of the Contractor, afford all avail
Page 81 and 82:
32.0 RIGHT OF BOARD TO TERMINATE CO
Page 83 and 84:
Contractor's control to be intimate
Page 85 and 86:
The Contractor shall comply with su
Page 87 and 88:
initial commercial operation (ICO)
Page 89 and 90:
49.0 CLEAN UP OF SITEThe Contractor
Page 91 and 92:
on account of failure to achieve gu
Page 93 and 94:
employees or any of the employees o
Page 95 and 96:
eplacement of any materials lost or
Page 97 and 98:
portion of such payment. Any sum re
Page 99 and 100:
2. Engineer 1 Copy3. Director, Dte.
Page 101 and 102:
Each part of the equipment which is
Page 103 and 104:
the practical arrangements he is of
Page 105 and 106:
Chapter IIISpecial Conditions105
Page 107 and 108:
a. The drawings showing the arrange
Page 109 and 110:
The Contractor shall erect temporar
Page 111 and 112:
The Contractor shall be responsible
Page 113 and 114:
The Contractor shall ensure that no
Page 115 and 116:
19.0 FIRE PROTECTIONOnly constructi
Page 117 and 118:
actions of the Board or the employe
Page 119 and 120:
29.0 OPEPATING AND MAINTENANCE INST
show all

bangladesh power development board tender document for ... - BPDB

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?